My belief is a valve rotated and the cam shaft has defligrated to the point that the engine casing has been pierced. Chevrolet is saying I am not covered by the recall for my 2021 Chevrolet Silverado 1500
2021 Chevrolet Silverado 1500 engine complaints
Page 8 of 16: complaints 191 to 220 of 453, newest first, as owners wrote them.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while her husband was driving approximately 60 MPH, the vehicle started shaking and lost motive power. The contact stated that the check engine warning light was illuminated. The driver was able to drive the vehicle back to the residence at a reduced speed. The vehicle was then driven to a local dealer to be diagnosed. The dealer diagnosed the vehicle and determined that the engine control module and sensors needed to be replaced. The vehicle was repaired. The vehicle was retrieved; however, while driving off the lot, the check engine warning light illuminated, and the vehicle started shaking violently. The vehicle was with the dealer. The dealer then diagnosed the vehicle and determined that two of the lifters in the engine needed to be replaced. The vehicle was not repaired. The contact researched online and related the failure to the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling); however, the VIN was not included in the recall. The manufacturer was informed of the failure and confirmed that the VIN was not included in the recall. The contact was referred to the federal safety agency Hotline to report the failure. The failure mileage was approximately 70,000.
The contact's son owns a 2021 Chevrolet Silverado 1500. The contact stated that while her son was driving at a moderate speed, the vehicle lost motive power without warning. Due to the failure, the vehicle was towed to a dealer where the contact was informed that the vehicle was included in the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling). The contact was also notified that the parts for the recall repair were unavailable. The vehicle remained with the dealer. The vehicle was not repaired. The contact's husband notified the manufacturer of the failure and was provided a case number. The failure mileage was 47,000
Truck has under 45k miles on it. After reaching 35-40mph, it began to shake and jolt. Once we drove approximately 20miles, the engine light began flashing, in addition to the parking break light turning on. The truck began to lose power and we were forced to pull over on the side of a busy road. After waiting a little bit, we were able to drive it to our local shop who advised us to tow it back the the dealership for repairs.
Engine failure in October of 2023. Had vehicle towed to dealership and was told truck was not under warranty because of mileage and was going to be months before they can get to it because of parts on backorder or shortage of parts. Had truck towed to another shop and had the repairs done there, at my expense, for a total of $15,600. Fast forward to July of 2025, recall comes out on my truck for engine failure. Got reimbursement form with recall notice in the mail and got the required documents to submit form and was denied reimbursement for the following reasons, truck is too old for reimbursement and also because I did not have the work performed by a dealership. It is my understanding that there is a federal law stating that a manufacturer can not deny reimbursement for using a 3rd party auto shop for repairs and as far as the truck being too old for reimbursement, the repairs were done well within the 10 years allowed by federal law so I don't understand what the problem is . Please help Thanks
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that the oil change message was displayed. The contact received notification of the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling). The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was unknown.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at 35 MPH, the vehicle lost automotive power. There was no warning light illuminated. The contact immediately pulled over and attempted to restart the vehicle; however, the vehicle failed to start. The vehicle was towed to a local dealer where it was diagnosed, and the contact was informed that the engine was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 77,000.
Coolant control valve manufacturer defect, 3.0 duramax LM2
We have a 2021 Chevy Silverado 1500 in which the engine has failed. We believe this is the issue involved in the recall of Chevy Trucks. It needs to be added to the recall list. It has been unable to move since 2/17/2024. We have reported this to GM but they have not responded. Thank you
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the engine was misfiring. The vehicle was taken to an independent mechanic, where the contact was informed that the cylinders were misfiring, and the mechanic recommended that the spark plugs be replaced. The contact replaced the spark plugs with the assistance of a retired mechanic; however, the failure persisted. The vehicle was taken back to an independent mechanic and was diagnosed with a cylinder misfire. The mechanic recommended removing the dynamic fuel system management by replacing the camshaft, lifters, and other unknown parts. The dealer was notified of the failure and advised the contact to schedule an appointment for a diagnostic test. The vehicle was not repaired. The contact related the failure to GM Campaign Number: N212353840. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 65,000.
