Mechanical Failure Under Power. No Warning. Full loss of propulsion. Known Issue with GM Vehicle.
2019 Chevrolet Volt electrical problems
12 complaints (34% of all complaints for this car). 2 crashes reported.
- owner complaints
- 12
- of this car's complaints
- 34%
- crashes
- 2
- recalls
- 0
Which part fails
Owners did not name a specific part.
At what mileage
Complaints by mileage at the time of the problem.
0k-25k
25k-50k
50k-75k
75k-100k
100k-125k
125k-150k
150k-175k
175k-200k
200k+
Chevrolet Volt electrical problems in other years
Related recalls
No recalls on record for this model year.
Related investigations
Loss of Motive Power due to the Battery Energy Control Module
On November 29, 2023, the Office of Defects Investigations (ODI) opened PE23022 to investigate allegations of a loss of motive power, including a stall, reduced power state, and/or a no start condition due to the Battery Energy Control Module (BECM) in model year (MY) 2016-2019 Chevrolet Volt passenger car vehicles manufactured by General Motors (GM). The BECM is located within the high voltage electric vehicle (EV) battery pack and monitors the temperature, current, and voltage of the high voltage battery cell groups. GM stated that the root cause was identified as an internal failure leading to a loss of communication within the BECM and does not pose a risk to motor vehicle safety. GM further stated that the failure cannot result in a complete stall, only a reduced power mode, no start condition, or a no charge condition. GM additionally stated that if these conditions occur, the driver will be warned via a Malfunction Indicator Lamp (MIL) and/or a reduced-propulsion message in the Driver Information Center (DIC). Data received and analyzed by ODI from all sources indicates that nearly all related BECM failures caused conditions aligning with GM’s predicted outcomes. Despite the large number of warranty claims, nearly all failures were not safety-related, i.e., not a stall or reduced power mode. ODI isaware of a single minor crash and no injuries or deaths. In March 2024, GM issued Special Coverage N232432680, which was mailed to consumers, addressing BECM failures in certain MY 2016-2018 Chevrolet Volt vehicles. This special coverage provides an extension of the warranty coverage for the BECM from 8 years / 100,000 miles to 15 years / 150,000 miles for all 2016-2018 Chevrolet Volts. Additionally, GM stated that replacement components are sourced from a different supplier and not susceptible to the failure. In view of the Special Coverage issued by GM, the existing warranty coverage already in place, and the low number of safety-related occurrences, ODI is closing this Preliminary Evaluation (PE). The closing of this investigation does not constitute a finding by the federal safety agency that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to
PE23022
Pedestrian alert sounds
the federal safety agency received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, the federal safety agency opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified the federal safety agency he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by the federal safety agency regarding the subject matter of the petition.
DP22005
What 2019 Chevrolet Volt owners say
Most recent owner complaints, unedited.
The contact owns a 2019 Chevrolet Volt. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the battery high-voltage disconnect relay. The vehicle was not repaired due to a lack of part availability. The manufacturer was notified of the failure, a case was opened, and the manufacturer confirmed that the part was on backorder. The failure mileage was 80,000.
Mileage: 38523 Engine Not Available Service Soon Propulsion Power Is Reduced Fuel Range Low: 3/4 Tank full of gas [XXX] - I was driving Northbound on [XXX] South of Castlewood in Northern California. I was driving 70 mph when I suddenly received the error messages above on my dashboard screen. The vehicle immediately had power from 70 mph quickly going below 59 mph. The traffic was extremely high and I had to quickly use my hazard flashes and carefully maneuver to the right shoulder of the frwy. The vehicle lost power so quickly I could have easily been rear ended or in a serious vehicle accident. The dealer test drove the vehicle and stated they received the errors at 95 mph. The dealership is recommending I have the entire transmission replaced with the assembly and the 45,000 mile maintenance. No other warning lamps, messages or symptoms or failures occurred. First occurrence [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Vehicle lost propulsion and all power mid turn at approximately 45mph. Powe steering and assisted brakes were gone. Conditions were rainy, resulting in single car crash. Car did not restart. No codes present. Occurred again after repairs at 70mph on highway. Codes P0AC4 and P0C0E indicating Drive Motor Power Inverter B. Despite being under warranty, GM cannot repair, and has no replacement parts. GM has ignored messages requesting buyback per federal law.
Vehicle has developed an intermittent issue when placed in park. Displays a message "Attention Needed: Shift to Park" accompanied by audio alerts inside and outside of the vehicle. This is obviously unsafe as the vehicle cannot be parked and turned off reliably. GM Technical Bulletin 19-NA-206 issued in May 2021 (attached) specifically states that that this repair is covered for the Volt by the separate Voltec Component Warranty. GM refuses to honor the warranty.
Car just stops when the battery control module stops working. Potential to leave us stranded in traffic. Confirmed as a defective part by the dealer.
1. Intermittent instruction to put vehicle in PARK when trying to start or shut down when in PARK already. 2. Intermittent NO REMOTE DETECTED when remote is in the car
Was approaching an intersection with a stoplight that was red. Another car stopped at light. Applied brakes, but car slowed down only slightly, no matter how hard the brake pedal was applied. It was like braking on black ice, even though the cars wheels were still going around. Rear ended the car at the light. Suspect that computer was telling the car to try to charge the battery using the forward motion of the car instead of stopping the car. All air bags deployed. Injuries were limited to bruises, abrasions, and general body soreness. Vehicle currently in possession of Allstate Ins. Have requested that brake system be inspected, and computer info be downloaded. Car was totaled. No injuries in other vehicle. No previous problems, no warning lamps or messages prior to accident. Car had been well maintained, including all recalls, and received routine maintenance (oil change, tire rotation) about three months before the incident. Problem has not been reproduced, nor is it likely to be since the vehicle is undrivable.
Car does not shift into park without multiple tries. I can’t turn off car if it’s not on park
2019 Volt - Shift to Park issue My 2019 Chevy Volt is having an issue when shifted to Park from Drive and all shift stick positions. If you shift to park to turn off engine you get a message on console that says "SHIFT TO PARK). You have repeatedly turn off/on engine/system to message to clear so you can leave vehicle off. System will not shut off until car reads that car is park. Something (sensor?) is not telling system that car is in Park.
Questions about the 2019 Chevrolet Volt electrical
Does the 2019 Chevrolet Volt have electrical problems?
Owners have filed 12 complaints about the electrical of the 2019 Chevrolet Volt, 34% of all its complaints.
At what mileage do 2019 Chevrolet Volt electrical problems start?
Not enough complaints include the mileage to tell.
Was there a recall on the 2019 Chevrolet Volt electrical?
There is no recall for this problem on this model year.
What year does the Chevrolet Volt have the most electrical problems?
The Chevrolet Volt model years with the most electrical complaints are 2017 (313 complaints), 2018 (90 complaints) and 2012 (86 complaints).
Other 2019 Chevrolet Volt problems
Transmission 17Engine 4Brakes 3Driver assistance 2Fuel system 2Acceleration 1Seats 1Steering 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Chevrolet Volt?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history