2018 Chevrolet Volt: check engine light

Filed Oct 24, 2026 · Electrical, Fuel system · UT

While driving through a canyon to get home, my check engine light came on and I saw the message "Propulsion Power Reduced" on my dash. The speed limit on that road is 65 mph, and I lost power going up a hill and went from 65 mph on cruise control to 48 mph. There are a lot of cars on that road, and it could've caused a serious accident. My vehicle does exactly what the GM extended coverage describes and is within the parameters, but somehow my vehicle does not qualify. This could've been bad on that road is it was raining or snowing.

Filed Sep 25, 2026 · Electrical, Fuel system · OH

FAILURE SUMMARY & SAFETY RISK: While operating in live traffic, the vehicle experienced a sudden loss of motive power and entered a "Propulsion Power Reduced" failsafe mode, creating a severe rear-end collision hazard. The vehicle is currently grounded and remains available for inspection upon request. WARNING SYMPTOMS & DIAGNOSTIC CODES: The instrument cluster illuminated the Malfunction Indicator Lamp (Check Engine), the ABS warning indicator, and displayed a persistent "Propulsion Power Is Reduced" message. A diagnostic trouble scan confirmed active high-voltage communication failures and powertrain faults: U2603 (Lost Communication with Hybrid/EV Battery Interface Control Module), P25A2 (Brake System Control Module Requested MIL), and ABS code C0500-00. PRIOR HISTORY & FAILURE TO CURE: This identical high-voltage Battery Energy Control Module (BECM) failure previously occurred in December 2025 at 97,808 miles and was presented to an authorized Chevrolet dealership for repair. The facility claimed the vehicle was repaired, but the exact same catastrophic high-voltage failure recurred in under 4,000 miles (at 101,635 miles). MANUFACTURER POLICY & OBSTRUCTION OF REPAIR: General Motors recognized this hazardous defect under Special Coverage N232432680 (covering BECM replacement for 15 years/150,000 miles at $0.00 cost). This policy links to GM Master Bulletin 07-00-89-037S mandating direct-bill Courtesy Transportation for grounded safety defects. Despite this, when presented for warranty repair, the authorized Chevrolet dealership explicitly refused intake and refused to honor the transportation mandate, stating on the record: "Yes, I do decline". GM Corporate (Case 98734634) admitted coverage applied but failed to compel franchise compliance, leaving a dangerous, immobilized high-voltage hybrid vehicle stranded without access to safety-mandated repair bays.

Filed Aug 27, 2026 · Engine, Fuel system · TX

I was driving back from [XXX] on XXX, when I received a "propulsion power limited" message on my dash with a check engine light. I pulled off to a nearby gas station and tried to scan the code to figure out what was going on when I then received the message "Engine unavailable" and the car shut off. I checked the fuse box and found that the F03 Fuse had blown. I replaced the fuse and attempted to start the car again. It began normally, but then after driving 10 feet, I received the "engine unavailable" message again with a check engine light and the car no longer had power and I had to coast into a parking spot. I checked the fuse again and found it was blown. If I had not stopped in the gas station, I would have been stranded on the side of the highway, or worse yet, I would have stalled out on the highway and potentially got hit. I had my car towed to a dealership who eventually completed their inspection of the car on XXX and determined that the EGR Valve had failed (the servo motor burned out and blew the F03 Fuse). This is a well known issue on the 2nd Generation of Volts and it is likely faulty servo motors in the EGR valves. The Dealership even included in its financial assistance request to Chevy on my behalf that the EGR valve failure is a known issue. When asked if there was any preventative maintenance suggested to prevent the EGR valve from failing, the service technician indicated that there wasn't anything that I did as the end user to cause the problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 17, 2026 · Fuel system · OR

