Engine would not start. When pressing the start button, engine would turn over but would only rough idle for a few moments then turn off. Called garage and had vehicle towed. Mechanic advised computer showed defective fuel pump power control module. Mechanic advised GM has recall N212332040 for defective fuel pump power control module but my VIN is not included. Mechanic ordered fuel pump power control module from GM and replaced on my vehicle. This corrected the problem. I am requesting my VIN to be added to the recall and GM to pay for the part, labor and towing.
2021 Chevrolet Tahoe fuel system complaints
Page 4 of 5: complaints 71 to 100 of 122, newest first, as owners wrote them.
It’s happened about 10 times since I’ve owned the car but the dealer can’t recreate it so we are out of luck. The vehicle accelerates on its own. Scenario 1…with constant light steady acceleration, it will lurch forward like I’ve stomped on the accelerator a bit, for about a second then go back to my normal input. Scenario 2, same lurch but this time while coming to a stop at a stop sign WITH MY FOOT ON THE BRAKE PEDAL ONLY. scenario 3…I’ve been using the adaptive cruise control and had it disengaged by braking, coming to a stop, then parking and turning the vehicle off. Then after getting back in and starting up and slowly pulling forward, the cruise control suddenly and abruptly renegages and attempts to accelerate to the last demanded setpoint. Image this scenario pulling out of a spot at a crowded gas station with pedestrians. I almost ran someone the hell over just now at the gas station and I’ve had enough. The dealer won’t do anything and when I called Chevy engineering they put zero effort into it, it was a 20 second phone call stating if it can’t be reproduced at the dealer there’s nothing they can do. This is absolutely completely 100% dangerous and unacceptable
In September 2024, our vehicle was unable to be start with engine light on. We were unable to get the car into drive or neutral. We were forced to pay out of pocket to have the car towed to dealer, which it needed to be dragged onto the tow truck. Upon inspection at the dealership we were told it was the fuel pump control module that failed and needed to be replaced. They searched recalls and found none on our vehicle but did comment they are replacing these a lot on same type of vehicle. The part was out of stock & backordered likely due to multiple issues, and took 2 weeks to arrive. Reviewing online many have experienced same issue while driving, luckily, we were not. There is an open recall on this part for many models of the same year and time, but for one reason or another our vehicle is not part of that recall #21V739000 / GM #N212332040. The replacement was covered under warranty but does not cover the tow of almost $300.
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while reversing out of the driveway, the vehicle suddenly lost acceleration and the message to restart the vehicle was displayed on the instrument panel. While attempting to restart the vehicle, the vehicle failed to restart and another message that the conditions were not met to restart the vehicle was displayed. The contact contacted OnStar to assist with starting the vehicle. The vehicle was started; however, the engine failed to remain running. The vehicle was towed to the dealer who informed the contact that the VIN was included in the federal safety agency Campaign Number: 21V739000 (Fuel System, Gasoline) and completed the recall repair. The contact stated that approximately two years later after the recall repair was performed, the failure reoccurred while the vehicle was idling. The message to restart the vehicle was displayed on the instrument panel; however, while attempting to start the vehicle, the started sputtering. The vehicle was towed to the same dealer and the contact was informed that the vehicle needed to be repaired under the recall again. The dealer informed the contact that the remedy was no longer covered under the recall, but the repair would be covered under warranty. The dealer informed the contact that the part was on back order and the vehicle would be repaired once parts became available. The vehicle had not been repaired. The manufacturer was made aware of the failure and opened a case. The failure mileage was 8,345.
The contact owns a 2021 Chevrolet Tahoe. The contact stated while driving 20 MPH, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the vehicle failed to restart. No warning lights were illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the fuel pump control module. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 37,000. The VIN was not available.
The contact owns a 2021 Chevrolet Tahoe. The contact stated while driving at an undisclosed speed, the vehicle stalled. The vehicle was towed to the dealer where it was diagnosed with fuel pump control module failure. The contact was informed that the fuel pump control module needed to be replaced. The vehicle was not repaired. The contact stated that the fuel pump control module was recently replaced prior to the failure reoccurring. In addition, the contact stated that the fuel pump control module was also replaced in 2022. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was approximately 20,000.