I have a 2021 chevy silverado and in october of 2023 I lost oil pressure and took the truck to a mechanic shop and they determined that the engine had spun rod bearings and crankshaft bearings inside the engine block and needed to be rebuilt. I had them make the repairs and upgraded the engine with aftermarket parts which cost me $15,600. When the recall came out this year it came with a form for reimbursement. I collected all the documents required to submit for reimbursement and I was denied because I did not have the work performed at a gm dealership. I didn't take it to the dealership because of the time they required to fix the truck and it was already out of warranty because of the mileage and I really didn't want to replace the engine components with more of their faulty parts. Just because I had the repairs done at a 3rd party shop does not excuse the fact that they sold me a truck with a faulty engine.
I am filing a formal complaint regarding a serious safety concern with my 2021 CHEVROLET SILVERADO, following the completion of recall N252494001 performed by Galleria Chevrolet in Dallas, TX. Prior to this recall work and related inspections, my vehicle operated without any abnormal engine noise. After the recall inspection and a subsequent fuel injector repair performed by the dealer, my vehicle began producing a bottom-end engine noise that had never been present before, and ultimately we have catastrophic engine failure. What is highly concerning is that the dealership staff previously documented the situation in writing as follows: “We performed the recall inspection and the truck passed. After performing an injector repair now there is a bottom-end noise when it's running. Did the failed injector possibly affect the validity of the test? That may be the case. We know that the truck did not experience the noise before the inspection; is it possible that the steps we took affected the truck in a way that got the noise to show itself? That’s what we need to determine.” Despite this acknowledgment, the dealership is now denying any responsibility, classifying the damage as unrelated “wear and tear”. This reversal appears highly suspicious, as it contradicts their own observations and written notes. It suggests that the dealership and GM may be refusing to fulfill their obligations under the recall and repair warranty, leaving me with a vehicle that has a blown engine and a significant safety risk. Given the timing of the noise, occurring directly after recall work and injector repair, and the internal documentation from the dealership itself, I request the federal safety agency investigate whether: This issue is part of a broader trend affecting other vehicles under the same recall. GM and its dealers are properly honoring their obligations to fully repair vehicles impacted by recalls. Consequential damage resulting from recall work is being systematically denied coverage.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving approximately 70 MPH, there was a knocking sound coming from the engine compartment before the vehicle went into "LIMP Mode" and decelerated to approximately 35 MPH. The check engine warning light was illuminated. The vehicle was driven to the local dealer, who diagnosed that the engine "Crank Shaft" had failed and needed to be replaced. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the federal safety agency Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 165,000.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving off an off-ramp at approximately 40-60 MPH and depressing the brake pedal, the vehicle suddenly lost power and turned off. The contact restarted the vehicle to continue driving. The failure had occurred twice. The contact stated that while driving at various speeds and depressing the brake pedal, the brakes grabbed, causing the vehicle to lunge forward, decelerate, and then lunge forward again, before coming to a complete stop. The contact shifted to park(P) and then to drive(D) and continued driving. The check engine warning light was illuminated. The vehicle was taken to the dealer four times before receiving notification of the federal safety agency Campaign Number: 24V797000 (Power Train). The dealer was unable to determine the cause of the failure. The vehicle was taken to the dealer, and the recall repair was performed. The contact stated that one hour after the recall repair, the failure recurred with the check engine warning light illuminated. The dealer was informed of the failure; however, the vehicle was not diagnosed or repaired again. The manufacturer was informed of the failure. The manufacturer referred the contact to the dealer for assistance. The failure mileage was approximately 56,000.
The 3 and 4 cylinder need to be replaced at 130000 miles with regulate maintenance always maintained
2021 Silverado 1500 Trail Boss LT with 6.2ltr V8 L87 had sudden catastrophic engine failure at 90,000 miles with excellent and routine maintenance up to. Findings were a broken timing chain, cracked piston and debris in number 8 intake port. Vehicle lost propulsion on the highway posing a safety risk to the driver, passengers and other vehicles on the roadway. Dealership confirmed the findings. There were no warning signs, signals, lamps, beeps, noises or any other indicators that there was an issue with the motor. It unexpectedly and suddenly failed without warning.
