2025 Chevrolet Suburban 1500: check engine light

Filed Aug 28, 2026 · Engine · 17,000 miles · FL

The contact owns a 2025 Chevrolet Suburban. The contact stated that while driving approximately 65 MPH, a banging noise was heard coming from the engine compartment, and the vehicle decelerated. In addition, several warning lights, including the check engine light and the anti-lock braking system light illuminated. The contact pulled over to the side of the road, turned off the vehicle, and had the vehicle towed to a dealer. The dealer diagnosed that the engine and radiator failed and needed to be replaced. The engine and radiator were replaced. Approximately 5 months and 6,000 miles later, the failure recurred and the engine began to run rough. The vehicle was returned to the dealer, where it was diagnosed that the engine failed again. The engine was in the process of being replaced. The manufacturer was notified of the failure and a case was filed. The failure mileage was approximately 17,000.

Filed May 18, 2026 · Engine · GA

3.0 Duramax engine failure at 5900 miles. Apparently is from the known thrust bearing issue. MIL, CEL, TCM illuminated. Failure occurred at 60 mph during rush hour traffic. Engine is being replaced under warranty. GM should issue recall for the affected lot of this engine.

Filed Mar 10, 2026 · Engine · 2,203 miles · MD

The contact owns a 2025 Chevrolet Suburban. The contact stated that while driving 25 MPH, a yellow triangle warning icon was displayed, and a message to "Please Add Oil" was displayed. The vehicle was taken to a dealer, where it was diagnosed with a broken part and oil was leaking oil onto the oil filter. The vehicle was repaired. The contact stated that approximately 1,000 miles later, the same triangle icon was displayed and with the same message displayed while driving. The vehicle was taken to the same dealer, where it was diagnosed that the oil needed to be changed. The vehicle was repaired. The contact stated that approximately 1,000 miles later; while driving at an undisclosed speed, the same triangle warning icon and the message were displayed with the check engine warning light illuminated. The vehicle was taken to another dealer, where it was diagnosed, and it was determined that the vehicle was consuming engine oil, and the oil needed to be changed. The vehicle was repaired, but the check engine warning light illuminated again, and the contact became aware that there was no oil in the oil pan. The manufacturer was notified of the failure. The failure mileage was 2,203.

Filed Nov 11, 2025 · Acceleration, Engine · MI

7/13/25: Car repeatedly jerking/shuddering/rough ride. A flashing check engine light came on for 10 or 15 minutes. After stopping car and restarting it, the check engine light went off. 9/15/25: Car jerking and another flashing check engine light. Took to dealership. They drove it and said no codes stored. Told it was probably the transmission "breaking in." Took home. Car continued to jerk/stumble. 8/28/25 to 9/15/25: Car jerking and flashing check engine light back on. Took to Autozone. A Random/Multiple Cylinder Misfire Code was detected (P0300). Took to dealership and confirmed P0300 Code stored. GM TAC engineers involved. Told they were unable to figure out why car was having multiple misfires. Returned car to me because no active code/light. 9/29/25: Car jerking and flashing check engine light back on. Got a warning of "reduced acceleration and drive with care." Car lost power. I have video of this and contacted On Star with report generated and P0300 code. On 10/1/25 on way to dealer, car making audible ticking noise. I have video of this. Took to dealer, the ECM was replaced and oil changed because it was "very dark" (in vehicle with 4,600 miles). Car continued to jerk/stumble. Told by dealer that problem would have to get worse before diagnosis could be made. 10/31/25: Jerking and another flashing check engine light with "reduced acceleration drive with care warning." Turned car off and engine light off. On Star report P0300. Took to dealer. The dealership was given the videos of check engine lights/reduced acceleration warnings and ticking noise video. All show problem happening around 1,200 rpms. Told by dealer on 11/11/25 that GM rep said they will not pay dealer for any work because no active engine light/codes. Told to pick up car. Asked dealer today for reason in writing, but no response. Very concerned about vehicle safety when repeatedly going into limp mode and flashing check engine lights with GM offering no solution.

Filed Oct 31, 2025 · Engine, Transmission · CA

Purchased the vehicle on April 7, 2025. On 7/15/25, the car had 6948 mi. and started running rough, had a loss of power, an odor from the engine, and then on the display: check engine, blinking green vehicle light, and a message stating that the car was lowering for stability control. Took the vehicle to the closest Chevrolet service. The service dept. determined that code found P0307 and P0300, cylinder seven had the most misfires above 500. After completing oil service, the vehicle began to click on the passenger side; however, it was not misfiring. They inspected and found potential lifter issue. Found ticking coming from cylinder 7 and verified misfires. Found 2 pushrods damaged. Heard noise coming from cylinder 4, removed valve cover, removed rocker arms, and found 1 pushrod damaged. They removed and replaced all lifters and 3 pushrods. They stated there was no more noise //after this repair. These repairs were completed on July 25, 2025. On 8/15/25 took back to service because it continued to run rough and made excessive noise and whistling when starting the vehicle. The dealer inspected and heard the noise, inspected the vehicle exhaust leak, checked exhaust manifolds, pipe connections, and determined there were no issues found. On 9/26/25 at 11,821 miles the car was making excessive noise, running rough, and was losing power. Drove home, and the vehicle was running rougher and losing power. No check engine lights or warnings were present. Drove home, and the vehicle was running rougher and losing power until it turned off. Towed in. Maintenance techs determined catastrophic engine failure, all bearings and engine rods seized. After this repair hen the catalytic converter failed. This car has been out of service due to engine failures for 43 days out of the 204 of ownership.