2017 Chevrolet Volt: fire, smoke or burning smell

Filed Sep 1, 2023 · Electrical · 40,000 miles · MD · fire

The contact owns a 2017 Chevrolet Volt. The contact stated that while driving approximately 65 MPH the message "low brake fluid" suddenly displayed before multiple warning lights began to illuminate and the vehicle stalled. While the vehicle was coasting on the shoulder the contact discovered that the braking system had malfunctioned and the vehicle did not stop when pressing the brake pedal. After coasting to a stop the contact noticed smoke coming from the front end of the vehicle. Eventually, the flames engulfed the front end of the vehicle and the fire department was called to the scene and extinguished the flames. The vehicle was destroyed and towed away. A fire report was taken at the scene. The cause of the failure was not yet determined. The manufacturer and local dealer were notified of the failure. The failure mileage was 40,000.

Filed Feb 14, 2022 · Engine, Fuel system · TX

EGR Valve in 2017 Volts is faulty/defective 1) Right from the time the car was brand new, smell of exhaust in Cabin when engine warms up 2) When EGR Completely failed a) Loss of Propulsion b) Strong burning smell in cabin - like plastic burning No such problems with new EGR installed Here are lots of other people's similar problems with the EGR Valve https://www.gm-volt.com/threads/2017-interesting-egr-valve-failure.328621/ https://www.gm-volt.com/threads/2017-egr-valve-walk-home-fuse-saga-update.339078/ https://www.gm-volt.com/threads/17-volt-w-68k-miles-p0401.338840/ https://www.gm-volt.com/threads/2017-premier-25k-reduced-propulsion-power-overheated.338864/ https://www.gm-volt.com/threads/2017-fuse-f3-blown-egr-valve-part-12691147-is-out-of-stock.339131/ https://www.gm-volt.com/threads/2017-egr-problem-at-25k-miles.334723/ https://www.gm-volt.com/threads/2017-engine-not-available-yikes.339067/ https://www.gm-volt.com/threads/egr-valve-being-replaced-2017-volt.340639/#post-5063406 https://www.gm-volt.com/threads/replacing-egr-value-yourself.341033/#post-5068080

Filed Feb 7, 2022 · Electrical · VT · fire

Went into a store to pick up a snack and the cashier noticed that my driver side door was on fire. The entire indoor panel was melted and burned. It looked like the fire started on the inside of the door panel where the wiring is. The car was turned off at the time of fire

Filed Sep 24, 2021 · MO · fire

Unknown what caused the fire per fire department. I drove to my bosses house and parked the car for about 15 minutes. I was about to leave in the car right before the fire started. At 12:05PM on 09/22/21 the car started smoking and fire appearing under the car. My safety and other by standers was put at risk by the thick black smoke and flying debris from the car. Thankfully I was not driving when the car caught fire. There were 4 different explosions two of which I believe were the two front tires and the gas tank. The Saint Louis County police and West County EMS & Fire protection both took a report but I do not have a copy of it. No warning signs or lights on the car when I parked it.

Filed Aug 31, 2021 · Electrical · 76,000 miles · MI · fire

The contact owns a 2017 Chevrolet Volt. The contact stated while the vehicle was standstill when the battery charger plug caught fire. The contact was able to extinguish the fire with his fire extinguisher. The fire department nor the police department was not contacted. The contact stated no one was injured or seek medical attention. The contact stated the vehicle was still drivable but unable to charge to drive. The contact called the local dealer and was made aware the failure. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 76,000.

Filed Jun 6, 2021 · Electrical · MD · fire

The charger that was supplied with the new car caught fire in the J Connector handle and melted (pictures attached). this happened in my garage and I discovered it within 3 hours after it happened due to a chemical smelling smoke haze in the garage, and a pile of ash on the floor under the J Connector. There was no other damage other than the connector and it took a few hours to air out the garage. I had plugged it in to be charged at 12 amps with the dash indicating "7 miles" of charge left. The dash indicated "9 miles" of charge available after the fire (full charge this time of year is approximately 58 miles). The fire went out on its own. The charger has been plugged in the same outlet for the last 3 years and there is almost no load on that circuit other than the car (exterior lighting that has 4 led bulbs of low lumens). After the fire my wife recalled that she thought the charger handle felt hot once the previous week when she unplugged it. This is a serious safety issue because it could have started a house fire and risked the health, lives, and safety of my family--5 of us and a dog, nevermind the damage to property and risk to first responders. I reported this to the dealer I bought the 2017 Volt from new, which is Fitzgerald Auto in Frederick, Maryland. They asked me to bring the charger and car out same day which I did. It took them 3 days to call me and inform me solely that the charger is not covered under warranty anymore because it has been more than 3 years and 36 thousand miles since I purchased the car, and they told me technically it is "an accessory" and not part of the car. They asked me to purchase another charger from them at more than $600 which I declined to do. I do not know if they informed Chevrolet/General Motors of the issue or sent the damaged charger in for analysis. They did not comment at all on the safety part of it.

