2007 Chrysler 300 fuel system problems

Filed Dec 18, 2023 · Engine, Fuel system · NY

Engine constantly leaking coolant from multiple areas on the engine. Have had to constantly get it repaired at least once a month. Also have had constant cylinder misfires, fuel injector system keeps going bad

Filed May 30, 2021 · Airbags, Fuel system · CO

I have 130k mileage on my Chrysler 300 2007 model. For about 3months, I’ve been experiencing fuel leaks from the bottom rear corner of the driver side just directly beneath my fuel tank, which also makes both the exterior and interior of the car smell of gas. I took the car for maintenance and the fuel tank seals were replaced after my fuel pump was changed. There was no visible fuel spill after the rear seats were removed and inspected but there was constant droplets of fuel from beneath the rear left side of the car. I don’t know what else to do and what can cause this?.. besides, whenever I put fuel in my tank, I can smell fuel coming from the AC vents. Also, my airbag warning light has been on for a long time on my dashboard. Help!!!

Filed Jan 14, 2020 · Driver assistance, Fuel system · 138,000 miles · TX

My car will outright just stop for no reason. I will sit at a light and the RPM guage will start going out of control and the car will rev on its own. Then I will start driving and ti will be find until I go to press on the brakes. Then the whole car will cut out. I'm able to get it to turn over again after two or three efforts of turning the key and pumping the brake. It has once done it with my daughter in the car, which I am not okay with. Luckily, we were turning into a neighborhood and not onto the highway into high speed traffic. It turned off and on about 7 times down the road before it started running properly again. It seemed to happen every time I would hit the brakes or attempt to turn. The car cut out like it had run out of gas even though there was plenty in the tank. All the lights on the right side (traction, ABS, etc) came on and then disappeared once it started running okay again. I had my fuel pump replaced twice thinking that was the issue and it was not. Something is wrong with this car and it needs to be recalled before someone gets hurt and it's to late to fix it.

Filed Dec 29, 2018 · Fuel system · 77,118 miles · TX

Car shut off while driving, there was a strong gasoline odor coming from underneath the vehicle, turned back on after a few minutes,gas cap light came on, went to autozone to run scanner and got code p0440, checked all evap components and lines and noticed something loose on top of fuel tank, rollover valve popped off and there was fuel all around it... I'm lucky there were no sparks from anything,had a full tank!

Filed Apr 27, 2018 · Fuel system · 162,126 miles · TX · fire

April 23 my battery caught on fire in blow my whole car up fire marshal told me electrical problems

Filed Jan 31, 2018 · Fuel system · 50,000 miles · CA

Tl* the contact owns a 2007 chrysler 300. After refueling the vehicle with the tank completely full, the vehicle suddenly shut off. The vehicle was taken to several independent mechanics who was unable to determine the cause of the failure. The local dealer (cole chrysler dodge at 805‑540‑5065) was called and the manufacturer was notified, but no assistance was offered. The failure mileage was 50,000. *tt

Filed Jan 11, 2018 · Acceleration, Fuel system · 189,000 miles · AZ

Fuel vapor in cabin

Filed Dec 14, 2017 · Fuel system · 63,000 miles · OR

Tl* the contact owns a 2007 chrysler 300. While driving 30 MPH, immediately after fueling, the vehicle stalled without warning. The vehicle was able to restart. The vehicle was taken to withnell dodge (2650 commercial st se, salem, or 97302 (877) 303-1959) where it was diagnosed that the fuel tank malfunctioned. A part within the fuel tank needed replacement along with the fuel tank. The vehicle was not repaired. The manufacturer was notified and did not assist. The contact mentioned that the 2005 and 2006 chrysler 300 had a recall for the same failure. The failure mileage was 63,000. *tt updated 9/19/18

Filed Jul 11, 2017 · Fuel system · 140,000 miles · NV

Vehicle dies while driving and wile coming to a stop in town. No check engine light. No codes - took it in to the chrysler dealership and they diagnosed a bad fuel tank. The inlet flapper on the fuel tank is defective allowing fuel to overflow the charcoal canister. This is the same problem as the 2005-2006 models that now come with a lifetime warranty on fuel tanks. I called chrysler and they are not willing to work with me to replace it or consume some of the costs, and it is a safety issue. It has dies out in the middle of an intersection over 10 times and wont always re-start. Sometimes it takes 5-10 minutes, and other times it starts right back up. I was in the middle of a turn and the car stalled out and I almost hit the vehicle to the right of me. It is very dangerous and needs to be included in the lifetime warranty issued to 2005/2006 models.

Filed Apr 17, 2017 · Fuel system · 120,000 miles · TX

Tl* the contact owns a 2007 chrysler 300. While the vehicle was stopped, the engine sputtered and then stalled. The failure recurred multiple times. The vehicle was taken to a dealer where it was diagnosed that the fuel tank failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the issue. The approximate failure mileage was 120,000.