Engine began to stall while driving or would not restart after parking. Happened one time while driving on highway [XXX]. Towed to dealer. Same fuel pump issue as recall N212332040 however that build date window closed March 4 2021 and my Tahoe was built in June 2021. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Driving on the I-95 I abruptly lost power driving in the left lane, RPM dropped all the way down and speed was rapidly decreasing. I had to pull over on the shoulder in the most safe manner possible for myself and other drivers on the road; but it was not without any risk. The body of the car was rattling on my way to the shoulder and the car shut off before I could put the car in Park in a safe place. With my hazard lights on I tried restarting the car but the enging would not turnover, the starter would run and the car would rattle about all whilst creating a traffic jam. Once i noticed the engine light and yielded to the car's inabiltiy to start up, we got the attention of a FHP State trooper who called in a Tow truck for us. Getting te car onto the tow truck in traffic also increased the risk associated for everyone involved. Aftert succesfully oading the car, which was no smooth task as the car could not shift into Neutral; we took the car to my local Firestone. After a diagnostic test done the following morning, we were notified of a fuel pump issue that has been on the recall list for my vehicle, but NOT associated with my VIN.
Stopped for gas, then proceeded to leave store, the check engine light came on, and car immediately shut off while on the highway going ~25mph. Car would not turn back on, and then lights for fuel machine error started coming on. Car sat there trying to turn on, lights off, and then would say push start button, but nothing happened. Car began to shake and continued to try to turn on, yet nothing happened. Car was towed to home, sat for an hour and then started again, check engine light remains on.
Several times over the last month, or so, my 2021 Tahoe has hesitated to accelerate while driving. On 7/31/2024 the vehicle was in park, turned on when the vehicle began idling VERY hard, shaking the entire vehicle. The engine was turned off and restarted approximately 10min later. I began driving when the vehicle began shaking, the engine light came on, and the engine then turned OFF while in drive, actively driving down the road (with my child in the vehicle). I coasted into a parking lot and attempted to restart the engine several times, without luck. After sitting for approximately 45min the engine restarted, and I was able to get home. The engine stopped and restarted several more times that evening, without issue. The engine light turned off. The following day the vehicle ran without issue, no engine light on. We took the Tahoe to Total Performance Repair shop where they ran a diagnostic scan of warning light history. The diagnostic scan came back with codes P023F and P129F; fuel pump issues. There is currently a recall for fuel pump module failure on some 2021 Chevy Tahoe vehicles. My specific vehicle is not included in the recall but is experiencing the recalled issues.
Other vehicles of my year and make were recalled. My car was manufactured 8/14/21. I was driving on 6/12/24 and my Car died. I had power. I had fuel but fuel was not getting to the engine. It turns out it was the fuel pump control module that many others were recalled. This could have been a very unsafe situation for me as it died in a traffic lane during morning rush hour. It would not start back up for me. My dealer diagnosed it very quickly and is repairing it in 2 days time. Had I been on the freeway, someone would have rearended me. My car has 22,000 miles on it.
When turning left in cross traffic, the truck stalled. It would crank and try to run, but not start as it wasn't getting any gas. The gas tank was full at the time. The failure was very similar to when I was stranded with the fuel issue in 2021 a couple of months before the recall for the fuel pump failure was issued (NTSA # 21V739000). Fortunately, it did start momentarily so that I could get out of oncoming traffic so that I wasn't t-boned. I was able to get it home, but it failed multiple times in the 8 mile trip back to the house. We will not drive this vehicle as it is unsafe to drive and now we are left to tow the vehicle to the closest dealership which is 50+ miles away. It seems this part only works a few years and then fails.
I was parked with engine on idling and the engine shut off. Tried to restart and it started shaking very rough idle, I turned off and tried to restart it would not start, I tried again and it started shaking again and shut off but the displays stayed on in the car. I called the Chevy dealer and had it towed to them. They ran diagnostics and confirmed it was an internal short inside fuel pump driver control module. They replaced and tested functional now. This is the second time they have replaced this part. The first time was last year driving when the engine decelerated and shut off. This is a safety issue and could be hazardous. My concern is this will happen again and I could be put in a very dangerous situation. I saw a bulletin issued for my vehicle with the same type of issue but my vehicle was not recalled to address Product Safety Recall N212332040 Stall While Driving Copyright 2021 General Motors. All Rights Reserved. Page 1 of 4 Release Date: October 2021 I am not sure if this is the same part or another issue.
