There was a fire of unknown origin within the van. The fire was self extinguished and contained to the inside of the vehicle. No one was in the vehicle at the time of the fire, and it was found about 45 minutes after leaving the vehicle parked.
2018 Chrysler Pacifica electrical complaints
Page 4 of 11: complaints 71 to 100 of 291, newest first, as owners wrote them.
Repair order date: 11/04/2024 mike perry chrylser/nacogdoches problems: shaking while idling/stop-start not working actions taken: replaced supports and mounts engine support – $105 trans mount – $274 engine mount – $155 parts - $535 labor - $600 total - $1191 repair order date: 10/14/24 - mike perry chrysler/nacogdoches problems: check engine light on/engine missing actions taken: replaced gasgets, gasget flange, camshaft, thermostat gasget - $250 gasget – $120 gasget exhaust flange - $43 camshaft intake - $572 antifreeze coolant - $53 thermostat - $122 parts - $1014 labor - $3752 total - $5129 repair order date: 10/02/24/southern chrysler lufkin issue: car wouldn't start actions taken - replaced starter and battery fuse fuse box - $202 labor - $636 total - $855 repair order date: 9/25/24 /mike perry chrysler /nacogdoches issue: check engine light on actions taken: replaced spark plugs and coils iridium ix - $15 ignition coil set - $274 labor - $300 total - $710 services from 9/25/2024 through 11/04/2024 *approximately 6 weeks total expenses $7,855
Vehicle just dies when you brake. This has now happened twice. Once in May 2024 and now Oct 2024. You have no steering and cannot be put into neutral or park. Must pull neutral cord to get pushed out of road. No codes pull up other than the neutral cord used. In May 2024 towed to dealer and they replaced starter but could not find anything else. In Oct 2024, took it to an independent car place and he could not find anything wrong, just re-boot computer. This is very dangerous; this is a handicap van modified for a wheelchair person to be put in through the back of the van. If I get hit in the back, I can't get my son out of the van. Extremely unsafe! I know the 2017 Chrysler Pacifica's were recalled for this and I believe the powertrain control module software was updated or the chip was replaced. This needs to be recalled for the 2018's also.
The contact owns a 2018 Chrysler Pacifica. The contact stated while driving approximately 40 MPH, the vehicle stalled. The contact stated that there was no warning light illuminated. The contact stated that the power steering and braking functionality were inoperable. The contact had the vehicle towed to a dealer. The dealer diagnosed the vehicle and determined that the batteries and the alternator needed to be replaced. The vehicle was repaired. The contact researched online and related the failure to the federal safety agency Campaign Number: 19V348000 (Electrical System). The manufacturer was not informed of the failure. The failure mileage was 104,417.
The vehicle has stalled several times while driving and while at a stop light leaving the van completely disabled and it will not turn on or start again. My wife and 2 year old were put at risk when the vehicle stalled on them at a major intersection and my wife was unable to put the vehicle into parking or drive since there was no power after it stalled and dashboard lights flicked on and off multiple times.. Stall has also happened at drive thru almost causing collision with vehicle in front. The stall produces dashboard error messages reporting an internal transmission malfunction, auto start/stop error, and or a problem charging the battery. Certified ASE mechanics can’t reproduce the issue or find anything to pin point the issue after multiple diagnostic tests ran and physical thorough inspection. Every time a stall happens loads of error codes (85+) pull up but none point to the root cause of stalling happening. Vehicle has most up to date software update done over a year ago.