General Motors is selling vehicles that are unsafe, unreliable, and unfit for consumers. My experience shows a clear pattern of negligence, misrepresentation, and disregard for public safety. On or about April of 2021, I purchased a 2021 Chevy Silverado RST z71 from Vetter chvrolet for about $56,000. GM promoted this vehicle as safe and dependable. Within the short 4 years of owning this truck, I faced major failures: engine issues, transmission problems and electrical malfunctions causing the parking break to engage on its own, at highway speeds of 70-80 mph on which nearly caused a serious accident, and failed Electronic Stability Control (ESC) system. This system helps maintain vehicle control, and a problem with it can affect braking, steering, and handling, Despite following GM’s maintenance guidelines, GM delayed repairs, denied coverage on certain failures, and left me with thousands in out-of-pocket costs. The vehicle remains unreliable and unsafe. For myself and my family, 2 children under 3 years old and one on the way. This is not an isolated issue—GM has a long history of recalls and defect cover-ups. These vehicles put lives at risk, cause financial hardship, and violate consumer trust. No one should fear for their safety in a vehicle marketed as “dependable.” This has impacted me by having : • Expensive repairs • Loss of transportation for extended periods • Ongoing fear of driving a defective vehicle with my family in it. Loss of use of my vehicle • Fear and emotional distress driving an unsafe product I have contacted GM and the dealership multiple times. Responses were dismissive, repairs were inadequate, and GM refuses accountability. Requested Resolution: Full reimbursement for all related costs Buyback (preferred) of the vehicle OR permanent repair at no cost Public acknowledgment and stronger quality control. Warning to Consumers: Think twice before trusting GM. Their failure to correct dangerous defects shows profits matter more than safety.
The contact owns a 2021 Chevrolet Silverado 1500. The contact received notification of the federal safety agency Campaign Number: 25V274000 (Engine and Engine Cooling). The dealer was contacted, and the contact was informed that the parts were unavailable. The contact stated that the manufacturer had exceeded the limited time frame to have the parts available. The manufacturer was contacted; however, the contact was informed that parts were not yet available. The contact had not experienced a failure.
So many vehicles like mine have si.ilar issue. Lifter issues causing engine damage and other part damage. Causes issues at high-speed with power and stranded motorists on dangerous highways. It is a safety issue because you could be stranded in middle of highway. Lifter issues causing bent pushrods and other engine part damage costing . I had one pushrod covered, but others failed and now thousands in repairs. In expensive vehicles. Also towing charges, hotels, rental cars, etc... I dont want to be stranded again as only one bank was all replaced. The entire top half of the engine should be fixed and should be replaced and a service bulletin and recall should be issued to help.protect consumers.
On, or about, 10 June 2025 I attempted to start my 2021 Chevrolet Silverado (with the L87 engine) and noticed an extremely rough idle. I shut the engine off and attempted to restart the engine, the idle was rougher than previous and then white smoke started billowing out of my exhaust. At that point I called a wrecker to take my truck to the service center at my dealership. After the dealership diagnosed my engine they stated that it had failed due the defect in the L87 engine that is currently the subject of an active recall. The service center informed me I would need a replacement engine under the warranty but could not give me a timeline, I have been in constant contact with my service advisor and they indicate that GM has no updates as to where I am in the queue, or how long it may be before my replacement engine will be sent. As of writing this complaint it has been two months with no updates from the manufacturer.
The contact owns a 2021 Chevrolet Silverado 1500. The contact stated that while driving 30 MPH, the rear wheels locked up, causing the vehicle to slide across the road. The contact was able to regain control of the vehicle and came to a stop in the middle of the road. The check engine and traction control warning lights were illuminated. The contact turned off and then restarted the vehicle and became aware that the transmission failed to shift into the intended gear. The vehicle was towed to the contact's place of employment. The contact who is a certified mechanic performed a diagnostic test and retrieved DTC: P0747, indicating a failure with the pressure control cylinder in the transmission. The contact also found information on the federal safety agency Campaign Number: 24V797000 (Power Train); however, the VIN was not included. The vehicle was not repaired. The dealer was contacted and confirmed that the VIN was not included int the recall. The manufacturer was not informed of the failure. The failure mileage was 83,830.
