At 2000 miles my truck developed a new “fluttering”, “ticking sound” once all cylinders reactivated as apart of the dynamic fuel management system. After bringing the truck to dealership, they proceeded to replace the lifters, the exhaust system twice, and performed a computer reflash. The truck was at the dealership for over 45 days within the first 6 months of ownership. After all the repairs, the sound is still audible and getting worse. In addition to this sound, at around 30,000 miles the transmission has now developed an audible clunking sound that can be felt once on release the gas peddle under slower operating speeds. After trying to engage with GM on simply understanding what the problem is and why there is the need for so much repair on a brand new vehicle, I am candidly fed up and let down as long term GM customer.
2021 Chevrolet Silverado 1500 engine complaints
Page 10 of 16: complaints 251 to 280 of 453, newest first, as owners wrote them.
At 38,000 miles: While driving, the engine began knocking, vibrating and shut off. The check engine light came on and the vehicle could not be restarted. It was towed to the dealer who diagnosed it with lifter failure. It was still under the powertrain warranty at this time. Several lifters were replaced as well as other engine parts and I was given the truck back after a few weeks. A week later, truck would not start. After looking under the hood I noticed most of the hoses and wires were not clipped off, causing them to just rattle and move around. Upon further investigation, I found that the wire to the starter was loose and had to be wiggled to get the truck to start. This wire should have been secured to the vehicle with the provided clips, but it was not and came loose because of it. I also found a random loose bolt lying in a void space under the hood near the windshield. I took the truck back to the dealership that replaced the lifters and explained my frustration with the condition my truck was put back together after tearing into the engine. I also showed them the random bolt I found. Their manager assured me that they would go through the engine compartment and make sure that the wires and cables were properly secured to the side like it should have been after the initial engine work. I never received an explanation of where the random bolt came from. After this engine work, my truck never seemed to drive the same. It began use more oil and the fuel MPG decreased. I reported to the dealer on the oil consumption and they had me start an oil consumption test. 600 miles after the oil change my engine light came on, truck began to run rough and make a loud engine rattle noise. I took it back to the dealer for a diagnosis. They called back and said that there was a lot of metal in my oil when they drained it. They contacted GM and are scheduled to open the engine up to find out if it can be fixed or needs a new engine. Currently at 52000 miles
The truck, while driving at highway speeds on the interstate, experienced catastrophic engine failure, seizing the motor while in driving. Luckily, I was able to pull the truck to the side of the road safely, without a crash occurring. Losing engine/braking power could have been a major concern but thankfully, traffic was light enough I had space to pull to the side of the road. The truck had to be towed to the nearest dealer, where it was discovered the motor had seized. 2021 Chevrolet Silverado Trail Boss 6.2L motor with 47k miles on the factory warranty/no modifications. Since taking the truck to the dealer, they warranty-swapped a remanufactured crate motor in the truck. Hearing of the major increase in issues with this truck, I traded it in on a different manufacturer and now have a different vehicle. Aside from this huge inconvenience and safety issue, GM's customer support line failed to cover the full cost for a rental truck while my vehicle was down for a new motor (late November 2024 until mid January 2025) and I still have yet to receive a refund for my tow bill. This experience that has now lasted almost 6 months (still with no resolution) has been horrible. I hope General Motors is held liable for this major issue.
I have a 2021 Chevrolet Silverado 1500 with a 6.2 L engine. There seems to be a recall on this model and particular motor but my VIN does not show up. My engine has failed as described in the recall. I have a bearing failure on the crank according to my mechanics shop. Please add my VIN to the recall so I can get this problem repaired. I have been without my vehicle now for over a month and would appreciate assistance on this problem.
Engine knocking brought to dealership and they found codes P0300 and P0304 #4 cylinder with 15,000 then remove head and so order new engine from General Motors
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while operating the vehicle, there was a popping sound coming from the engine compartment, and the vehicle decelerated unintendedly and started driving rough. The vehicle was driven to the local mechanic who diagnosed an engine cylinder misfire. The mechanic replaced the fuel injector and engine lifter, and the vehicle was repaired. The contact stated that recently while driving, the same popping sound reoccurred, and the vehicle started to lose motive power. The vehicle was towed to the local mechanic who determined that the engine had failed. The exact cause of the engine failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 42,239.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while his wife was driving 35 MPH, the vehicle was making abnormal sounds. The driver drove the vehicle back to the residence. While driving at undisclosed speeds, there was an abnormal ticking and knocking sound coming from the vehicle. The contact stated that the sound went away and came back. While driving at an undisclosed speed, the vehicle lost motive power and stalled. The contact stated that the engine warning light was illuminated. The contact stated that the failure was related to the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling); however, the VIN was not included. The vehicle was taken to the local dealer, but the vehicle was not diagnosed or repaired. The dealer informed the contact missed an oil change and was negligent in servicing the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was contacted. The failure mileage was approximately 67,000.
