2015 Chevrolet Tahoe: fuel leak

Filed Mar 19, 2026 · Fuel system · AL

The failure is believed to have originated in the fuel delivery system, specifically the check valve in the low-pressure fuel feed jumper line at the engine. This valve failed to seat properly, allowing high-pressure pulses to travel back into the low-pressure side of the system. This malfunction caused the S-shaped portion of the fuel feed line near the tank to vibrate excessively against its mounting clip. This constant friction wore through the line, resulting in an active fuel leak. All damaged components remain on the vehicle and are available for inspection upon request. The safety of the driver, passengers, and the public is at immediate risk due to a severe fire hazard. Because the leak is located near the fuel tank and undercarriage, gasoline is being released where it could be ignited by road sparks, static electricity, or exhaust heat. A fuel leak of this nature threatens a catastrophic fire that could result in vehicle loss or personal injury. The problem has been confirmed via a physical inspection that matches the symptoms documented in a GM Service Bulletin (Recall - High Pressure Fuel Pump Leakage). While the vehicle has not yet been subjected to a formal tear-down by a dealer due to the danger of driving it with a leak, the visual evidence at the exact location specified in manufacturer documentation confirms the failure. To date, the vehicle has not been inspected by the manufacturer, police, or insurance representatives. Prior to the leak, the primary symptoms were an audible rattling and ticking noise from the engine bay and underside, characteristic of the pressure pulses described in the TSB. There were no warning lamps or dashboard messages, as the mechanical wear on the exterior of the fuel line occurred outside the scope of the vehicle’s onboard diagnostic sensors.

Filed Aug 6, 2025 · Fuel system · VA

I am leaking fuel from the fuel lines connected to the fuel tank. I can smell the fumes inside of the cab. I also can see the fuel leaking under the driver seat.

Filed Apr 30, 2025 · Fuel system · MS

I’ve had to have the fuel line replaced 3 times because of fuel leaks.

Filed Jun 26, 2024 · Fuel system · 220,000 miles · TX

The contact owns a 2015 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, there was an abnormally strong odor inside the vehicle. The contact stopped the vehicle to complete an inspection of the vehicle. The contact became aware that there was a large fuel leak on the ground. The contact stated that when the vehicle was turned off the fuel leak stopped. The contact stated that fuel only leaked out when the vehicle was running. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact researched and discovered TSB: 17-NA-304; however, the contact was informed that the repair could not be covered under the TSB. The failure mileage was approximately 220,000.

Filed Dec 16, 2023 · Engine, Fuel system · NJ

I was constantly smelling a strong odor of gas coming from the inside/outside of my 2015 Chevy Tahoe. When I purchased the vehicle in 10/23 everything appeared fine. I researched the internet to determine what the problem could be & found dozens of similar situations. People saying the fuel line rubs the undercarriage of the vehicle causing a pin hole size in the fuel line causing it to leak gas. Currently my vehicle is in the shop and the problem is TBD.

Filed Oct 6, 2023 · Fuel system · 120,000 miles · NC

The contact owns a 2015 Chevrolet Tahoe. The contact stated that she would smell the odor of gasoline when she approached the vehicle. The contact stated there was a stain on her driveway that was gasoline. Most recently, the contact saw that fuel was dripping from the fuel tank. Also, the contact stated that the vehicle had become more difficult to start in the morning, sometimes taking over four attempts. No warning light was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The contact had researched online and related the failure to the manufacturer Technical Service Bulletin Number: 17-NA-304 Possible Fuel Leak (Fuel System, Gasoline). The failure mileage was approximately 120,000.

Filed Oct 6, 2023 · Fuel system · IN

The high pressure fuel line from the fuel pump to engine sustained a pinhole leak over the fuel tank. Fuel leaked over top of tank and ran down front drivers side front of tank. Discovered the leak after noticing strong fuel odor inside vehicle. Took to shop. The fuel line is installed as so it will rub undercarriage of vehicle. This is what happened to mine. This is a factory install and the lines are doomed to fail because of this. The excessive contact rubs holes into the lines. This seems to be a common problem with the 2015, according to my research. There are hundreds of these same complaints with this year listed all over repair sites on the internet. I believe this needs looked into, as flammable fuel leaking suddenly can be a hazard.

Filed Sep 7, 2023 · Fuel system · 182,000 miles · SC

The contact owns a 2015 Chevrolet Tahoe. The contact stated that after refueling the vehicle, an abnormally strong fuel odor was detected. The following day, while starting the vehicle, the strong fuel odor was detected again. Additionally, the contact noticed fuel leaking from the fuel line onto the ground when the vehicle was parked. The vehicle was taken to the dealer; however, the vehicle was not yet diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 182,000.

Filed Sep 7, 2023 · Fuel system · SC

Gas leaking out of my vehicle. First noticed it right after pumping gas then started smelling a strong odor of gasoline!

Filed Jul 26, 2023 · Fuel system · MA

Started smelling gas fumes. Notices gas dripping from under vehicle leaving puddle under vehicle drivers side. Safety due to gas leak under vehicle. Brought to balise chevrolet springfieled massachusetts. Leak confirmed from top of tank. Removed fuel tank and found that the feeding hose has a hole due to it rubbing on the tank recommended replacing fuel sending unit, ring and hoses due to mileage. Which is only 114088. Fuel pump, module unit ring, 2 hoses replaced. There were no warning lamps, messagesor other symptoms prior to failiure.

Filed May 26, 2023 · Fuel system · AR

Leaking fuel from the in-line on top of gas tank. Very dangerous and alarming that this is a known issue and you choose to set back doing nothing. It’s the same exact problem that everyone is talking about so it’s be nice to be reimbursed for the parts or repair or something

Filed Apr 25, 2023 · Fuel system · CA

2015chevy Tahoe LT fuel pump rattle cause fuel line to rattle. Service Bulletin Bulletin No.: 17-NA-304 Date: February, 2020 Subject: Brand: Cadillac Chevrolet TECHNICAL Ticking, Rattle and/or Buzzing Noise Heard from inside Passenger Compartment, Possible Fuel Leak Model: Escalade Escalade ESV Model Year: from VIN: Engine: L86 L86 L83 L83 L83, L86 L83, L86 Transmission: to from to Suburban Tahoe 2015 Yukon Models Yukon XL Models 2020 GMC Involved Region or Country North America, Middle East, Europe, Russia, Chile, Columbia, Ecuador and Peru. Condition 1 Some customers may comment on the following condition: • Arattlingand/ortickingnoisethatmaybelouderinsidethevehiclethanoutside. ⇒ The noise may be picked up at the back of the left valve cover, and/or underneath the vehicle near middle of the driver’s door. ⇒ This noise will be noticeable at idle, most noticeable in the 700-900 RPM range. ⇒ The noise may also sound like a lifter tick. ⇒ This may also be called a fuel line buzz or ringing noise. • Whiletherattleisoccurring,theS-shapeportionofthefuelfeedline,rightinfrontof the tank, will be vibrating / rattling. Condition 2 Some customers may comment on a fuel leak. Diagnosis that the fuel leak is originating from the fuel feed line at the molded-in clip on top of tank. Cause The rattling, ticking noise may be caused by the check valve in the low pressure fuel feed jumper line at the engine not fully seating, allowing pressure pulses from the high pressure side back into the low pressure side of the fuel system. These pressure pulses could cause the S-shaped portion of the fuel feed line, in front of the tank, to vibrate and/or rattle If the S-shaped portion of the fuel line rattles over a period of time, the fore-aft motion in the line could result in wear. This wear could result in a fuel leak where the line is secured into the molded-in clip on the tank.