1997 Chevrolet Silverado electrical problems

Filed Oct 20, 2014 · Electrical · 30,000 miles · TX

Approximately in 2006, with only 30,000 miles, I noticed antifreeze pooling under my 1097 silverado pickup. I took my vehicle to an auto repair shop and was told that it needed a new radiator. The radiator was replaced. Approximately one month later the same problem. The radiator was again leaking. The radiator was replaced three times until the owner of the repair shop stated that he would no longer replace the radiator and explained that the 1997 silverado pickup was known for a condition called. Electrolysis. It was suggested that I remove the battery cable after each time I drove the vehicle. I started to removing the positive battery cable and within 3 weeks the same problem. I then contacted rudolph chevrolet dealership in el paso, texas. They refused to tackle the problem and referred me to emmitt radiator shop, also in el paso, texas. They advised that they would charge $80.00 per hour with a minimum of 10 to 12 hours with no guarantee. They did suggest that I remove both positive and negative battery cables. This is where the problem with the exploding battery comes to light. When I would try to remove the battery cables after each trip, even to the movies or out to dinner, the battery would be so hot that it would burn my hands. I also kept replacing the batteries and finally ask a saleswoman at auto zone supply house what was wrong with the batteries and he pointed to the battery and said, "look at the sides of the battery, how it is extending outward it could explode". Again I was told me that they did not have the equipment to fix the problem. This falls into the category of a lemon and general motors knew of this problem or should have known of this problem the 1997 silverado pickup and have placed consumers in harms way.

Filed Aug 22, 2014 · Electrical, Locks · 187,600 miles · AZ · fire

Tl* the contact owns a 1997 chevrolet silverado. The contact stated that while parked, the driver's side panel caught on fire. Also, the contact mentioned that the power locks and the power windows failed to operate properly. The fire department was not contacted. The vehicle was not destroyed. The vehicle had not been diagnosed or repaired. A police report was not filed and there were no injuries. The manufacturer had been notified. The approximate failure mileage was 187,600. Updated 9/29/14*cn updated 2/26/2015

Filed Jun 21, 2003 · Electrical, Fuel system · 25,000 miles · CA

Fuel injectors plug up every 10,000 miles, water pump went out at 40,000 miles, alternator went out at 45,000 miles all in all this truck is a piece of crap.

Filed Apr 10, 2003 · Electrical · 4,000 miles · TX

The turn signals on the vehicle, 1997 z-71, silverado have not been working dependably since 1997. We took the vehicle to connel chevrolet 3 different times to fix the problem and the turn signals still go out sporadically. We did take the vehicle to fort knox ky where the turn signals were working since 1999. And now (april 3 2003) the turn signals are not working properly again. All the fuses are fine and the light bulbs are all brand new and the turn signal is still not working.

Filed Jul 19, 2002 · Airbags, Electrical · IL

While driving at 5 MPH, the front passenger's side air bag deployed, hitting the consumer. Contacted dealer, who was not willing to do anything. *ak the dealer discovered that the module malfunction was due to water damage. After futher dismantling the console in order to repair, it was discovered that the water damage was due to a leak in the left cowl area. Consumer feels that gmc should be liable for not having adequate sealing to prevent water from seeping into the cowl area.

Filed Jul 30, 2001 · Acceleration, Electrical · CA

Transmission went out at 40,000 miles. Consumer was told that transmission was not under warranty. *ak battery and alternator failed, short circuit fuse caused failure of brake lights and turn signals. Injector failed. Water pump failed. Vehicle jumped out of gear, was towed to dealer who informed consumer that transmission needed replaced, consumer is angry that a vehicle with such low mileage would have transmission failure and chevrolet will not asist in repairs.

Filed Jun 1, 2001 · Electrical, Engine · IN

Problem #1: the fuel pump relay doesn't seem to disengage after first starting the engine and it heats up. This causes rough operating of the engine. Further investigation shows that the maxi fuse to the lighting system heats up also, but does not fail. Another area that is affected is the mini fuse to the courtesy lamps. It heats up, but does not fail. The last area to be affected is the evaporative emission canister vacuum switch. It acts as if the wheels are out of balance around 50mph. I have taken this vehicle in to the dealership on a number of occasions and they either can't find anything wrong or try and tell me that the fuel injectors are at fault. They put injector cleaner in the fuel tank on two occasions, which made it run worse. I asked to have the injectors replaced while it was still under warranty and they said they had to follow procedure bulletin #00-06-04-003 before taking that step. The problem still existed, but they haven't offered to replace fuel injectors. My thinking is that the problem is really the ignition switch. Can you please advise me of any other similar complaints and how it was resolved? Probelm #2: while driving straight highway at about 55 MPH steering feels loose and wants shift lanes on it's own. On sweeping turns it turns to the right on it's own. I had the front end alligned and a new set of tires, but the problem still exists. Any advise?

Filed Sep 5, 2000 · Electrical · LA

Battery is leaking acid where the connection is.

Filed Mar 15, 2000 · Electrical · MI

Two wires inside the fuel tank rubbed the insulation off of the wires, causing a direct short, and vehicle becoming inoperable. Vehicle has been repaired.

Filed Feb 1, 2000 · Electrical, Fuel system · MS

Electrical components of fuel pump burned up along with wiring harness.