Purchased vehicle used and have put on miles. But since day 1 issues have been arising. First the Auto stop/start function stopped, 2 years later still unable to find the fix. More recent the gear shift just doesn’t work/turn on randomly or turns off while driving which is a safety concern. Now for the past 2 months the gear shift will not work or while driving the vehicle just loses acceleration and braking and slows to a stall and I can’t do anything until the gear shift turns back. I had 3 children on [XXX] when this started putting all our lives in danger. We were stuck for 2 hours the vehicle ran but was not drivable. Every mechanic says something different and it is a luck of the draw if the vehicle will work when you try it. Batteries all tested good. No obvious other issues other than loss of power steering for a short time. All warning lights flashing on and off randomly but it coincides with the loss of driving capabilities. I just want to be done with this vehicle it’s dangerous and now I’m stuck with it. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
2018 Pacifica with multiple similar issues. August 2018 - Recall - Reprogram Powertrain Control module May 1019 - Recall fixes (Power steering and ball joint). July 2021 - start/stop light came on - took to dealership and they replaced the battery for that system. Feb 2022 - Recall customer satisfaction notification 1 Y65 July 2022 - ISSUES begin - Cylinder misfire - and car would not start and was smoking. Van was towed to dealership. The dealership had the van for 2 months and had a difficult time really diagnosing the issue. They ended up replacing the right Cylinder head - which is a major part of the engine. Just being over the 60,000 mile mark, we had to fight with Chrysler to honor the warranty on this very expensive fix. Spark plugs were also changed at that time. August 2024 - check engine light is back on, as well as the automatic start/stop button. We took to Auto zone and the diagnosis was Cylinder 6 misfire. All along we have felt there should have been a recall on this van. Is it an electrical issue that is failing? Searching online there are a lot of these complaints about Cylinder misfiring issues with this year/model. It also looks like there may have been a class action lawsuit as well. A 4 year old van should not need a major engine repair. Now here we are 2 years later with a 6 year old van and having a similar issue. We are worried it is going to be another costly fix. We have had nothing but issues with this van and it is unacceptable, especially regarding a brand new car. We have all our receipts indicating appropriate and timely oil changes and transmission flushes, etc from the dealer.
While driving on the highway, the car suddenly had a flash of start/stop system and then car stalled as soon as I moved to the exit lane. Once I stalled I had to stop car. Wait several minutes, and try to restart car. After several attempts and me blocking busy traffic, it restarted. This happened repeatedly even after technician said they cleared codes.
The contact owns a 2018 Chrysler Pacifica. The contact stated while driving approximately 70 MPH, the message that the "Vehicle Will Shut Down" was displayed and the vehicle stalled. The contact was able to call for help and had the vehicle jumpstarted. The contact stated that the vehicle failure was intermittent but became a recurring failure. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 118,000.
While driving on a 4-lane highway, I received a message on the dashboard "Vehicle will shut off soon". I had just a few seconds before power to the vehicle was limited. The engine stopped working and another message was displayed: "Battery Conditioning Leave Ignition in Run." After that the car would no longer move and I was in the middle of the right lane. Luckily I could get my children out safely. The vehicle was towed to the local Chrysler dealership where it is waiting for repair.
Frequently replacing axillary battery due to a power draw from the sliding drivers side passenger door. The door has a short in the wiring that has killed the battery and drained the main battery no less than 6 times since owning this since brand new in 2018. Vehicle had been stranded on roadways twice, gas station line once, and parking lots three times due to this short in the passenger door. Since removing the fuse for this door we have had no issues, except the sliding power door is now a manual door.
The contact owns a 2018 Chrysler Pacifica. The contact stated the Auto STOP/START light and head gasket light remained illuminated. While starting the vehicle, the vehicle was vibrating abnormally. The vehicle was taken to the dealer who diagnosed a leak in the head gasket. While inspecting the vehicle, the dealer became aware of a hole in the engine, and that the engine and head gasket needed to be replaced. The vehicle had not been repaired. The manufacturer was made aware of the failure and opened a case number. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was 92,000.
I keep getting a check engine light with my Pacifica hybrid. The scanner says P1B11, soft code is P0506, Hybrid battery or wiring harness. The codes erase after driving for a long while, however, I notice that I’m not able to maintain a full hybrid battery charge for longer than a few miles. After about 5 miles of driving, I’m a 80% of battery life left. MPG averages about 30+/- something’s not right. It’s happened twice now, both times with excessive outside temperatures. 1st time while idling, 2nd time while stopped for fueling.
On 4 separate occasions the vehicle while in motion will flash an alert that states “vehicle shutting down, stop safely” and the van will proceed to completely shut down- all electrical components do not work, including the sliding doors. After 30-45 minutes, the can will start back up without issue. Has been evaluated by a Chrysler dealership mechanic, as well as 2 private mechanics. They have been unable to replicate the issue. The main and auxillary batteries have been replaced twice each. Each incident we were able to pull over safely and there have not been any injuries or crashes, but we are concerned if it happens and we can’t pull over, we could easily crash.