I am filing a formal safety complaint regarding a persistent and unacceptable failure with my 2021 Chevrolet Silverado Trail Boss. The vehicle intermittently fails to start due to a recurring “Service Steering Column Lock” error. While the key fob still locks, unlocks, and remote starts the truck, the push-to-start system becomes entirely non-functional once inside the vehicle. This defect is not only frustrating — it’s dangerous. My wife has already been stranded twice, once in below-freezing temperatures in January, and again in May, causing her to be late for work and left alone at night in unsafe conditions. A truck purchased for over $60,000, marketed as rugged and dependable, should not be experiencing a critical failure like this at just 48,000 miles. What’s more concerning is that this appears to be a known issue within the GM community, with no official recall despite Technical Service Bulletins (TSBs) acknowledging the problem. Customers are being left with unreliable transportation and no consistent fix. This failure is both a mechanical and safety issue, leaving drivers vulnerable without warning. I urge the federal safety agency to investigate this defect, pressure GM for a formal recall, and ensure corrective action is taken before someone is injured due to being stranded or the failure progressing to more critical steering or ignition malfunctions.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving 70 MPH, the vehicle jerked and failed to accelerate as intended while depressing the accelerator pedal. The contact stated that the engine seized. The check engine warning light was illuminated before the failure. The contact was able to coast to the side of the road. The contact stated that the vehicle was towed to Midas, where it was diagnosed and determined that the fuel pump control unit had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact related the failure to the federal safety agency Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); however, the VIN was not included. The failure mileage was approximately 57,000.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving approximately 40 MPH, the vehicle started shaking abnormally, and the vehicle lost motive power. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the residence. The vehicle was then towed to a dealer where it was diagnosed with engine failure. The contact was informed that some undisclosed parts needed to be replaced. The vehicle was repaired but the contact stated that the vehicle was still shaking slightly. The manufacturer was notified of the failure. The failure mileage was 92,000.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that upon starting the vehicle, there was an abnormal tapping sound coming from the engine, with the check engine warning light displayed on the instrument panel. The contact stated that while driving at various speeds, the vehicle jerked and hesitated while depressing the accelerator pedal. The vehicle was taken to an independent mechanic and a dealer, where diagnostic tests were performed. The contact was informed that the engine lifters were defective; therefore, the engine needed to be replaced. Recently, the contact stated that while at a stoplight, the vehicle shut off and failed to restart. Due to the failure, the contact had the vehicle towed to the residence. The vehicle was not repaired. A mechanic later informed the contact about the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling); however, upon investigation, the contact discovered that the VIN was not included in the recall. The manufacturer was then notified of the failure and confirmed that the vehicle was not included in the recall. The contact was then referred to the federal safety agency Hotline to report the failure. The failure mileage was approximately 97,000.
The 6.2 is using 1-1.5 QT. every 3000 or so miles. I have done the check every 1000 miles. Had a bent lifter replaced 2 christmas ago.
this is 6.2 l l87 engine that is being recalled but this vin is not on list. already had lifters and rods replaced while back. coming home from trip truck made awful noise and I lost power on the interstate. thankfully was able to get out of traffic but waited 3.5 hours for tow. at dealer but cant tell me when they can look at it. 60,200 miles and they are saying well we will see what we can do but your powertrain warranty ended at 60k. i have had numerous problems and these are all known by gm especially 2021 6.2l.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while driving 70 MPH, there was an abnormal clunking sound coming from the engine compartment, and the contact discontinued driving the vehicle. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the push rod in cylinder 5. The vehicle was repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling); but the VIN was not included. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was 64,000.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving on several occasions at various speeds, the temperature gauge remained at hot (Hot) location, with a dinging warning notification. The check engine and "Transmission idle temperature high" messages were displayed. The vehicle was steered to the side of the road each time and turned off for approximately 45 minutes to allow the vehicle to cool down. The vehicle was taken to a dealer where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The vehicle was then taken to an independent mechanic where it was determined that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 115,000.
Driving to work my engine failure light came on….the engine immediately sputtered. I immediately drove inside the bay at Ozark Chevrolet. As soon as I pulled in….the technician told me to turn it off and that I wouldn’t be driving it anymore. See my statement for $3,429.15. I have to carry my grandkids in this vehicle. I traded it in on Tundra. And now I find out about the recall. It was the 8cyl engine currently under recall.
Service Engine Soon lamp illuminated with extremely rough running engine, would barely keep running. Dealer diagnosed misfires on cylinders 1, 3, 7, with cylinder 5 showing the most misfires. Tear down revealed defective lifter on cylinder 5. Repair under warranty included replacing all bank 1 lifters. Mileage of vehicle was 19566 at time of repair
Driving the truck at 45 mph, the engine stalled and the dash had all the lights on showing codes. Had it towed home and called the dealership the next business day. I was told it was the drive belt pulley that had gone bad causing loss of engine power. I had that replaced and the dealership then told me that the lifters were bad. I had to get that replaced because I needed my truck. The dealership had had it for almost three weeks at that point. $1300 to replace a lifter.