The contact owns a 2021 Chevrolet Silverado 1500. The vehicle was initially taken to the local dealer to be repaired under the federal safety agency Campaign Number: 24V797000 (Power Train). The contact stated the vehicle was not repaired. While driving 30-35 MPH, the rear-end locked up and caused the vehicle to enter the wrong lane. The contact stated that other vehicles were able to drive around the vehicle during the failure. The engine revved, and the RPMs revved too high. The driver was able to pull over safely. The check engine, traction control, parking brake, and maintenance warning lights were illuminated. The vehicle was towed to the local dealer, where it was diagnosed, and it was determined that the rear-end had locked up, and the #5 cylinder and wiring harness needed to be replaced. The mechanic was unable to unlock the rear-end. The vehicle was not repaired. The vehicle was taken to the local dealer on six other occasions for unknown issues. The manufacturer was contacted regarding a buyback. The failure mileage was approximately 34,958.
The contact owns a 2021 Chevrolet Silverado 1500. The contact had received notification of the federal safety agency Campaign Number: 25V274000(Engine and Engine Cooling). The contact stated that upon taking the vehicle to the dealer for a routine oil change, the contact requested an engine inspection and oil change. The dealer performed the oil change; however, the dealer informed the contact that the recall remedy was not yet available for the vehicle. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was informed of the issue. The contact had not experienced a failure.
The truck started rattling and lost power while driving. Every warning light came on on the instrument panel. I was driving on the freeway in rush hour traffic when this happened. Yes, it has been confirmed by a dealership and independent service center. No lights were on prior to when it failed to give any warning that something may be going wrong. The failure occurred immediately after GM issued a recall in April involving defective V8 engines (Recall Link [XXX] )). While our truck is not currently included in the recall, the diagnosis of the vehicle is all the same as that of the recalled engines. We should not have an engine failing at 130K miles on a vehicle that has been well maintained. We are asking that this truck be added to the recall. We are still without the vehicle as engines cannot be sourced. Please advise on next steps. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
In June 2025, I received a letter from General Motors noting that a defect exist relating to motor vehicles safety in certain 2021 model of Chevrolet Silverado equipped with the 6.2L V8 gas engine (RPOL87). The dealer has been unable to fix the issue in a timely manner as they claim that the parts are on backorder. Additionally, they have been unable to provide me with another vehicle while my car is in the dealer. It is completely unacceptable that the dealer has been unable to fix the issue in a timely manner or provide with alternative form of transportation while the parts arrive.
Lifters 1-3-5-7 all failed. They were pitted as was the camshaft. Diagnosis from Hendrick Chevrolet in Hoover AL. 70k miles on one owner truck. Regular servicing and never towed anything.
check engine light came on at 55000 mile went to servige ststion they check oil 4 quart lowe motor leaking o il . been to dealer 5 time in last 2 0r 3 month . now engine making peaking noise at 6400 mile . dealer say warrenty out have to pay for repair . something wrong clinder head they guess dont now for shore will have to tare into motor this truck was under warrenty when i first took it for repairs now they want me to pay for the repairs .
No updates have been made to fix recall. Status has been pending for a long and it’s preventing me from selling the car due to fear of breaking down.
Around July 1st, 2025 I was hearing a ticking sound when taking off from a stop. On July 11th I had an oil change completed on the truck at the Local Chevy dealership, after the oil change, I mentioned the noise and was told maybe we could schedule some sort of deep cleaning of the internal components of the engine. After leaving the dealership after the oil change, I was still hearing the ticking sound. I then scheduled an appointment on July 22nd for the dealership to look into the ticking sound. I drove the truck to the dealership and it was working fine; other than the ticking sound when the RPM’s were at 2200. At no time was there any warning lights that came on to alert me to a problem. After approximately 30 minutes of waiting in the customer waiting area, the service advisor came and got me and said “we have big problems” and they were going to need the truck longer to look into it. I walked out to the service bay to get some personal items out of the truck. At that time, the mechanic pointed out some white looking fluffy cotton material and said that just came out the end of your exhaust. I had never seen that material prior to this appointment on July 22. The dealership called me July 24th and told me that the engine and exhaust system need to be replaced. They told me that the bottom end connecting rod came apart, and went through the engine and the exhaust system while it was at their facility on July 22. This truck has the 6.2L V8 (RPO L87) gas engine…. This truck is a 2021 and there is 76,957 miles currently on it (7/24/2025). With a blown engine, and an exhaust system that needs to be replaced.
Went to accelerate through an intersection and the engine seized up in the middle of the intersection. Complete loss and of engine propulsion. Had to be towed. Could have caused an accident. No warning signs. Truck was running great until it wasn’t running at all.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Chevrolet Silverado 1500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history