1996 Chevrolet Silverado transmission problems

Filed May 10, 2005 · Transmission · 58,000 miles · FL

Since purchased from maher chevrolet in 2001, the "c clip" in the "transfer case" has broken three times and we have never used the 4 wheel drive. This occurs during normal driving! The first time was within months after owning the vehicle. The second time was 30,000 miles after it replaced. Now less than 20,000 miles later, its broke again. There must be something defective internally in the transfer case. When driving and the "c clip" breaks, the gears start grinding loudly. You can not exceed 3 - 5 miles per hour. Since this is an instant movement, this can cause an accident wehn travling on the interstate. Which my husband frequently does while driving to work. The warranty has expired on the vehicle and I don't understand why this problem has not been fixed since it was brought back to the dealer on two occasions and supposedly, fixed then. Is the dealership the problem or am I dealing with unsafe defect with the transfer case. I will list the approx. Date that the dealership looked at my truck last, and then wanted to charge me over $2,500 to "investigate" why the "c clip" keeps breaking.

Filed Mar 3, 2004 · Transmission · 50,400 miles · IL

Transmission started slipping and stopped shifting into 3rd gear at 50,000 miles. Was rebuilt at trans service shop. Cause was lack of ground wire between control module and transmission causing erratic fluid pressures. I paid the $1470.00 repair bill. Tsb described the defect, I was not notified. This was preventable from chevy's perspective.

Filed Jun 23, 2003 · Transmission · TX

Consumer noticed that while traveling, transmission goes out during passing gear. Consumer is now on 3rd transmission.

Filed Jan 23, 2002 · Transmission · VA

When accelerating from a stop vehicle would not go into gear properly. Vehicle would not go from one gear to another. Dealer contacted.*ak consumer states that the transmission is currently changing correctly, however now there is a fluid leak, dealer wants to charge consumer for these repairs.

Filed Nov 28, 2001 · Transmission · NC

Z71 truck transmission failed at 55,000 miles. Gm states that my vehicle is in excellent condition & that there was nothing that I did to cause the failure. Gm service bulletin (doc. #225207) states that the vcm can cause erratic line pressure with the 4l60-e transmission. Although the bulletins are for tech. Info only, this service bulletin documents a known pre-existing defect that can "lead" to premature transmission failure due to the vcm communicating intermittent, erratic, unstable line pressure. The bulletin addresses the problem & potential "failure or damage" versus being informative & tools needed for the job. Because consumers are not notified of bulletins, they end-up paying for these repairs out of pocket, never knowing they stem from factory defects & could be repaired for little or nothing. Notification precludes additional problems & expense that could be covered by the warranty or hidden warranty (so called good will program).

Filed Jul 2, 2001 · Transmission · NH

This is the second transmission that failed at 10,000 miles on replacement. Exact thing happend loud noise lost forward gears and reverse and forward came back without reverse. This vehicle has never been used to tow.

Filed Jun 27, 2001 · Transmission · NH

1st transmission went at 37,000 on 3/10/2000 2nd transmission went on 06/24/2001 with only 10,000 mi on it. 7 1996 vehicles around the same mileage that we know have had to be replaced. Thank you.

Filed Apr 1, 2001 · Transmission · NJ

The transfer case failed. Nlm

Filed Mar 12, 2001 · Transmission · TN

I was told that transmission failed because a modifacation was not made .why was I not notified ?

Filed Feb 5, 2001 · Transmission · NC

Consumer was traveling on highway and heard a noise. Was able to pull over to shoulders. Vehicle was towed to dealership, and mechanic told him that transmission needed to be replaced.