2006 Chevrolet Uplander steering problems

Filed Nov 29, 2018 · Electrical, Engine · 100,000 miles · PA

I looked up every problem an recall for the 2006 chevy uplander cause we bought the van when it had 40,000 miles since we got it it was in an out getting fixed the siding doors would just open the electrical was an is all messed up the back suspension makes a clicking sound we had to get a new transmission the steering knuckle broke are van has every problem an recall that is listed about this van but when I but the VIN it said that it has none that's bull it's has more then then even have listed this van was an is a lemon since we got it an everyone from the beginning didn't want to hear it now it broke down again the lights are going off an on, the temp shoot to hot an it shut off please help me an my wife we have three kids an this van is all we have we paid for almost everything out of pocket an now we can't to me gm should fix everything that is wrong with it an add the recalls that it has or is this the type of van they sell I just don't no how this much can go wrong with one van that has no recalls we where driving it when the steering went I don't no how we are still living an did not wreck same with tonight when all the lights inside an out just went off it was dark an my wife was driving with are three kids

Filed Jul 24, 2014 · Steering, Suspension · 27,009 miles · OH

Soon after the purchase of the van I had a problem with to much play in the steering and noise in the front end. I took it back to the dealer and they said they could not verify the problem, so we went back numerous times ,finally in 4-20133 they replaced the steering shaft. It seem to be okay for a while but after driving about 2000 miles it was loose again. My warranty has ended so the dealer says I have to pay for another shaft. How many times should this be replaced to be considered safe? Has anyone else had this complaint?

Filed May 24, 2014 · Brakes, Electrical · 50,000 miles · NC

Ignition switch will not start engine periodically...stuck in key switch. Have to start vehicle inbetween drive and neutral. Have to roll backwards in vehicle while trying to get gear in drive can only park with vehicle front end at upward slant or vehicle will not start at all. Abs light on and off all the time. Do not know if uplander van is a suburban or not, so not sure if on list provided on this form. This been going on for years, and I was told it was a known problem by others, but have not had the ability to get it fixed purchase vehicle in pinehurst north carolina thank you

Filed Apr 9, 2014 · Steering · 59,000 miles · NY

Tl* the contact owns a 2006 chevrolet uplander. The contact stated that the tires would require replacement every year. The vehicle was taken to an independent mechanic to determine the cause of the recurring failure. The mechanic stated that the tie rod end needed to be replaced. The tire rod end was replaced however, the failure recurred two years later. The tie rod end was replaced a second time but to no avail. The tie rod end was consistently replaced every year over the course of four years. The failure mileage was 59,000.

Filed Mar 17, 2014 · Steering · 3,000 miles · WI

Tl* the contact owns a 2006 chevrolet uplander. The contact stated that while driving at any speed, there was a loud clunking noise coming from the front of the vehicle. The failure was recurring the vehicle was taken to the dealer and diagnosed that the intermediate shaft, rack and pinion would need replacing. The vehicle was repaired but the failure recurred. The repair was made three times but to no avail. The manufacturer was contacted and stated that they would be liable for the repairs if they found that the exact same repair was needed to correct the failure. The vehicle was inspected again and the dealer stated that the bushings were what needed to be replaced. The bushings were replaced however, the failure persisted. The manufacturer was notified of the failure multiple times. The approximate failure mileage was 3000.

Filed Jul 17, 2013 · Driver assistance, Steering · 89,900 miles · MD · crash

A deer ran across the road. In an effort to avoid a collision, my wife swerved but the vehicle began to spin around and she could not control it by counter steering. My wife struck a post sideway on driver side. The vehicle was declared a total lost by california insurance who has the vehicle.

Filed Jun 18, 2012 · Body, Electrical · 4,200 miles · FL

I bought my uplander at dealership milage was at 24,000. The door would open and not close we finally got this fixed I hope. Just yesterday at milage 45,000 we had to replace tie rod on passenger side. Found out that it did not have grease pin on it called manufactor and they say someone had to have replaced it. I do not believe it had ever been replaced and this is what is causing tire wear and vibrations in the uplanders which also could cause accidents even deaths. Also when driving all lights will go off until you hit brakes I have had diagnotics checked to see if anything would show up. Nothing does. So this is a major concern also . There seems to be the same problems listed from almost everyone and some of these things could cost consumers their life or their families. While I like the uplander I am concerned that the safety issues are not being handled by manufactor and no one seems to care. What will it take to make this vehicle safe.

Filed May 10, 2012 · Steering · SD

This unit when steering input to the left makes a humming noise synonymous to the steering knuckle recall bulletin. When I took it to the dealer for diagnosis they asked for serial number that I provided and they stated my unit is not up for the recall and now what is my recourse?? I have spouse and 3 toddlers and commute daily at 110 km per hour for over 300 km. I am quite worried and afraid if something should fail mechanically as the noise is from the drivers side and puts us in the direct line of oncoming traffic for a potential head on collision and the dealer reps were not at all sympathetic or concerned and just brushed me off without offering an option at the very least. Any help is much appreciated. Thank you.

Filed Apr 6, 2012 · Brakes, Steering · 61,000 miles · MO

Tl* the contact owns a 2006 chevrolet uplander.the contact stated that while driving 5 MPH the vehicle exhibited an abnormal sound from the front end. The contact took the vehicle to a dealer. The dealer diagnosed the failure as a fractured tie rod. The contact also stated that the rear brakes would malfunction at low speeds, increasing the stopping distance. The dealer repaired the front suspension and the rear brakes. The failure and current mileage was 61,000. Updated 05/10/12

Filed Mar 2, 2012 · Driver assistance, Steering · 84,000 miles · IL

I bought my 2006 chevy uplander used with 74,000 in fall of 2011. While at an busy intersection stop sign, the traction control and stability service lights came on, then all dashboards lights came on and the van stalled. All lights (both interior and exterior) shut off and I couldn't restart vehicle. Road conditions were dry and clear. After rolling onto the side of the road and letting it sit for around 5 minutes, it started and did not have any more problems. The following week, it happened again while driving on the highway. Road conditions were slick and snowy and the traction control and stability lights came on, then there is a "clicking" sound in steering column. The van stalled, started, stalled, and started again on while I am driving down the road. I was able to turn onto a country road and shut it off (basically it died). I waited and restarted to try to get to town. It began happening again and this time I lost control and ended up in a field (luckily no injuries). After getting it out I took it to the dealership (no issues on way there) they hooked it up and there weren't any codes coming through. Tech drove it over 4 days and it never happened to him. Then today as I was driving into town, it happened again. The traction/stability light comes on, you hear a "clicking" sound in the steering column, and it begins to die/start again while continuing to drive. Eventually it just dies. I will let it sit for a time and then restart it. Depending on how long it sits (over an hour is better) it will either continue with issues or drive normally for upto a week before issue begins to reoccur.