2022 Chrysler Pacifica fuel system problems

Filed Oct 28, 2026 · Electrical, Fuel system · WA

The vehicle experienced a concurrent failure of the high-voltage traction battery pack and the High-Voltage Battery Coolant Heater (Diagnostic Trouble Code P0E15). The electric battery coolant heater is a critical component of the high-voltage battery thermal management loop and vehicle cabin heating/defrosting system. When this heater fails, the high-voltage battery cannot regulate cell temperatures in colder ambient conditions, which disables electric propulsion mode, triggers powertrain limp-mode/reduced propulsion warnings, and leaves the vehicle unable to clear or defrost the windshield in freezing temperatures. A sudden loss of propulsion power in traffic or loss of windshield visibility during cold weather presents severe safety hazards. The manufacturer approved the traction battery pack under warranty but denied statutory coverage for the concurrently failed high-voltage coolant heater, leaving the vehicle disassembled and inoperable.

Filed Aug 23, 2026 · Fuel system · MN

Chrysler issued this safety recall 52D at the end of June and still no remedy is being reported as available from Chrysler. This is abysmal customer performance and and unacceptable turnaround time for what amounts to a serious safety risk. Chrysler has not and continues not to provide an estimated timelines for resolution. I am renting a vehicle in the meantime given the safety risk (both while driving and while parked), paying for the rental cost out of pocket and taking a risk that Chrysler will reimburse. In short, the manufacturer has failed or is unable to remedy this safety recall for this vehicle in a timely manner.

Filed Jul 20, 2026 · Engine, Fuel system · CO

On July 19, 2026, I was driving my 2022 Chrysler Pacifica Hybrid on E-470 at approximately 75 mph. Without warning, the dashboard displayed "Stop Safely. Vehicle Will Shut Off Soon," and the amber check engine light illuminated. At the same time, the vehicle immediately lost all motor power, began slowing, and did not respond to accelerator input. There were six occupants in the vehicle, including four young children. I was traveling on a busy six-lane highway with little to no shoulder. I had to maneuver across traffic without motor power to reach the side of the road, placing all six occupants at immediate risk. After turning the vehicle off for about five minutes, I restarted it. Only the check engine light remained illuminated, and the vehicle appeared to have normal power. We continued driving at 55–65 mph to reach a safer location. About 10 minutes later, the same warning appeared and the vehicle again lost all motor power. This time we were on a steep, busy exit ramp and had to immediately pull off as the vehicle rapidly lost speed, again placing all six occupants at risk. After waiting about five minutes, we restarted the vehicle, drove it to a safe location, and had it towed to a dealership. The dealership was closed, so the cause of the failure has not yet been determined. This incident created an extremely dangerous situation, and we narrowly avoided a collision on the interstate. A sudden loss of propulsion at highway speeds without warning is a serious safety hazard that warrants investigation and consideration for a recall.

Filed Jul 4, 2026 · Electrical, Fuel system · CA

I am reporting an ongoing, catastrophic safety defect and corporate suppression regarding Chrysler Recall 03A (the federal safety agency Campaign 23V010) on my 2022 Chrysler Pacifica Hybrid. The official recall remedy has repeatedly failed to prevent total electrical system depletion and unexpected motive power shutdown in the field, leaving my family in extreme danger. On March 3, 2023, at 6,000 miles, the vehicle suffered a complete, un-warned motive power shutdown while I was driving my two young children on a rural highway. The vehicle stalled dead on an incline in the middle of a lane. The brakes failed to engage automatically, so I couldn’t evacuate my children because I had to keep my foot on the brake. Cars had to swerve around our vehicle at 55 MPH, as it was on a blind corner. My children were deeply traumatized; my autistic child was completely inconsolable and now suffers from an ongoing, severe psychological fear surrounding this vehicle stopping unexpectedly. We were only saved from a crash because a passerby stopped to help after about 15 minutes. The dealership subsequently applied the Recall 03A software update and replaced the 12V battery. This recall remedy has utterly failed. The replacement 12V battery died again in May 2025 and died a third time in June 2026, proving a chronic electrical defect exists. The dealership refused to perform parasitic draw testing, refused diagnostics, and simply charged the battery, stating 'it's fine.' Chrysler corporate support subjected me to a cycle of unresponsive case managers. One manager promised a buyback review within 3 days, but instead, a subsequent manager closed my file. Corporate explicitly refused to escalate the vehicle to their STAR technical team and flatly refused to provide copies of my warranty and service records. I explained to both corporate and the dealership that I don’t feel safe driving this car without further diagnostics but corporate refused to authorize, stating they stood by the dealer.

Filed Jun 24, 2026 · Electrical, Fuel system · MI

Upon attempting to charge the vehicle with factory supplied Level 1 charger, a dashboard message appeared stating "Service Charging System" and the vehicle would not charge. Took the vehicle to a service station and scanned the vehicle. Listed error code is p0d27-00. The code could not be cleared and the vehicle was unable to be charged. Vehicle had to be taken to a Chrysler dealer for the code to be cleared in order to charging capability to be restored. This was considered a "software" issue and not covered under the vehicles warranty - despite it directly affecting the fuel/hybrid propulsion system. This defect and inability to clear the code means the vehicle cannot be charged, reducing its range and fuel economy, and increasing emissions. This is a critical issue and should not incur customer expense to have the code cleared.

