2018 Chevrolet Traverse fuel system problems

Filed Oct 1, 2026 · Electrical, Engine · MD

First issue-cracked catalytic converter caused leaking carbon monoxide inside vehicle. When I was driving I could smell strong, nauseating fuel smell and would have to drive with windows open to try and get fresh air. Took it to local shop for repair which cost $2700. After repair did some research and found special coverage warranty for 2018 Traverse for this same issue, however chevy told me because I took it to a third party they would not reimburse. Second issue-when car would go into gas saving mode vehicle would shut off quickly then start back up and all alert lights would come on (ie. engine light, parking light, etc.), vehicle would also show typed alert on screen something about power steering would be modified and drive safely. Recently took it to chevy to have it looked at, 3 issue were wrong, one being the purge solenoid needing to be replace. Because of known issue before, did some research and also found a special warranty coverage for 2018 traverses for this issue as well. However, my VIN is not showing any of these recalls so now chevy says they will also not cover this.

Filed May 11, 2026 · Electrical, Engine · IL

Special coverage programs for the 2018 Chevy Traverse front exhaust pipe mounting bracket failure. GM has focused on coverage specifically on 2019-2021 models, but 2018 models are affected as well. I'm being forced to pay for a new exhaust when 2018 models should have been included for the Specific special coverage (e.g., N212356540, N222385510) exists for 2019–2021 vehicles, offering repairs (sometimes for 15 years or 150,000 miles) when the front mounting bracket breaks.

Filed May 6, 2026 · Engine, Fuel system · TX

The vehicle shudders and it very slow to shift from park to drive.

Filed Apr 27, 2026 · Fuel system · CA

My engine light came on, so I took it the mechanic. According to the reading it says it was my purge valve, they replaced. After driving 30 miles it came back on. I took it back and they thought it was a defected part so they replaced it again. After 30 miles, it came back on. The mechanic searched online and showed me this issue was for 2019 for a recall. I contacted GM to see if there is a recall for 2018. They said no. At this time the engine lights stays on, but it gives a evap engine light. I can't pass smog due to the issue. The gas tank does not have a cap, it's open. This is how it was when I purchased the vehicle.

Filed Apr 8, 2026 · Fuel system · TX

Valor Canister Purge solenoid is faulty. After filling it up with gas and start driving the vehicle begins to stutter. After a stop at an intersection the vehicle begins to stutter and shuts off.

Filed Mar 17, 2026 · Fuel system · KY

The exhaust system on my 2018 Chevrolet Traverse has failed due to cracking in the exhaust pipe and/or muffler assembly. This appears to be consistent with known issues in similar model years where exhaust pipe brackets separate and cause cracks or holes in the exhaust system. The failure has resulted in excessive exhaust noise and potential exhaust leakage. The dealership has confirmed the issue and recommended repairs costing several thousand dollars but stated my VIN is not included in the existing recall or special coverage. Yes, the vehicle and failed components are available for inspection upon request. The failure of the exhaust system creates a risk of exhaust gases, including carbon monoxide, entering the passenger cabin, which poses a serious health hazard. Additionally, a compromised exhaust system can affect vehicle performance and emissions, and in some cases may increase the risk of fire if hot exhaust gases escape in unintended areas. This issue is especially concerning because it has been identified in other model years of the same vehicle, yet my vehicle is not currently covered, despite experiencing the same failure. This creates an ongoing safety concern for myself, my passengers, and others on the road. The problem been reproduced and confirmed by a certified Chevy dealer.

Filed Nov 15, 2025 · Engine, Fuel system · TX

ome customers may complain of a rattle or exhaust noise, a CEL/MIL on, or repeat concerns of lean codes or converter failures. The cause for these concerns could be a broken or poor weld with lack of penetration on the Bank 2 exhaust. Issue is exact same as listed in Bulletin PIP5681A

Filed Oct 21, 2025 · Engine, Fuel system · 55,000 miles · TX

The contact owns a 2018 Chevrolet Traverse. The contact stated that while operating the vehicle, the check engine warning light remained illuminated, and the vehicle hesitated while accelerating. Additionally, the vehicle failed to immediately restart after refueling. The vehicle was taken to the local dealer, who diagnosed and determined that the purge valve was faulty and needed to be replaced. The vehicle was not yet repaired. The contact stated that the purge valve was replaced on two previous occasions. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 55,000.

Filed Aug 13, 2025 · Engine, Fuel system · MI

The vehicle has a design flaw which causes a bracket which connects the 2 pipes which connect to the catalytic converter to fail. Once the bracket has failed, the rear catalytic converter is allowed to vibrate more than designed, adding extra stress to the catalytic converter. Over time, this additional stress causes the catalytic converter to fail, releasing harmful gases directly from the engine exhaust manifold with carbon monoxide and other harmful gases into the air and into the passenger compartment of the vehicle. This is a know issue that GM has recalled on the 2019 (recall N212356540) and 2021 (recall N222385510) model year Traverse. Other years may have also been recalled that I am not aware of. For some reason, GM has neglected to take ownership of this issue on the 2018 Traverse which shares the same design as both the 2019 and 2021 model years. I have gone to the dealership and contact Chevrolet's customer service multiple times and they refuse to reimburse me for the cost of the necessary repairs. I have already purchased the broken and necessary, ancillary components and repaired the vehicle myself because I did not want to pay the dealership over $2000 in labor which they quoted me.

Filed Jul 21, 2025 · Fuel system · CA

I have had to repair the muffler and now the catalytic converter. There was a fissure on the muffler and now there’s a fissure on the catalytic converter.