In March of this year (2024), while driving down the road at 45 mph, my Pacifica's dashboard suddenly lit up and flashed all kinds of warnings including ABS off, the check engine light, the parking brake, the service electronic throttle control, electronic stability control off, collision off, warning parking brake, and other lights that I'm not sure what they mean. It seemed like every warning light in the panel lit up. The van slowed down and wouldn't let me accelerate and it felt like the power steering wasn't active. I pulled into a parking lot and shut the engine off. After restarting, the check engine light was lit, but the van let me proceed. I took it to my auto shop that said the codes were all electronic/ software related and I had to take it to a dealership. The dealership said they couldn't find anything wrong and that the codes didn't save. On June 9, the lights started flashing again while I was parked in a parking lot while I was on a road trip. I was able to capture the end of it on my camera. I again turned the engine off and on again, and the van "reset" with only the check engine light on. I was able to proceed through the rest of the weekend and the check engine light actually turned off after a day. Then on June 22, the warning lights started flashing again. My son was driving this time (along with my husband and 2 other sons). He pulled into a parking lot to return the van home, but it wouldn't go into a gear. Slowly, they toggled through the gears until it would allow them to drive the van home. He also said that it felt like he lost power steering. Losing steering, the ability to accelerate, the ability to put the vehicle in gear while driving, and losing the ABS system and the electronic stability system definitely puts my family and others at risk of an accident. I am prepared to take it to my dealer if asked. It has not been inspected by anyone else accept a local car shop and the dealership.
Back in January While driving and stopping at a red light the warning light appeared that the stop/start function was unavailable. The warning "electronic service" appeared and went away. While stopped at a red light the vehicle turned off with no other warning. This put me at serious risk with my children in the car for an accident. After a minute I was able to turn my car back on get hhome. I had my vehicle serviced and had a new main battery put in. Now in June the same warning came on again. I have to pay hundreds of dollars just to get a diagnostic report. This is the second time in less than 6 months. This is putting my safety and the safety of my family at risk.
The contact owns a 2018 Chrysler Pacifica. The contact stated while driving at an undisclosed speed, the contact noticed a failure with the START/STOP system. The contact stated that on several occasions the vehicle lost motive power and stalled with the START/STOP engine warning light illuminated. The dealer was contacted; however, the vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHSTA Hotline for assistance. The failure mileage was approximately 80,000.
Head gasket is blown with not that many miles, it's blowing fuses on a daily bases, start stop function won't work. Coolant leaks. Coils damaged, and lastly ac unit won't close properly and keeps making noise.
While driving a message came across the dash to "service charging system" and then a second message appeared that said "speeds limited" and the vehicle slowed to 44mph entirely out of my control.
There is a loud clicking and popping noise from the front drivers side suspension when turning or going over bumpy ground. The car also pulls to one side unexpectedly when going around corners Sometimes while driving the car will shut down and restart as if rebooting a computer.
My Vehicle suddenly stops while the car is in motion, it shuts completely off. I had an instance where my car shut off coming off the freeway off-ramp. This has happened on numerous occasions and we have been trying to call the dealership to see if there is any recall. We are never given a straight answer and we feel unsafe to drive our vehicle
The van auto shutoff during a stop in an intersection. The van did not turn back on when the pressure was released from the pedal. The engine was off and I was in the middle of the intersection. The gear shifter knob was unable to move to a different gear. After multiple attempts to restart the car were unsuccessful, the car finally restarted after cycling through the att, run, start menus without the brake being depressed and then pressing the break and pushing the start button. This vehicle has had the recall work performed related to this issue and the repair is insufficient. The stall is intermittent and difficult to repeat.
The vehicle display reads "Service Charging System" and switches into limp mode where the vehicle is prevented from driving faster than 15 mph. After leaving the van sit for a time, it drives ok. I took the van to a Chrysler dealership twice after this happened, and the dealership could not resolve the issue. After the second time this happened, the dealership contacted an engineer at Chrysler to try and resolve the problem, but they could not. Chrysler says the problem stems from the charger that is being used, but the error/limp mode occurs not after using a charger. I am concerned that the vehicle will switch over to limp mode at any time presenting a safety risk.