Filed May 26, 2026 · Brakes, Driver assistance · FL

1. Most emergency lights come on while the vehicle's brake engages automatically. The brake then pumps up and down on its own if any pressure is applied. Shortly after, the vehicle goes into "limp mode". The vehicle is currently at a Chrysler Dealership service department and available for inspection. 2. This has occurred 8 times since the vehicle was purchased in October 2024. All but one time, it has happened while driving. Once it happened while on a major highway. I had to quickly veer into a turn lane so our vehicle was not rearended by another car. Another time, I was driving my children to school and it happened about 10 seconds before crossing the worst intersection in our city. That could have resulted in a major crash based on the history of that intersection. A third time, I was traveling at about 40 miles an hour when warnings came on and the brake started to engage. Luckily, I had just gotten off a major highway and I was able to get to the side of the road. 3. The problem has been confirmed by a dealer, since it happened while I was in their service parking lot. However, they have been unable to recreate, find the source of, or fix the issue after 7 times of servicing it. 4. I am unsure whether the manufacturer has sent anyone outside of the dealer's service department to inspect the vehicle. We have been in contact with the manufacturer directly since December 26, 2025 in relation to this issue. Our extended warranty company may have had an inspector out on the first visit to the dealership for the issue, but no one since that I am aware of. 5. Emergency messages have included: Service Electronic Stability Control, Service Charging System, Service Hybrid Electronic Vehicle System, Auto Emergency Braking Unavailable Service Required. Multiple emergency lights come on including: Check Engine, Electronic Throttle Control, Electronic Stability Control Active, Service Forward Collision Warning. The first incident was January 22, 2025.

Filed May 17, 2026 · Electrical, Fuel system · OH

My 2022 Chrysler Pacifica PHEV has experienced three separate complete losses of motive power at highway speed, each preceded only by a brief dashboard warning to pull over safely. First occurrence: April 18, 2026. Second: May 7, 2026 — vehicle towed to Spitzer Motor City (Cleveland, OH), an authorized Stellantis dealer. Dealer replaced the Power Inverter Module hardware under warranty (R.O. 42463CY). Third occurrence: May 17, 2026 — just five days after the repair. Notably, the battery was at 40% on the third occurrence, meaning the engine had not cycled on, distinguishing this failure from the prior two. The root cause is the internal transmission wiring harness connector short identified in the federal safety agency Recall 03A (23V‑010). Per the federal safety agency's own ODI investigation (RQ24-004), the software recall remedy does not prevent loss of motive power. TSB 21-008-23 / Warranty Extension XE1 identifies full transmission replacement as the correct fix. The dealer did not perform a transmission replacement. The safety risk is severe — complete, sudden loss of drive power at interstate speeds with minimal warning creates immediate rear-end collision risk. The defect has been confirmed by the authorized dealer. The transmission assembly is available for inspection. No police or insurance involvement. This VIN currently shows zero open recalls, suggesting the incomplete repair was logged as satisfying Recall 03A.

Filed Apr 21, 2026 · Electrical, Fuel system · CA

I was traveling on the freeway at approximately 65 miles per hour. I slowed to approximately 50 miles per hour to pass a disabled vehicle and began accelerating again when the dash displayed a message that said "Stop Safely- Vehicle will Shut off soon" the check engine light, a red turtle light also lit up. I had to make a quick maneuver to the far right lane putting myself and other vehicles at risk to avoid the car shutting down in the middle of the freeway. I wanted to get closer to an exit so I continued driving slowly on the shoulder. The wouldn’t accelerate, so whatever speed I let it get down to was the fastest it would go. At the exit I was concerned I wouldn’t have enough power to make it up the hill so I shut off the car. I let it sit for a couple of minutes and then turned it back on. It turned on with the check engine light still on . I then drove it straight to the dealership using surface streets and keeping my speed around 40-45 miles per hour. This was the second time this vehicle has experience this kind of loss of power. The first time happened in July 2024 and resulted in a full transmission replacement. This incident constitutes a dangerous loss of motive power at highway speeds. The failure mode appears identical to the issues described in the federal safety agency Safety Recall 23V‑010 (Chrysler Recall 03A), yet this vehicle has already had a full transmission replacement for this exact issue in the past.

Filed Jan 11, 2026 · Electrical, Engine · OK

While driving 75MPH, the vehicle shut down with a message to pull over. All acceleration was lost. We had to navigate, without warning, across 3 lanes of traffic to pull over on the right side of the highway. This was EXTREMELY unsafe as we were slowing down and essentially cutting off other vehicles who were honking at us as this was a traffic hazard. All 6 members of my family were in the vehicle. We had this happen another 3 times before arriving home. I took it to my local dealer, who could not replicate it. They performed a software update, which I have since learned would NEVER fix this problem. We had it happen to us 5 more times, so I took it to another dealership, who initially could not replicate it. In all cases, we had the following check engine light codes be triggered. I have screen shots of them from my personal OBDII reader: P0A43 "Drive Motor 'A' Position Sensor Circuit Intermittent", C2225 "Status: MIL - PCM Disabled EDU: No Sub Type Information". After doing my own reading, it seemed many others have experienced the exact same symptoms and it has required a transmission repair/replace. I also learned most people had a battery charge on the high voltage battery (as this is a plug-in hybrid) when the vehicle shuts down. I charged my van, took it for a ride at 75MPH and it occurred within the first mile. I took it back to the dealership, and at this point, I refuse to drive it until the hardware fix happens. It seems like this should be a recall for all vehicles that can have this problem. It is EXTREMELY unsafe as it occurs at 70MPH+ speeds.

Filed Nov 26, 2025 · Fuel system · WI

Fuel line leak near engine. It sounds very similiar to the 2023 Chrysler Pacifica Recall. The vehicle reaked of gasoline fumes coming in through the vents. Our mechanic replaced the fuel line, said it had a hole. We felt very unsafe even starting the car when it reaked of gas due to risk of fire. No warnings lights or anything, just the smell to tip us off. No one else has inspected the car since we didn't have anything catastrophic happen.