The bearings on the crank shaft witch caused a lifter to fail and bent a rod witch caused it to become jamed in crank shaft. Engine faild at speed of 55-65 independent service center confirmed the problem no other warring lights came on untill engine failed
2019 Chevrolet Silverado 1500 engine complaints
Page 9 of 15: complaints 221 to 250 of 424, newest first, as owners wrote them.
I am writing to express my concern regarding a serious issue with my 2019 Chevy Silverado. Recently, while driving on the highway, I experienced a sudden loss of power. After diagnosing the issue, I was informed that my engine now requires a full replacement. This comes shortly after I had the camshaft replaced. My truck has only 80,000+ miles on it, which I believe is well below what should be expected for such a major failure. I have maintained the vehicle according to recommended service schedules and was surprised by this issue. Chevy has quoted me approximately $15,000 for the engine replacement, which is an extraordinary expense given the mileage and service history of the vehicle. I am seeking assistance in resolving this matter, as I believe this type of failure should not occur under normal conditions with such low mileage. Please let me know what steps can be taken or if there is any warranty or goodwill support available. Thank you for your time and attention to this matter.
Truck rev high without much acceleration Clunking noise when accelerating Hard shifting Shuttering
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while driving at an undisclosed speed, the engine seized. No warning lights were illuminated. The vehicle failed to restart as intended. The vehicle was towed to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was repaired. In addition, the contact stated that the Carfax report indicated that the engine was replaced two times by the previous owner. The contact stated that the engine replacements were performed prior to the contact purchasing the vehicle; however, the new engine failed at 20,000 miles. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 79,561.
Lifter roller seized causing damage to the camshaft lobe. Problem has occurred in many other vehicles with the 5.3L L84 engine No warnings before issue occurred.
I had a problem with the truck start to make noises and shaking complete then i put on a flat bed and take to the dealership to make a diagnosis and the dealership told me that is complete failure of the engine and that i have to replace so they order a new engine and they installed so they charge me around 11000 dollars
I was passing a line of vehicles when a semi started over into my lane. I hit the gas, to avoid being hit by the truck. When I did warning light on my vehicle appeared on the display. I lost speed and immediately heard a loud knocking from the engine. I was on an open 4 lane highway and knew there was a dealer close by. I drove to the dealership, I left the vehicle running so they could hear it. The service tech told me they had seen "several" vehicles in with the same problem with the 5.3L . I left the vehicle there and was given a loaner. They told me the lifter had gone bad when I sped up quickly, and the camshaft was damaged. Further research by me has discovered a lot of vehicles have this same issue due to the active fuel management system. I chose not to pay Chevrolet $7000 to fix the engine, and currently have it in a private shop being repaired. A less experienced driver may have slammed on the brakes or swerved and caused a major accident. My vehicle did slow down on its own, but I was able to keep control and safely maneuver to the right lane.
Unexpected loss of power. Issues with bearings caused cam to get damaged leading to required engine replacement.
Engine lost power while driving. Was able to make it to the dealer. They stated that the lifters were shredded and the camshaft was damaged so the engine had to be replaced along with the radiator due metal shavings found everywhere. Vehicle was maintain at the dealership and only had 95000 miles. Dealer did not offer any assistance and GM only offered 10% off. Purchased engine on my own and had installed.
engine replacement at 60k miles due to metal pieces broken down and shredded in engine, happened while driving. dealer replaced engine because i had extended warranty. Few months later the transmission failed and they replace with a brand new transmission because i had extended warranty. Now 15k miles later my wheels randomly lock up when turning corners. very dangerous. I can dig for every fine detail and time stamps and paper tail but i saw article on gm issues with engine and wanted to share. they didn’t want me to come forward when all of this happened.
When taking off the car is shuddering and isn't excellerating as it should. Like it won't get into gear.
Vehicle has been maintained perfectly with full records. 99, 300 miles. Vehicle suddenly lost power at 55 mph, loud noise from the engine compartment. Immediately stopped and had the vehicle towed to the Chevrolet dealership. Diagnosed with DOD failure, required complete engine replacement. Explicitly told by this dealership and four others that I called for comparison price, stated that this is a known weakness, a known “defect” for years. It does seem very criminal to me that neither you nor GM/Chevrolet has not taken action on this known and very public issue. My cost was just over $13,000 +2 weeks rental $900, plus $300 towing.
