Hydraboost piston blew out, lost brakes and steering. Almost wrecked vehicle.
2004 Chevrolet Silverado 2500 brakes problems
168 complaints (46% of all complaints for this car). Typical mileage when it fails: 80,000. 13 crashes reported.
- owner complaints
- 168
- of this car's complaints
- 46%
- typical mileage
- 80,000
- crashes
- 13
- recalls
- 0
Which part fails
- Foundation components: hoses, lines/piping, and fittings10
- Foundation components: disc: rotor2
- Antilock/traction control/electronic limited slip: wheel speed sensor/tone ring2
- Antilock/traction control/electronic limited slip2
- Power assist: hydraulic1
- Power assist1
- Fluid1
- Driveline: hydraulic: hoses, lines/piping, and fittings1
At what mileage
Complaints by mileage at the time of the problem.
Chevrolet Silverado 2500 brakes problems in other years
Specific symptoms reported on the 2004 Chevrolet Silverado 2500 brakes
Phrases found in the owners' own descriptions, so one complaint can mention several symptoms.
Related recalls
No recalls on record for this model year.
What 2004 Chevrolet Silverado 2500 owners say
Most recent owner complaints, unedited.
I have changed all 4 new tires in 4 different times every yrs not sure if that a wheel problem. And also fix my fuel injection system that was give me a problem in the past. Now I replace all new rotor brake discs and pad in 30 minutes out from a mechanical shop it's show a engine light now saying range shift inhibited on my dashboard. And when I'm shifting to drive it just reverse instead of drive. Now is back in the shop for now problem to come. From garden city kansas
Brake lines failed after having already been replaced. Factory lines corroded through and truck was scary to slow down. Was fortunate to be going at low speeds in a residential area - but glad there were no kids around and I needed to brake quickly!
I have had a complete brake job because all of the lines rusted out and failed as I was driving. Fortunately, I was able to use the emergency brake to stop safely. I spent rough.y $3,000 to get this repaired. Now the fuel lines, fuel cooler and everything attached has rusted out to the point that it is going to be an additiona $2,500 to repair this. Also, the complete under carriage and rear end has rusted to the point that I am expecting it to fail at any time. This is not only a dangerous situation, but is extremely costly to the consumer, me. When the brakes failed, I was driving on a street approaching a busy intersection. With no warning at all, the pedal went to the floor and I had no brakes. The repair facility mechanic said he has never seen a system so bad. I keep the vehicle in a garage and have washed the under carriage in the winter to keep road salt from accumulating.
Total brake failure when attempting to slow/stop vehicle to make a turn. Drove into parking lot to get off of roadway, hit sign, tree, parked vehicle before vehicle finally stopped.
Engine runs rough at idle.ck engine light on.
Brake lines have started rusting out. Only 120k on the truck. Called gm. Gm will not help with this known issue of the brake lines corroding. Had 1line fixed after it blew coming to a stop by my house. Second line blew yesterday slowing down while exiting the freeway
Brake lines and related calipers continue to rust and fail. Have now lost brakes while driving due to failure of various brake lines three times. Twice I lost the brakes while driving in highway traffic. Once while backing slowly down a ramp to a dock. Have had lines replaced 3 times now. Calipers also replace. Vehicle in shop for emergency repair now. Previous dealers have said this problem is related to the new brine material applied to roads by dot in winter. Note that I do clean undercarriage to remove salt. Also have had several older vehicles other makes/ models during same time period and have not had this issue. Never replace brake lines on other vehicles.
While traveling 50 MPH towing a boat applied the brakes , the vehicle slowed down and the brake pedal went to the floor with the units finally stopping . All brake failure warning lights light up on the dash and upon inspection it was discovered the brake line to the right front wheel had rusted through and blew out all the brake fluid directly under the drivers door. All remaining brake lines are severely rusted and appear swollen as to be ready to burst as well under the drivers door along the frame rail. Vehicle has 2,760 engine running hours on it with 82,500 miles driven. All brake lines are original to the truck .dealer estimate to replace all brake lines was in excess of $2,000. This vehicle is only driven on the highway and never off road. I have owned many vehicles over the years and this vehicle is the only one that has suffered a catastrophic brake failure which thankfully did not end in a crash. After further investigation with other similar truck owners I have discovered this has been a common problem that in now surfacing and may result with tragic consequences if not addressed by the federal safety agency and gm immediately.
On 4/28/2016 traveling to work following a tractor trailer in a 55 MPH zone, the tractor trailer abruptly merged into the right turn lane after a curve without a signal leaving two stopped cars in my travel lane making a left turn. I applied hard pressure to my brakes and the pedal went to the floor. I impacted an avalanche that was pushed into a small compact car causing substantial damage to my vehicle and the avalanche. The driver of the avalanche was transported to the hospital with minor injuries. While at the accident scene I noticed fluid leaking under my truck just behind the left rear tire. The truck was towed from the scene to a body shop where they discovered 2 ruptured brake lines in between the master cylinder and proportioning valve. Attached pictures show severally rusted brake lines with no other rust or corrosion on parts in the surrounding area. Initial estimate for repairs on my truck were $6,371 before tear down.
Questions about the 2004 Chevrolet Silverado 2500 brakes
Does the 2004 Chevrolet Silverado 2500 have brakes problems?
Owners have filed 168 complaints about the brakes of the 2004 Chevrolet Silverado 2500, 46% of all its complaints, more than any other problem.
At what mileage do 2004 Chevrolet Silverado 2500 brakes problems start?
The typical (median) mileage in owner complaints is 80,000 miles.
Was there a recall on the 2004 Chevrolet Silverado 2500 brakes?
There is no recall for this problem on this model year.
What year does the Chevrolet Silverado 2500 have bad brakes?
The Chevrolet Silverado 2500 model years with the most brakes complaints are 2003 (247 complaints), 2002 (212 complaints) and 2001 (181 complaints).
Other 2004 Chevrolet Silverado 2500 problems
Electrical 105Engine 36Fuel system 26Steering 16Transmission 15Suspension 12Wheels 9Acceleration 6Tires 5Airbags 4Body 4Visibility 4Lights 2Locks 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2004 Chevrolet Silverado 2500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history