Service engine light came on, took it to Chevrolet dealership (2 months outside warranty). They found p2459 for regeneration frequency, performed necessary dpf regeneration procedure and was successful in completing and regeneration event, applied smoke to exhaust system for testing purposes and found large exhaust leak at rear tail pipe connection necessary to install new graphite seal and clamp. Also, found coolant leak at rear of engine on passenger side, upon further inspection found egr cooler coolant hose's actively leaking. necessary to replace hose's at this time. They do not want to release the vehicle back to us for “safety” reasons, while a part has been back ordered for 6 weeks. Doing some research, it appears there has been a trend of issues with the exhaust tail pipe, which is excluded also from extended warranty. I’m surprised, given the frequency of this on a newer vehicle that it has not yet been recalled. The coolant hose is a different issue, but likewise surprised it is not recalled.
The contact owns a 2021 Chevrolet Tahoe. The contact stated while driving 70 MPH, the vehicle inadvertently lost motive power. The driver was able to pull to the shoulder of the roadway, where the vehicle failed to restart for 40 minutes. The check engine warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the fuel pump power control module. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 21V739000 (Fuel System, Gasoline), but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the federal safety agency Hotline for assistance. The failure mileage was 42,000.
My car suddenly stopped while driving on the highway , no warning signs I had to be towed . My car in now at the Chevy dealership, was told was " fuel system issue"
The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving 35–40 MPH, the vehicle abruptly shut off. The contact continued to pump the brake pedal to alert oncoming traffic. There were no warning lights illuminated. The contact called the Police, and the vehicle was towed to an impound lot. The vehicle was towed to the local dealer, where it was diagnosed that the fuel pump control drive module needed to be replaced. The vehicle was repaired. The manufacturer was contacted, and a case was opened. The contact stated that the failure was related to the federal safety agency Campaign Number: 21V739000 (Fuel System, Gasoline). The failure mileage was approximately 38,000.
As a traffic crash reconstructionist, the issue is a MAJOR SAFETY ISSUE. My wife was exiting a residential driveway when the vehicle started to stutter and immediately shut down with no power or any capability to get the vehicle off the road. The shutdown caused the blockage of a residential street on a Friday afternoon, until the correct tow truck arrived. This was due to the fact the vehicle could not be moved due to not being able to start the engine nor the ability to place the vehicle into neutral, without starting the engine or crawling un der it with tools. It was determined the fuel module went bad. There was no warning of the failure of the component. Luckily the shut down of all components of the vehicle did not occur on a high speed or highly traveled road since I did not have any control of the vehicle after the fuel module failed. This is not the first report of the issue to the federal safety agency. Hopefully something will happen to find a fix to put the vehicle in neutral without tools, for the safety of the motoring public.
The contact owns a 2021 Chevrolet Tahoe. The contact stated while driving approximately 70 MPH, the vehicle lost motive power. The contact depressed the accelerator pedal however, the vehicle continued to lose motive power and failed to respond to the accelerator pedal being depressed. The contact was able to pull off the highway and the vehicle was turned off. The contact stated no warning light was illuminated. The contact attempted to restart the vehicle and after several attempts, the vehicle was towed to a dealer. The local dealer diagnosed the vehicle and determined that the fuel pump control module needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to the federal safety agency Campaign Number: 21V739000 (Fuel System, Gasoline). The failure mileage was approximately 40,000.
My wife was driving our vehicle and had (fortunately) just turned onto our quiet street. As she was heading towards our driveway, the car turned off. We couldn’t figure out the issue. After paying for a tow to Sterling Chevrolet in Mount Pleasant, SC, we learned that the fuel pump system had died. This was at 36,071 miles (71 miles over our warranty). We were then told that there had not been a safety recall on the fuel system for our 2021 Tahoe z71. It wasn’t until later that we learned there HAD been a recall and I’m not sure how to handle this. The recall occurred before we took possession of the vehicle (8 months before), thus we were never notified. Per the maintenance records, the fuel system had never been repaired nor was a part replaced on this vehicle. Thus, I believe our vehicle would roll up under this recall and we should be reimbursed for the repair expense.
