Chrysler Pacifica Plug-In Hybrid engine failure problems

Filed Nov 14, 2024 · Transmission · CA

Van engine failed during driving. This is a known issue by Chrysler and they will not repair the underlying problem - this is related to a prior recall. Instead, it only suggested replacing the battery which is a temporary fix. Separately, this van has a pending recall due to a fire risk. Unable to use the plug-in hybrid function of the van nor park it in a garage due to the recall issue. It has been almost four months since the recall notice without any news of when Chrysler will fix this problem. I requested a buy back due to the inherent risk of severe injury from simply being inside this van but was denied.

Filed Oct 31, 2024 · Electrical, Transmission · NY

Vehicle check engine light came on preventing state inspection, at same time message on dash states "service charging system" . Using the oem charger 120v. Many complaints online say clear the code and power cycle the circuit and charger. Did both and code persists. Battery not charging affecting fuel economy and raising emissions above the stated usage average due to no battery assist. Try clearing codes no luck. OBD code P0d27 is permanent. Try using OEM level Opus access, factory tech says its a known issue, Tried clearing code no luck. This defect could cause vehicle to have no electric propulsion causing stall if gas engine died and lead to a collision. This defect should be recalled and corrected with a module or software update so generic scan tool or automatic monitor resets upon removal and replug of charging cable. Dealer tech says the IDCM is the cause. 30625 miles. This is causing higher than expected emissions, gas costs, and possible accident risk.

Filed Oct 30, 2024 · Brakes · 55,000 miles · FL

The contact owns a 2022 Chrysler Pacifica Hybrid. The contact stated while driving 70 MPH, several unknown warning lights were displayed on the instrument panel. The contact stated that the brake pedal seized and could not be depressed. Due to the failure, the contact was forced to coast the vehicle to a complete stop. The contact had the vehicle towed to a dealer where it was diagnosed with an ABS module failure. The contact stated that the ABS module was replaced under warranty. The contact stated that the failure recently returned while approaching a stop sign. The same symptoms occurred during the failure and the contact was able to make a right turn and coast the vehicle to a complete stop. The vehicle was towed back to the dealer where it was diagnosed with a brake booster failure. The contact was informed that the parts were on backorder and that the repair would be covered under warranty. The vehicle was not yet repaired. The manufacturer was notified of the failure but offered no assistance. The failure mileage was approximately 55,000.

Filed Oct 9, 2024 · Engine · NV

I bought a 2024 Chrysler Pacifica Hybrid Pinnacle [XXX]. On [XXX] I was driving. I was on a busy six lane road when the engine stopped working. The dash display showed a message to the effect of "Stop safely, vehicle engine will shut off soon" [the engine had already shut off when I saw the display]. The battery and engine lights displayed. The vehicle would not start and was towed to my dealership. They could find nothing wrong with the vehicle. They replaced the battery thinking it was dead from the desert heat sitting on the dealer lot prior to sale. The car worked until [XXX]. My daughter was driving, again, on a six lane road, when the engine died. The dash again showed the "Stop safely, vehicle...." [again the engine had already shut off when she saw the display}. The engine and battery light were again illuminated. Email notifications were sent to me showing alerts: Powertrain Malfunction, Charging system, Brakes & Suspension Antilock Brake System. I had the car towed to my dealership. Again, the dealership replaced the battery but could find no cause. The car currently works. I have owned twenty autos in my life. I have NEVER had a vehicle stop working as I am driving it. This is an extremely dangerous situation; the risk of being rear ended by another driver at a high rate of speed is great. I have seen other posts from Pacifica drivers with the same issue. Putting any driver in an unsafe situation such as this needs correction; it is even more disturbing when it is a minivan designed for families with children. My dealership is as stumped as I am. Chrysler needs to address this immediately. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 6, 2024 · Electrical, Engine · MO

After driving a few minutes gas engine died and received "Stop safely vehicle will shut off soon" on cluster as well as a turtle icon.

