2006 Chrysler 300C: engine stalls while driving

Filed Mar 1, 2026 · Fuel system · CA

Completed x53 extended warranty a year prior at dealership, car still stalls only after putting fuel even though always filling to 3/4-7/8 of tank. Had my children with me Car stalled again today at middle of busy street when about to make a left turn after i filled to 3/4 of a tank. Had dodge dealer in Manteca, CA diagnose after first stall half a year prior and they would not replace faulty new tank. Still had to pay diagnostic fee saying fuel liquid was getting into vapor lines and flooding engine and that new tank is not the issue even though it is allowing fuel liquid to pass through vent valve which caused saturation of vapor canister and purge solenoid and engine stalling. Car only stalls when pumping gas 3/4 tank or above

Filed Jun 13, 2025 · Fuel system · OK

After Fueling on several occasions the vehicle just abruptly stalls out and it's very dangerous I notice that there is recalls on other 2006 Chrysler but mine isn't on there but I am very concerned about this as it could cause me to get in a accident

Filed Apr 24, 2025 · Electrical, Fuel system · WI

car stalled after filling gas tank. I was driving through an intersection and had to stop for oncoming traffic, when the car stalled and would not immediately restart, it eventually did start after several panic moments of being stuck in the intersection while the light was changing to let opposite traffic proceed. It stalled 2 more times on the way home. Both times I was slowing the car down when this occurred. I have been fearful of driving this car again since this happened. I heard there was a recall from Chrysler for lifetime replacement of gas tank due to a possible control valve shutoff float failure. My vehicle has never had the gas tank or float replaced, but it does not show up for a recall when I enter VIN. What should I do?

Filed Feb 26, 2025 · Electrical, Engine · LA

There a problem with car stalling and dying because of power being lost to tcm because of tipm. Dealer had my car for 7 weeks and $1900 changing tcm and problems still exist. Didn't even make 10 miles from dealership. Very dangerous

Filed Jan 2, 2024 · Electrical, Engine · MD

While I was driving the car, the car stalled on me at a stop light, its a safety risk and could caused an accident at anytime, yes its available for inspection. Yes the problem has been reported and inspected by auto shop and dealership. No warning lights it just randomly happened while driving, while I was driving the check engine light popped up then disappeared and 2mintues later my car power was reduced and car shutoff at stoplight.

Filed Dec 28, 2023 · Fuel system · 214,624 miles · FL

The contact owns a 2006 Chrysler 300C. The contact stated that the fuel tank was previously replaced under an unknown extended warranty coverage; however, after the repair, the vehicle experienced a failure. The contact stated that after refueling the vehicle and driving at slow speeds, the vehicle stalled. The contact stated that the failure recurred several times while driving and coming to a complete stop. The vehicle was towed each time the failure occurred. The contact stated that the vehicle stalled in the middle of the road during the last failure. The contact was able to push the vehicle to the side of the road with assistance. The vehicle was towed to the residence. The vehicle was then towed to the dealer, where it was diagnosed and test-driven, but the cause of the failure could not be determined. The vehicle was not repaired. The failure mileage was approximately 214,624.

Filed Nov 27, 2023 · TN

When car is cranked and put in gear or stop car will go dead. When driving if I ease off gas and then reapply the gas car will stall which can be quite hazardous while driving. The problem was intermittent has been going since I have had the car thought the tank recall would fix the problem which it we thought had corrected the problem for a time. But it became intermittent at first it was every few weeks and now it does it whenever I drive the car several times as I drive recently I am now afraid to try and drive it especially any distance. The gas tank was replaced due to a recall. Have replaced fuel tank and thermostat. My mechanic isn't sure what is going on. I have seen various forums where others are having the same problems with their 2006 Chrysler 300 C's and have taken them back to the dealer and they have not been able to determine what the problem is. I feel this should be investigated.

Filed Nov 18, 2023 · Fuel system · MA

Once fueled, the engine will consistently stall from start to cruising speed, and has even shut off while driving. There was an issue with Chrysler fuel tanks evap valve sticking open, which causes this fault, however I have not received any assistance from Chrysler or any authorized dealer.

Filed Oct 30, 2023 · Fuel system · VA

My Fuel Tank is stuck in open position, it is making my car stall, sputter, and cut off. When my gas is very low car doesn't cut off and runs fine, but when I fill car up it stalls and cuts off, this is very dangerous it cuts off at red lights, stop signs, slow traffic, I've seen this is a Warranty/Recall problem with the faulty fuel tanks, with stuck open fuel shutoff valve. My car is running at max fuel because of this problem. It's been like this since I bought car 2 months ago. I need this fixed immediately. And all parts on my car are brand new this Faulty fuel tank is the Culprit

Filed Aug 30, 2023 · Fuel system · PA

The car will just shut off while driving or at rest. My safety and other people on the road is unsafe in the vehicle because when it shuts off in the middle of the road the steering wheel is also not working. The car has been to multiple shops with each shop guessing what could be the problem and fixing what they think may be wrong and after 2,000 dollars the car is still stalling out while being drove. No lights or diagnostic test come up with anything that could cause the problem

Filed Jul 6, 2023 · Engine, Transmission · 200,000 miles · FL

The contact owns a 2006 Chrysler 300C. The contact stated that while driving at slow speeds during traffic congestion, the vehicle inadvertently lost motive power and stalled. Upon restarting the vehicle, the vehicle hesitated but seemed to return to normal functionality. No warning lights were illuminated. The vehicle was taken to the dealer however, the dealer was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 200,000.

Filed Apr 15, 2023 · Engine · NC

While driving my Chrysler when I stop at a red light or stop sign the car will simply stall out and die so I put it back in park and recrank it and sometimes it'll die immediately after that and sometimes it'll wait till the next red light or until I'm making next stop. And when the car is in park it'll stall out I'll simply have to crank it right back up sometimes it'll stall out immediately after that and sometimes it'll run for a minute or two and then stall out. But as long as I got my gas my foot on the gas while I'm breaking at the same time it won't die