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while driving at approximately 60 MPH, while depressing the accelerator pedal, there was an abnormal clicking sound coming from the from the engine compartment. The contact stated that the check engine warning light was illuminated. The contact drove the vehicle to a local dealer. The dealer diagnosed the vehicle and determined that a lifter had failed and had damaged the cam shaft. The dealer informed the contact that the engine was damaged and needed to be replaced. The vehicle was repaired. The contact researched online and related the failure to the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling); however, the VIN was not included. The manufacturer was informed of the failure. The failure mileage was 116,124.
GM 5.3 Liter V8 engines are known to have lifters lock up and bend push rods or destroy the camshaft resulting in engine replacement or rebuild. GM's fix is to replace the badly designed lifters with the exact same ones hoping that they will last past the warranty period thereby putting the entire cost of replacement on the owners. GM is well aware of the lifter issue but denies any responsibility. A simple google of 5.3 lifter failure will show thousands of complaints and experiences from various auto boards/pages. My Lifters went out while doing 75mph on the highways resulting in immediate slowdown with cars having to swerve to avoid hitting me while i pulled over to the side.
My engine misfired and is now no good. Only 90,000 miles and well maintained.
Engine misfires, cam and lifters failed suddenly. While driving
My 2019 Chevy Silverado started having a tapping/bang and loss of performance check engine light, out of the blue at 127,000 miles. Very similar to the issues of the just released recall on 2021-2024 Mechanic suspects it’s either cam/lifters and/or bearing rod issue Vehicle has NOT been repaired as of today 04/30/2025
The contact owns a 2019 Chevrolet Silverado 1500. While the contact's husband was driving at an undisclosed speed, there was an abnormal ticking sound coming from the vehicle. There were several unknown warning lights illuminated. The contact drove the vehicle to the shoulder of the road and the vehicle lost motive power. The contact stated that the vehicle failed to start as intended. The vehicle was towed to the contact's father's residence. The vehicle was then towed to the dealer where it was diagnosed with a fractured lifter and crank shaft failure. The contact was informed that the engine and the ECM needed to be replaced. The vehicle was being repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 110,000.
Lifter failure at 125,000 miles. Lifters replaced and #8 failed again after 7 miles. The truck went into a state of significant reduced power at the time this firat manifest. I was on the interstate and it could have easily resulted in an accident. GMC dealer quoted $10,700 for a new engine.
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated while driving at an undisclosed speed, the message "Pull Over Turn Off Vehicle Immediately" was displayed, and the vehicle lost motive power. The vehicle failed to restart and was towed to the dealer, who determined that the engine had seized. The dealer replaced the engine. The contact related the failure to the federal safety agency Action Number: PE25001 (Engine, Engine and Engine Cooling) and the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The manufacturer was made aware of the failure and advised the contact to file a complaint with the federal safety agency Hotline. The failure mileage was approximately 108,000.
In 2022 we experienced harsh shifting between gears and had dealership assess and they flushed the transmission. We were told other than that there is no remedy. The problem still persisted occasionally. Recently while driving the EPC light and check engine appeared as well as engine shacking and jerking. We’re broke down on side of busy highway. Getting it back into dealership preliminary testing is that there is engine misfire and transmission. Frustration that GM is in class action lawsuit for transmission issues and that we had it inspected before with being told nothing more can be done. Vehicle is currently in shop being diagnosed for repairs.
I had a lifter failure on 8/12/2024 with only 66,994 miles on the truck. Not only did I have lifter failure it also damaged the camshaft. It is documentation of this issue. I was at a stop light when the truck started what felt like bouncing and when I accelerated it hesitated then all my lights on the dashboard came on. Then I could hear a ticking sound and when I would come to a stop the engine felt like it went from forth gear to first gear and would slam into a stop. Then the SES light and Service traction light came on Yes, the problem was confirmed by a Chevrolet dealership and stated they have been having issues with this happening in 2020-2022 Silverado's and have seen it in the 2019 models as well. There was another Silverado same year also at the dealership for the exact same problem. Yes, the component was inspected at the service department at the dealership. No there was no warning of any kind
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, there was a burning oil odor detected. Additionally, the contact noticed that engine oil was leaking onto the ground. The vehicle was taken to an independent mechanic, who determined that the engine oil cooler lines were leaking. The mechanic replaced the engine oil cooler lines. The contact related the failure to Customer Satisfaction Program: N212326940 (Engine Oil Cooler Lines Detaching from Crimp); however, the vehicle was not included. The manufacturer was made aware of the failure and advised the contact to file a complaint with the federal safety agency Hotline. The failure mileage was approximately 50,000.