I was driving on an interstate in Seattle, and the car completely died. A check engine light went on. I had to roll into the shoulder and call for a tow to the dealership's service department. Here is what they found: ----60GCZ ENGINE REPAIR DIAG/ customer reports the ses lamp is on with reduced propulsion message displayed. Check and advise. 1. Tested vehicle and verified reduced propulsion power message and SES light. Scanned vehicle for codes and found multiple P0489, P0030, P0031, P0132, P0135, P0137, P0443, P0458, P0597, P0598, P06DA, P06DB, and P103C. Traced back to no power on circuit 5293. Traced back to blown 15-amp fuse 3 of under hood fuse block. Found bulletin #24-NA-080 stating this can be caused by a short in the EGR valve. Tested circuit 5293 and found short at the EGR valve. Advise EGR valve and cooler replacement then retest.---- We disconnected the EGR valve, which means we are driving only on gas, not electric. We cannot charge it anymore. The cost to replace the valve and cooler is over $4k because Chevrolet does not make the vehicle anymore or the EGR valve part apparently. This is a SIGNIFICANT safety hazard if the car is going to simply die suddenly. It is a miracle I did not get hit.

Filed Aug 5, 2026 · Electrical, Engine · TX

While driving on a highway the car started to hesitate, a message appeared on the console "Propulsion power is reduced" and the engine light turn on. After driving some miles, a new message appeared: "Engine unavailable, service soon" and the car only ran on electric power, no motor engine. I had the same problem 3 year ago and the dealer identified the problem as a shorted EGR valve. This time I knew this shorted EGR valve burns the F3 fuse. I managed to get to a car part shop and bough several fuses (15 amp). After replacing the fuse 3 times I managed to get to the dealer. The repairs cost $3000+ (up from $1000+ 3 years ago). This problem is well documented on the GM service technical bulletin "21-NA-116" dated February, 2023. Three years ago I was in the middle of nowhere in South Texas and it took 6 hours to get a tow truck This time I was lucky enough to be close to to a town that the remain battery power was enough to get to the store where I bought the fuses. GM should recall this part and do a proper fix

Filed Jul 24, 2026 · Electrical, Fuel system · FL

The Battery Energy Control Module (BECM) failed. Before repair, the check-engine light appeared intermittently, the vehicle sometimes had difficulty starting, and the indicated electric range could suddenly drop from about 30 miles to zero despite a charged high-voltage battery. When this occurred, the gasoline engine started unexpectedly. The air conditioning also intermittently blew warm air until the vehicle was restarted. These symptoms created a safety concern because propulsion mode and indicated range could change without warning, and the vehicle could fail to start in traffic or another unsafe location. An authorized Chevrolet dealer confirmed the problem. The dealer retrieved DTCs U2624 and U2629, performed circuit testing, and diagnosed an internal short in the BECM causing loss of communication with high-voltage battery modules. The dealer stated this failure caused the warning light, starting issue, sudden loss of indicated battery range, and air-conditioning symptoms. The BECM was replaced and programmed after removal of the high-voltage battery assembly. The warning light first appeared about one month before repair, with the other symptoms becoming more apparent in early July 2026. The vehicle had approximately 80,918 miles when inspected. The failed component was retained by the dealership as a core and is not available to me for inspection. To my knowledge, the vehicle was not separately inspected by police, insurance, or GM engineering personnel. My vehicle was excluded from GM Special Coverage N232432680 even though it is a 2018 Chevrolet Volt with the same confirmed BECM failure addressed by that program and the federal safety agency investigation PE23022. I paid $3,970.56 for the repair. I am filing this complaint because this defect can cause no-start, loss of indicated battery range, warning lights, unexpected propulsion changes, and potentially reduced propulsion, while some affected 2016–2018 vehicles appear excluded from the special coverage.

Filed May 1, 2026 · Acceleration, Fuel system · NC

I was driving my 2018 Chevy Volt at about 30 mph on EV mode. The battery was at 50%, the car was performing normally. Then the battery jumped to 100%, the check engine light came on, and the vehicle lost power. I was in rush hour traffic and unable to get the vehicle to go faster than 5-10 mph. I switched to "normal" mode to engage the gasoline engine, hoping this would help but it did not. The gas engine RPM fluctuated wildly and did not restore the ability to accelerate the vehicle. I was still unable to go faster than 5-10 mph. I was a few blocks from home and managed to get home safely. The engine code was P1E00. I put the vehicle on the charger and it seemed fine the next day. This exact situation I ran into - reduced engine power - is addressed in Special Coverage N232432680, which includes this vehicles VIN. I took the car to the GM dealer today and they are telling me that the car is fine, they can find no problems. I mentioned that this issue is covered under Special Coverage N232432680, and was told that unless they can reproduce the issue in the shop, that they cannot apply Special Coverage N232432680.