The fuel pump power control module failed. We were driving on the interstate going around 75mph with traffic. The car suddenly lost power dropped to 60, 40, 20 in 5 seconds. We barley made if off the hwy`s left side when the Tahoe died. Would not start back up and locked in park. Had to be towed on a flat bed dragged up the bed and brought to the Chevy dealer who confirmed the fuel pump power control module failed and replaced under warranty. We have a 2021 Tahoe, there is a recall for this part but it did not include our vin. Really scary breakdown and could have been hit by another car.
The vehicle stalled without warning, while driving. After taking it to the dealership they said it’s the Fuel Pump Power Control Module. After further research I see this has been under recall, however, my vin doesn’t show a recall for this.
The vehicle stalled without warning, while driving. After taking it to the dealership they said it’s the Fuel Pump Power Control Module. After further research I see this has been under recall, however, my vin doesn’t show a recall for this.
Vehicle is sputtering and jerking while driving When slowing to a stop vehicles engine will shut off. I do know that the 2021 Tahoe has recalls on the fuel pump issues but not sure why my vin number isn’t covered under this recall. This is a 2 year old vehicle and already has recalls on this year model on its fuel pump. At this point it is barely driveable and is a danger for myself and my family to drive.
While sitting at a stop sign the vehicle began to stall. I was able to drive 50 feet and it died in the road. The Tahoe is not getting fuel to start. Starter continues to try and engage upon start but the vehicle never engage. The fuel pump drive module seems to be an issue. I can't get the car out of park to have it towed to the Chevrolet dealership. This is consistent with other Tahoe recall vehicles having the same issue.
Fuel Pump Module malfunctioned while driving, causing vehicle to shut down in middle of street. Very alarming when car died while driving, fortunately was not driving at a high speed or on a busy street/highway and was able to move to an exit lane without incident since no shoulder on street, did cause quite a traffic jam (very stressful). Vehicle was towed to dealership after could not be jumped started. Dealership confirmed faulty fuel pump module. Currently at dealership & will be for a while due to part backlog. Received no warning lamps, messages or other symptoms prior to this incident.
On Wednesday,Sept20 2023 I was traveling eastbound in the passing Lane on interstate 90 in New York when my Chevy tahoes motor began shaking violently, chugging, and losing power. The check engine light illuminated. The engine stalled as I frantically tried to move to the berm. There is a lot of large semi traffic on that road and I had a difficult time maneuvering safely without power to get onto the side of the road. I was unable to move completely into what I felt to be a safe area. I continued to try to start the motor after about 10 minutes I was finally able to get it started and move it to an exit where it was towed to community Chevrolet in Meadville Pennsylvania. The Chevy dealer at this point has told me it is a fuel pump problem and they are on back order and there is a strike by the auto workers. They are unsure as to when I can have this problem remedied with the parts that are needed.
We were driving down the road and as I tried to accelerate the car would not go. Then I realized the car said push to start. My husband tried to push the neutral button and told me to restart it but I said you have to push the brake. All this is happening as we are coasting down a main road with speed limits of 55mph and my family is in the vehicle (including 2 toddlers in the back seat). Once we coast to a gravel area off the road I push the brakes and try to restart. My dash goes all black and I try to restart. It tells me battery low push to start. The starter engages and stays engaged until I push the start button again to turn off. The screen tells me it is shutting down functions to save battery. The check engine light is on. We tried 3x with same results. Finally we get out and my parents come to us. Within 15 mins of the initial incident, my husband and dad get in and start my vehicle. My dad suspected the fuel pump. The fuel was right under 1/4 tank but not low enough for the fuel light to be on. They drove to the fuel station, approximately 2 miles away, filled up the tank and drove it to an auto parts store who connected it to a diagnostic machine and it read fuel pump. They drove it back to my home, approximately 2 more miles. The check engine light is still on. I will call the dealership tomorrow. The vehicle has 23,000 miles and is still under manufacturer warranty.
Sudden engine shutdown in the middle of traffics. Vehicle was towed to a Chevrolet dealer. Chevrolet dealer replaced fuel pump power control module.
The suit also says the lifters in affected engines were installed in an incorrect position in the lifter guide and do not always conform to design specifications. Plaintiffs claim their vehicles needed frequent valvetrain maintenance, including “more frequent oil changes, engine flushing and cleaning and/or replacing the valve lifter oil manifold and its filter at regular intervals.”
VIN decoder
See the problems and recalls for an exact car
Buying a used 2021 Chevrolet Tahoe?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history