Filed Feb 1, 2019 · Acceleration, Electrical · 26,000 miles · CA

Driving up the freeway at a normal speed, my volt began to accelerate without warning and after applying the brakes again began to accelerate involuntarily. After I managed to pull to the side of the road by applying the brakes hard, smoke came out of the hood. I called a tow truck and he had to jump the car to start it again.

Filed Dec 1, 2018 · Electrical, Engine · 14,300 miles · CA · fire

I leased this car in september 2017. On november 30, 2018, I got onto the freeway while running on gas and the vehicle began smoking within about 5 minutes. I pulled over and got out and the vehicle caught fire and was destroyed. There were no previous mechanical or electrical issues or any warning signs. I have driven the vehicle countless times on gas rather than electric charge. The fire started under the hood on the passenger side. The entire interior, all windows, the front tires, and the front of the car were completely destroyed. I have seen 2 other reviews on this website about spontaneous vehicle fires.

Filed May 9, 2018 · Electrical, Fuel system · 20,000 miles · TX · fire · 1 injury

Urgent urgent. This is something wrong with the 2017 volt. My vehicle caught on fire while driving down the interstate at higher speeds. I have found two others that this has happened too. Gm didn't even investigate before denying liability, they made a determination over photos. All 3 vehicles had over 20k miles on it. Others lives may be in danger. Please investigate.

Filed May 8, 2018 · Electrical, Wheels · 27,000 miles · TN · fire

My car has had electrical problems since almost the first day of ownership. My car has had constant electrical problems. I contacted gm and even showed them a video that showed what my car was doing as far as not turning off when I pressed the button to shut the vehicle off. I would appear to shut off only to turn back on repeatedly. Gm did absolutely nothing to fix my issues except run in circles and claim they couldn't/wouldn't do anything about it cause the dealer couldn't duplicate the problem. Even though I had video proof of what my car was doing to me. It only happened at random and was very sporadic. My car has now caught on fire and burned to almost nothing and I am out a lot of money. Just take a look at my site www.chevyvoltsucks.com to say I am pissed at gm is an extreme understatement. Numerous complaints were made and only proved to be a total waste of time and given lame excuses. I also had repeated problems out of the rims bending causing replacement of these rims on an extended contract I had that covered the rims and tires. I have owned numerous cars over the past 30 years and have never bent a rim in my life until this car and it was over 4 rims bent in total in less than a year of owning this car.

Filed Apr 11, 2018 · 20,000 miles · TX · fire

On sat april 7th, my 2017 chevy volt randomly caught fire while driving down the interstate. I was able to pull over and exit the vehicle only suffering from smoke inhalation. This was my second volt and I had driven it over 20k miles. Here is what I do know. There was no warning, only flames engulfing the front of my vehicle. 8 days prior, the chevy dealership did some recall updates on my vehicle. I was traveling at highway speeds (70+) on the gas backup mode this was the first time driving at these speeds on 0 battery after picking up my car from the dealership it has been 4 days since the incident and I am utterly disappointed that nobody from gm has reached out to me regarding this incident.

Filed Apr 3, 2016 · Driver assistance, Electrical · 135 miles · CA

2017 chevrolet volt extreme engine hazard: on 22-mar-2016 I purchased a 2017 chevrolet volt premier, all safety options. Driving on freeway at 65 MPH, straight driving, relatively light traffic, the engine light came on yellow and steady (emissions system service warning) but the car uncontrollably decelerated. The freeway had no shoulder due to construction. The car smelled of burning electrical insulation confirmed by the tow truck driver. The car, with less than 150 total miles, in clear weather, at twilight, 76 degrees, california at sea level, straightaway, had a sudden and near total loss of all propulsion. This caused a lack of control (obviously) in the forward direction, causing an extreme hazard on the freeway. I am an experienced driver: make no mistake, this was a serious manufacture's error. I checked, no parking brake, the car was in drive gear, I had both electric range and over 7/8 tank of gas showing a gas range of 360 miles - and I had just driven 60 miles. There was no brake smell, as I did not need to apply the brake because the engine gave no propulsion. My hand was off the regen switch. The car had a major malfunction causing an extreme hazard, and based on the smell, possible fire hazard.