Filed Apr 29, 2026 · Electrical, Transmission · PA

The vehicle (2018 Chevrolet Volt) is experiencing an intermittent failure of the Battery Energy Control Module (BECM). Diagnostic trouble code P1E5B was stored in the system. This is a well-documented defect in this vehicle population that frequently results in a sudden, unexpected loss of propulsion power while driving ("Propulsion Power Reduced" mode), posing a significant safety risk in high-speed traffic. ​Although a Chevrolet dealership confirmed the presence of the stored fault code, they refused to perform the repair under the extended warranty (Special Coverage N23243268) because the Check Engine Light was not actively illuminated at the exact time of inspection. The manufacturer requires the vehicle to be operated until the fault recurs, exposing the driver and others to the danger of stalling on highways or at busy intersections. The failed component remains in the vehicle and is available for inspection.

Filed Mar 23, 2026 · Fuel system · CA

The vehicle losses power on high speed, check engine comes on, low propulsion massage displays. Vehicle does not charge. Issues similar to the investigation DCS6812.

Filed Feb 8, 2026 · Engine, Fuel system · CA

It was the XXX recall for the DTC P0442/check engine light code. The dealership said that the recall had been satisfied in 6/2020 by putting a buffer in to separate the 2 lines but not replacing the part. Now the exact same code DTC P0442/check engine light in the exact spot that occurred for the original recall. The dealership originally quoted $5,093, then after me complaining that it is the same recalled problem they dropped the cots to $2384. I believe that is an agreement that the manufacturer should cover this. Of course I will have to pay to get my car but I would like the manufacturer to reimburse me for it seeing it was a manufacturer default. I spoke to the manufacturer they flat out refused to cover it. I obviously disagree. Would like you to pressure them to change their decision. Thank you, [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 9, 2025 · Electrical, Fuel system · CO

On June 27, 2025, while driving, the vehicle displayed a "Propulsion Power Reduced" warning message and a Check Engine Light illuminated. I immediately experienced a loss of power. I brought the vehicle to an authorized Chevrolet dealer the same day. On July 1, 2025, the dealer diagnosed the failure as a faulty Battery Energy Control Module (BECM) and high-voltage system fault (Code P1E00), requiring a full replacement of the high-voltage battery pack (Part #24296900). The manufacturer (GM) was contacted, and the replacement battery was ordered on July 2, 2025. As of December 2025, the vehicle remains in dealer possession (over 5 months) with no repair completed. The manufacturer has stated the part is on indefinite backorder with no ETA. The failure of this component renders the vehicle inoperable and presents a safety risk due to sudden loss of propulsion power while in motion. The manufacturer has confirmed the failure but is unable to provide a remedy within a reasonable timeframe.

Filed Dec 2, 2025 · Electrical · 129,000 miles · GA

The contact owns a 2018 Chevrolet Volt. The contact stated that while attempting to start the vehicle, the engine failed to turn over as intended. Additionally, the vehicle would not charge when connected to a charger. The check engine warning light illuminated. The vehicle was taken to a local dealer, where the BECM was reset. The vehicle was repaired; however, the check engine warning light remained illuminated. In addition, the contact stated that the message "Reduced Power" was displayed on the instrument panel. The vehicle was taken back to the same local dealer where it was diagnosed, and determined that the BECM needed to be replaced. The vehicle was not repaired due to the cost. The contact related the failure to an unknown Chevrolet recall; however, the VIN was not included. The manufacturer was made aware of the failure. The failure mileage was approximately 129,000.