Driving on a farm to market road, I passed a slow dump truck, when I let off the gas, every light on my dash came on, I lost all power and my engine started knocking. I Had 60662 miles on it. I bought it with 442 miles on it. The rod bearing went out and threw the rod thru the block. Complete engine replacement. The issue is not only on the 6.2 motors, I know many 5.3 ecotec owners that have had this issue as well as me. gm file # 9-13551227044.
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while the vehicle was parked and turned off, the contact noticed that the engine oil cooler line was leaking fluid on the ground. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related to the failure of the Customer Satisfaction Program: N212326940 (Engine Oil Cooler Lines Detaching from Crimp); however, the vehicle was not included. The manufacturer was made aware of the failure, but informed the contact that the VIN was not included in the Customer Satisfaction Program. The failure mileage was approximately 100,000.
The contact owns a 2019 Chevrolet Silverado 1500. The contact stated that while driving 65 MPH, the traction control and another unknown warning light illuminated on the instrument panel. Despite the failure, the contact was able to drive the vehicle to the residence. The vehicle was then taken to a dealer where a diagnostic test was performed. The dealer replaced the fuel injectors, lifters, and the catalytic converter. The manufacturer was notified of the failure and extended the warranty on the vehicle and offered the contact reward points. The vehicle was repaired. The failure mileage was 110,000.
I own a 2023 Chevrolet Silverado 1500 with a 6.2 liter L87 engine that is currently part of class action lawsuits. While driving down the highway with a car full of passengers at around 75-80mph, the vehicle shut down and would not accelerate. Frantically from the left lane, I crossed traffic almost causing an accident multiple times, to the shoulder of the highway. I then called for a tow truck to tow the vehicle as it would not start. The vehicle was towed three hours later, to the dealer (Quirk Chevrolet) and I walked off of the highway with the group of people. We then ubered home. The dealer diagnosed some mechanical issues that they said were the issue and “repaired” the vehicle. I picked the vehicle up three days later. Three weeks after that I was driving down the highway at about the same speed, 75-80mph, and my vehicle shut off again and was unresponsive. I had to then cut across three lanes of traffic frantically again and I coasted off of the highway due to an off ramp being right there and me acting quickly. The vehicle was unable to start for about 20 minutes and when I finally got it started it was making a loud audible knocking noise. I shut it down and called for a tow truck to the same dealer I had it serviced at a few week prior. I got a call the following day stating my vehicle needed an engine replacement and that I was most likely going to have to wait four months or more for it. They stated that they did not have any loaner vehicles available for me due to four other 6.2L engines needing replacement and if they had any available in the coming months, they would all be midsize SUVs. They stated that there was nothing they could due to get me a truck and only a midsize was offered which would not be any time soon anyways. I called three other Chevy dealers in the area and they stated that they all had between 3-5 seized 6.2L engines in the shop. There were no warning signs prior to this happening minus the repairs stated above and maybe a tic
While driving down the interstate on cruise control with my son, my truck dash board lit up with no warning, service esc, service parking brake, check engine light flashing. The cruise control was disengaged and did not function. The truck began to run very rough.small amounts of White smoke where visible from the tail pipe. Acceleration was very hesitant. The codes were scanned and showed misfire on cylinder 1 and a rough idle code. The repair shop confirmed I had two failed lifters that destroyed my camshaft and send metal throughout my engine. The repair was to replace the entire engine.
I was getting on the freeway and all of a sudden a lost power and heard a loud clunking noise. I drove as fast as I could to get in a safe area. Afterwards I had my vehicle towed to my mechanic. They said engine failure and possibly transmission failure. They found metal shavings in the oil. I had changed it myself a few weeks prior. I then took it to a gm dealer. I was just outside my powertrain warranty at about 70k miles. They said the same thing. 24k to repair. I had to junk the vehicle.
The engine failed on me when i was driving was able to get off of road did not cause accident but left me stranded while i was out of town while working i had to replace engine cost me 14,371.00 i think this needs to be looked into my understanding this has happened to this motor alot and no sense in people paying this kind of money when you have only driven it 3000 since i have owned it
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Chevrolet Silverado 1500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history