Chrysler Pacifica fuel leak problems

Filed Oct 2, 2026 · Fuel system · IA

The contact’s daughter owns a 2021 Chrysler Pacifica. The contact stated that while operating the vehicle, there was a strong fuel odor inside the vehicle. The contact’s husband inspected under the hood and became aware that there was a pin-sized hole in the fuel line and that there was fuel leaking inside the engine compartment. The contact stated that the fuel supply line was touching the engine and the vibration from the engine had caused the pinhole in the fuel supply line. The fuel supply line was replaced by the husband, and the vehicle was repaired.

Filed Oct 30, 2025 · Brakes, Fuel system · DE

The rear brake at 4MM at 32K miles at the time of OIL change at dealer and front BRAKE still have 7MM, as a mechanical engineer, I know this should not happen. also while driving, there is high freq metal sound, I have notified the dealer every time I went to oil change, they confirmed it is fine but I do not feel safe. 2nd issue is the powertrain system feels no power while climbing hills and the car almost stops and sliding back even I put on gas pedal and almost hit the car behind me one time. 3rd issue is that gas door seal is broken within first year of use, it could cause gas leaking.

Filed Oct 21, 2025 · Fuel system · WA

High pressure fuel leak with large fan spray pattern in fuel line part number 68492134AA where it sits and rubs against a sharp corner of another component, (appears to be ignition coil) above the rear passenger side of the engine. Searched online and found another owner had posted an image of the exact same leak! https://www.reddit.com/r/ChryslerPacifica/comments/1amcdp9/2021_pacifica_hybrid_fuel_leak/Their photo and mine are identical and in comments on their thread, Two other owners that responded to that thread also said they've also had exactly the same leak. The cause appears to be how this line is routed by the factory. it is resting against the coil and not secured in a way to prevent chafing. Result is extremely dangerous with fuel spraying down towards the exhaust. The part is available for inspection. Safety of my family was put at risk by fuel spraying towards hot exhaust while my wife was driving. She was unaware of problem until fuel smell just prior to arriving at home. Problem is easily reproduced. I spoke with Olympia Chrysler Jeep and the service advisor Corey, said he had seen this issue before as well. He also said because car is not under warranty and I don't have roadside assistance, towing would be at my expense. I have ordered replacement part and will install and secure it to prevent chafing. I will keep part to be availalbe for examination. There were no warning lamps, messages or other symptoms prior to the fuel smell.

Filed Feb 12, 2025 · Fuel system · AL

While driving my children home from an evening activity, there was a strong odor of gas inside the cabin. I had the vehicle towed to the dealership the next morning for diagnostics and repairs. The dealership 's technician was able to reproduce the issue and upon further inspection discovered a small leak in the fuel line. It was determined that the fuel line had been rubbing against the coil pack, which created a small hole. The fuel was leaking onto the coil pack. This puts both the driver and the passengers at risk because the coil pack is in close proximity to the spark plugs. When there is a spark and gasoline, fires and/or explosions tend to be the result. The technician stated that there had been no tampering with the components and that the gap between the fuel line and the coil pack is very small. I believe that the gap is too small because normal operation of a vehicle should never cause a hole to be rubbed into a fuel line due to it's proximity to the coil pack. Prior to the smell of fuel, there were no other warnings. I have included pictures of the faulty part.

Filed Sep 16, 2024 · Fuel system · TX

Van had a smell of gasoline inside the cabin and out. Upon inspection, the fuel line going from the hard line to the nylon line in the engine bay was leaking. The nylon line between the fuel pressure sensor and the hard line had rubbed against a coil pack and was leaking fuel. Any fuel leak, especially in the engine bay, poses a safety risk as it can combust and cause a fire inside the engine bay. Other owners have posted about this exact problem on forums, hence why I knew where to look for the issue. I have ordered the new fuel line through the dealership, however, if the fuel line has the same bend in it as the original, the same thing will happen in the future.

Filed Jul 10, 2024 · Fuel system · NE

Van has 70K miles. After a long road trip. last stop noticed a gas smell from the front of van. When opening the hood noticed gas had been leaking over top of the motor by spraying fuel. Moving the fuel line running over the top of the motor, showed it was rubbing against top of the coil pack on engine. The rubbing over time caused a small cut in the fuel line allowing for fuel leak. The fuel line seam to be malformed or is unsported causing the rubbing.

Filed Apr 27, 2023 · Electrical, Engine · VA

Car was serviced for a gas leak at a Chrysler Dealership the previous day. The next morning, I was driving at a low speed (<20 mph) when an error message appeared "Car must be in P (park) to place in drive." I switched to P and tried to restart the engine. It turned over several times but never restarted. A police officer had to manually disengage the transmission and emergency brake to put the car in neutral and roll it to a turn lane (rather than in heavy traffic). The car was towed to a dealership and is still being diagnosed. We had no driving issues prior to the car stalling this morning, even with the previous gas leak mentioned above.

Filed Mar 22, 2023 · Fuel system · NE

The fuel line into the fuel tank and tank itself were leaking gas. It was not a large leak but it was enough to soak the felt lining underneath the gas tank. It made our garage completely smell of gas fumes and the fumes began to migrate into the home. The dealer originally took a look at it on 3/13/23 and determined that the fill line was just loose into the tank. However when we filled the tank with gas again on 3/20/23 the problem began again. It went back into the dealer on 3/21/23 and they are replacing the fuel tank and the fuel fill line. No warning lights or messages ever came on.

Filed Sep 20, 2020 · Fuel system · OH · fire

Fuel pressure sensor bad, fuel leaking, fires

Filed Sep 5, 2020 · Engine, Fuel system · 65,000 miles · NC

Its throwing a PCM code an the car is stalling so bad in the moddle of driving I have been stuck severeal times an I thunk there is a fuel leak I smeell gas so bed its throing po300 code an wont chanfe even when I got all the parts I see there is a recall on my year of car can somwonw hwlp mw I cant keeo cutting off ill wreck