The #5 cylinder keeps having a misfire sometimes causing failure of the vehicle to get up and move when needed in an emergency Situation this being a family van make even putting children in danger at times. After inspection by myself a Mechanic that even taught College Automotive repair, I have also taught Jet engine repair I find this concerning. Is what is happening is the head gasket is leaking coolant into the #5 Cylinder and we all know water will not admit a spark. Rust can be seen on the Valves and top of Piston cylinder upon inspection. This is a well know issue across the United States and Chrysler Dealers and manufacturers, their mechanics, parts and service departments also know this. This is poor workmanship inferior parts. But the most concerning is not being able to get a response out of the vehicle to get out of the way in an emergency situation and that the owners of Chrysler Corporation do not care. With the cost the consumers paid for these Vehicles it should not have to fall on them due to the inferior parts and workmanship of the manufacturing Company. The Average Consumer cannot afford to fix this issue, and some are still paying for their Pacifica's Immediate action should be taken with this problem as many Babies, Children and adult lives are being put at risk. I would recommend to stop driving these vehicles immediately until the problem is resolved. Accident waiting to happen possibly causing bodily harm.
The check engine light came on and the vehicle experienced a slight loss of power. Later the Start/Stop indicator light cam on with a message saying it has malfunctioned. Upon driving the van continues to have issues going up hills and accelerating from a stopped position. The check engine light remains steady without blinking.
Initial Symptoms: Auto-start/stop failed/tripped, plus excessive white exhaust smoke continuously exits (will not stop). Stopped driving vehicle ~26Nov2023. Problem 1: P0303 Solution 1: Ignition coil and spark plug replacements @ $905.17 (15Dec2023) Not Fixed: Error code is gone but white smoke persists. Problem 2: Chrysler tech found low coolant, traced to EGR cooler. Solution 2: Replaced EGR cooler @ $1,319.00 (05Jan2024) Not Fixed: Excessive white smoke still exits tailpipe and does not stop. Neither solution fixed the root cause. There is also an engine smoke smell in the cabin (we don't smoke). Potential Root Cause: Failed head gasket forcing coolant into the engine then burning out as white exhaust.
oticed that the CEL had come on, and after reading the codes, I found out that there was a cylinder 5 misfire. To fix the issue, I decided to replace all the spark plugs and ignition coils, and after putting everything back together, I erased the codes. However, the following day, the same code appeared again, and I realized that the coolant level in the reservoir was low. I performed a pressure test on the system and ran it to temperature, but there were no coolant leaks. While the car was running, I observed bubbles in the reservoir, and these signs pointed towards a blown head gasket. After checking online for Pacifica common issues, I found out that head gasket failure is one of the main complaints. As a mechanic with 13 years of experience, I know that these symptoms indicate a blown head gasket. Unfortunately, due to this issue, I had to leave work twice as my wife and four kids were stranded 30 minutes away from the house. This is not acceptable, and I've never had a vehicle blow a head gasket before.
After radiator was replaced by the dealership, our car has been experiencing coolant leaks that we have “repaired” twice, however the issue keeps coming back within the week. We are also experiencing stalled engine will driving, where the car just slows down instantly or stops.
The contact owns a 2018 Chrysler Pacifica. The contact stated that the main battery and the auxiliary battery had been replaced on multiple occasions. The dealer had not yet determined the cause of the failure. The contact stated that the frequent battery failures caused the vehicle to stall while driving at various speeds with the battery and check engine warning lights illuminated. In addition, the contact stated that the vehicle was diagnosed with a cylinder #3 misfire. Also, the contact mentioned that the vehicle would jerk forward upon depression of the accelerator pedal without warning. The vehicle was taken to the dealer for a diagnostic test; however, the dealer was unable to determine the cause of the failure. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 46,000.
Suddenly our Pacifica would not start and started cycling through over a dozen error messages. We were finally able to get the vehicle to start and took it to the dealership. They confirmed that the star connector needs to be replaced. After looking at many forums, this appears to be a fairly common issue among the early hybrid pacificas, to the point that I felt I should report here, especially given the recalls that have already happened due to the electrical system in the car. We just got the last recall done in August and already we now have a ~$1000 bill to repair the electrical system again. Please have someone look into how many of the pacificas need this particular connector replaced given the prevelance of people with the same issue online.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Chrysler Pacifica?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history