The repair estimate includes a complete teardown and replacement of the camshaft, 16 lifters, seals, bolts, gaskets, and associated components. The full cost breakdown is: Labor & Parts Subtotal: $11,402.78 Shop Fees & Tax: $467.13 Total Estimate: $11,869.91 Yes, the vehicle is available for inspection. it has been inspected by a chevrolet dealership and they gave us the above estimate to repair it. The vehicle powered down while driving on the freeway. It has not been inspected by police or insurance representatives, only by the chevrolet dealership service department. No, there were no warning signs prior to it powering down on the freeway. When it stopped producing power needed, the engine light came on as well as emergency brake light. This issue started on the freeway on Tuesday, April 29, 2025. The vehicle is only 4 years with only 130,000 miles and one that has been properly maintained. We believe this failure is not due to neglect or wear, but rather a known manufacturing defect.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while driving 70 MPH with the cruise control feature activated, the oil pressure message was displayed, and the vehicle stalled. The vehicle was coasted to the side of the road. The vehicle was not able to be restarted. The vehicle was towed to the residence and then to a dealer to be diagnosed, and the contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 78,000.
The contact owns a 2021 Chevrolet Silverado 1500. The contact received notification of the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.
While driving, engine stop and dash had message to put in neutral and hit start button to restart, but dash would gest go dark and did not restart. Vehicle towed to Wilson and Bell Automotive. After get engine reset I was told engine has loud knocking sound and needs to be replaced. I been going to this shop for over 30 years and trust there description. New engine was ordered. Then found out several days later that GM is going to recall my vehicle 2021 Silverado 1500 6.2 engine due to engine failure.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving 25 MPH, the vehicle suddenly stalled. The vehicle was able to restart. The instrument panel was illuminated with several unknown service lights. The vehicle was taken to the dealer who diagnosed that the lifters had failed. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 140,000.
Truck ENGINE completely SHUT down while driving on a high traffic road in my area. Had vehicle towed to my dealer for inspection.
I am reporting a safety concern that I believe should be included in an existing or expanded recall for the Chevrolet Silverado. The issue involves engine replacement due to metal shaving being found in oil & brake failure, which occurred on 05/01/2025 The problem with the brakes occurred while I was in heavy traffic in Dallas, Texas multiple times, resulted in multiple near-accident experiences that day. The truck has been diagnosed by a mechanic, at the Chevy dealership and I believe this defect poses a serious safety risk and may be affecting other Silverado vehicles outside the current recall scope. I have driven the vehicle to Chevy and stayed in constant contact with the dealership, had diagnostics done, but the issue has not been resolved. am requesting that the federal safety agency investigate whether this issue warrants inclusion in the current recall or a new safety campaign. I have on had this vehicle less than 2 years and I put less than 70K miles on it. I purchased it from vandergriff Chevrolet in Arlington, TX
Metal shavings were found in my oil after the check engine light came on a day before I took it in. The day that I took it in my brakes limited the speed of my truck to 43 mph due brake malfunction. The dealership called and told me that they recommend engine replacement due to the metal shavings found in the oil. I can give more in depth info as I receive it but I just wanted to alert Chevy that my vehicle is doing the same thing that the others are getting recalled for.
Engine starting shaking while driving and lost power. With only 33000 miles on engine.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving 60 MPH, the vehicle jerked, and the contact noticed an unusual clicking sound coming from the vehicle. The accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle was driven to the residence. The vehicle was taken to the dealer, where it was diagnosed with camshaft failure. The contact was informed that the camshaft needed to be replaced. The vehicle was not repaired. The vehicle had been taken to the dealer twice within a month due to the failure. The manufacturer was made aware of the failure, and a case was filed. The contact had requested a buyback. The failure mileage was approximately 70,000.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving 70 MPH, the vehicle made an abnormal knocking sound. The contact exited the freeway and continued driving 40 MPH; however, the vehicle stalled, and several unknown warning lights were illuminated. The vehicle failed to restart and was towed to the dealer, where it was diagnosed that piston #4 valve had seized, causing damage to the push rod. The dealer took the engine apart and replaced the push rod, the valve, and the head gasket. The contact stated that the failure occurred while driving 70MPH. The vehicle was towed to Team Hodges, INC. Chevrolet (2265 M-76, West Branch, MI 48661), where it was diagnosed that piston #8 valve had seized, causing damage to the camshaft. The dealer replaced the valve, the camshaft, and other unknown parts. The vehicle was repaired. The contact related to the failure to the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling). The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall. The failure mileage was approximately 10,000.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated while driving at various speeds, there was an abnormal metal-on-metal grinding sound coming from the engine. The contact also stated that whenever the vehicle was started, the engine was making an abnormal knocking sound. There was no warning light illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact had received notification of the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling); however, the part to do the recall repair was not yet available. The manufacturer was informed of the failure. The failure mileage was approximately 47,000.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Chevrolet Silverado 1500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history