Filed Feb 10, 2023 · Transmission · 33,449 miles · MD

The contact was an insurance agent who was filing a complaint on behalf of her client, who leased a 2022 Chrysler Pacifica Hybrid from Enterprise Rental Car. The contact stated that while her client was driving 62 MPH, the engine seized, and the vehicle lost motive power. The client pulled over to the side of the road. The vehicle was towed to an unknown location and was not yet diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. Upon investigation, the client was made aware of the federal safety agency Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) associated with the VIN. The failure mileage was approximately 33,449.

Filed Feb 7, 2023 · Electrical, Fuel system · 9,000 miles · IL · crash

The contact owned a 2022 Chrysler Pacifica Hybrid. The contact stated that while making a left turn, the accelerator pedal was depressed however, the engine failed to increase in speed. As a result, another vehicle crashed into the front passenger side of the contact’s vehicle. No warning lights were illuminated. The air bags deployed. No injuries were sustained. No medical attention was required. A police report was filed. The vehicle was towed to a salvage yard and deemed a total loss by the insurance company. The vehicle was not diagnosed or repaired. The contact then stated that she became aware of the federal safety agency Campaign Number: 23V010000 (Electrical System, Hybrid Propulsion System) upon searching the federal safety agency website. The dealer nor the manufacturer was not notified of the failure.  The failure mileage was approximately 9,000.

Filed Sep 23, 2022 · Electrical, Engine · CA

While driving an a well paved road, I received a check hybrid system alert on my dashboard. Then several lights bean to flash including the blind spot alerts on the side view mirrors and several other alert system. Adaptive cruise control and lane change failure alerts also went off. I was only two miles from home and managed to get back. The engine did not cut out. The next morning, it started up but just a few miles into testing it out, the same alerts and light appeared, but this time the engine died along with the power steering. I coasted to roadside, turned off the car, and waited for 5 to 10 minutes. I started it up and drove it home. The engine remained on but the lights and warning continued to flash. The emergency lights also cut out periodically. I managed to drive the car to a Chrysler dealership I've visited in the past. The diagnostic alert on the Mopar app said there was a problem with the Electronic Throttle control (ETC) and the service person that looked over the diagnostic saw several system failure and alerts when he viewed the diagnostic record. At this point, the dealership has had my car for the week and the problems persist and now it won't go into gear. They still cannot determine the source of the problem. I contacted the Chrysler support line to ask them to escalate the problem. There is an open recall on this vehicle, but the parts are still not available to fix it. It only has 101,000 miles on it. I've found several complaints from Pacifica Hybrid owners related to the same ETC alert.

Filed Jun 16, 2022 · Electrical, Fuel system · 62,000 miles · GA

The contact owns a 2017 Chrysler Pacifica Hybrid. The contact stated that while turning either left or right, the steering wheel seized. The contact stated that the failure was related to the federal safety agency Campaign Number: 19V348000 (Electrical System) however, the VIN was not included. The contact then received notification of the federal safety agency Campaign Number: 22V077000 (Hybrid Propulsion System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The failure mileage was approximately 62,000. VIN tool confirms parts not available.

Filed Apr 22, 2022 · Engine, Transmission · CA

While driving 70MPH on the freeway the power to the engine failed. The dash showed a power error, telling me to plug the vehicle in. After coasting to the shoulder, the power to the car would not turn off, nor would the engine turn back on. I sat on the shoulder of the I-15 Freeway in Rancho Bernardo, CA for 45 minutes until a tow truck could come and tow the car to the dealership where it was purchased, Bob Baker Chrysler in Carlsbad, CA. The service technician, Juan Gonzalez, kept the car for about a week trying to replicate the problem, detect the issue, or learn anything about it. He could not determine the cause or the solution. However the car would start again and appeared to drive normally again. After 7 days the car was returned to me with out any repairs or any explanations or any assurance that this would not happen again. My family was placed in serious danger by being forced to sit in the car on the small shoulder a major interstate freeway without any power to the engine.