Chrysler Pacifica fuel pump problems

Filed Apr 14, 2026 · Fuel system · MD

2024 Pacifica Van with 66,000 miles started to run rough then quit in a McDonalds parking lot in Richmond VA 70 miles from our home residence. I had the car towed to a local Chrysler dealership on Saturday night before Easter. The tow truck drive was kind enough to take myself, spouse, daughter and Golden Retriever to the Richmond airport where we rented a car and drove home to Leonardtown, MD. The Chrysler dealership troubleshoot the vehicle and ordered a fuel pump.

Filed Feb 9, 2026 · Engine, Fuel system · WI

As I was leaving the gas station the Check engine light flashed on and off then the car was like turning on and off fast and a loud clunk sound and the Fuel pump module exploded gas sprayed all over the gas station. Huge fire hazard and the car began to smoke Vehicle experienced a sudden catastrophic fuel system failure involving fire risk and loss of propulsion. The incident occurred without warning and created a serious safety hazard to occupants and surrounding traffic. This vehicle is a Chrysler Pacifica Hybrid. Similar failures involving fuel system and hybrid control logic have been widely reported. The manufacturer was contacted but declined to properly document the safety incident. This failure is not consistent with normal wear and tear and represents a potential safety defect. Key details to include when submitting online: - Sudden loss of propulsion - Fire risk / fuel involvement - Hybrid system interaction - Manufacturer declined to document incident

Filed Feb 6, 2026 · Fuel system · TX

In at least 3 different drivers experienced the engine shutting off while driving at low speeds. It happened either while stopped at the traffic light, or shortly after being stopped at the traffic. The engine stalled and the message on the dash said to stop the vehicle, turn it off, then turn it back on. Fortunately, we were able to coast to a stop and follow the procedures. We replaced the fuel module and fuel pump, which did not help. I did some research last night and found an article from CBS News dated 01/12/2018 for this issue that recalled some of the Pacifica minivans starting with the 2017 model. Our van is a 2018 Chrysler Pacifica. I suspect it was built AFTER the recall, but the software was not fixed when built. I want this fixed under the recall umbrella so I don't get charged for something Chrysler already new was a safety problem.

Filed Dec 28, 2025 · Electrical, Fuel system · GA

We bought this vehicle from a local dealer in March (9months ago) in the time we’ve had it… it’s been in the shop for about 6 of them. 1- About 3 weeks after the purchase it shut off while I was driving on the highway. We then took it to the dealership in Jasper, Ga bc the error code said the pcm needed to be reset. They couldn’t get it to reset so they embarked on a diagnostic that took 3 months to discover the fuel pump was “too small”. The dealership repair guy assured us this was a solve to the issue, they’re tech put 200 miles on it an had no issues. 2- The day we got it back the check engine light came on and while going around a curve to the right, the wheel locked up on me and almost drove me into a mailbox. We turned around and went right back to the dealership. They had it for another couple weeks and told us we needed a new rack and pinion. We couldn’t afford the $6000 they wanted to fix that. So we then called the guy we bought it from and he had a local repair shop take a look and they replaced some parts on the rack and said it was good to go. 3- got it back and the check engine came on again, they code said pcm needed to be reset. We couldn’t get the dealership to call us back so we went to the local shop o’reileys recommended and they deducted some gauges needed to be replaced. 4- within a couple weeks the van was sputtering and cutting off again, we took it back to the local shop and the only thing they could think to do was change the auxiliary battery. 5- we’ve had it for about 2 weeks… 2 days again I went to start it up and it cut off. I had to wait a few minutes to try again and it started. Then yesterday while driving we stopped a red light and something popped and the dash lit up with errors and a grinding noise started. We went to accelerate to turn and started rolling backwards while in drive. We slammed on the brakes, turned the cautions on and put it in park and still rolled backwards. We had to get a tow back to the local shop.

Filed Mar 4, 2025 · Electrical, Engine · PA

2020 Pacifica keeps stalling. From a stop light or stop sign the vehicle will lurch forward without warning. Recently, from a strip mall I stopped before pulling out into traffic and the vehicle lunged forward peeling rubber and shot onto the main road and I had to slam on the brakes to get the vehicle under control. At the next stop light, it stalled and I couldn't get it started. I'm handicapped and I had to exit the vehicle with my canes and advised the driver behind me of the problem. I've made 5 trips to the dealer with this problem. The dealer replaced a crankshaft postion on one trip and the fuel pump on another visit. If you leave the vehicle set for about an hour everything goes back to normal until the next time it stall, which is the next time I use the vehicle. More recently I picked up my vehicle from the dealer on February 14th, put 24 miles on it. I didn't use the vehicle on [XXX]. I then drove six miles on [XXX] for a total of 30 miles and it stalled again. The dealer South Hills Chrysler Jeep keeps telling me they can't duplicate what I'm telling them are the problems with the vehicle. I don't know if it is a transmission or what. I called Chrysler customer service and spoke with a man named Sahil. I explained the issues with the vehicle and he contacted the dealer and parroted what the dealer said to me, they can't duplicate what I am saying is wrong with the vehicle. This was on February 28th. My van has been setting at the dealer since February 18th and I haven't boo from the dealer since. Sahil is to call me tomorrow the 5th of March , but I don't expect any information from him that will resolve the issue. I am [XXX] and [XXX], I need this van for hauling [XXX} for doctor's appointments and other issues that surface. This problem of stalling started back on the middle of November, 2024, again the middle of December, 2024 and again the middle of January, 2025. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 3, 2025 · Electrical, Engine · NV

Unknown, engine light came on flashing while driving. Car has been repaired by the dealership a few weeks ago and replaced the fuel pump.

Filed Aug 31, 2023 · Electrical, Engine · OH

Our engine has stalled while driving the vehicle at least four times since July 1. The engine begins to shudder, and the car will not accelerate, and then the engine completely dies. After it happened today, it was not possible to restart the engine or put it in gear. My and my family's safety was put at risk because the vehicle was inoperable. Three times this happened on major interstates with traffic moving at high speeds. I had to move my children and their car seats into another vehicle while traffic passed. We have had the vehicle in for service at least three times, at least twice at Chrysler dealers. The problem has not been reproduced (yet) but this latest time it completely disabled the vehicle so expect they will see more of the problem now. After the engine cuts out, we get an electrical warning light that flashes briefly, plus a check engine light, and a message that instructs to move the gear shift to P to start the vehicle and another that warns that the Start/Stop system needs service. We have had these all serviced, the fuel pump and battery replaced, and have been told the problem is resolved and yet it keeps happening.

Filed Jul 17, 2023 · Fuel system · 53,000 miles · KY

The contact owns a 2017 Chrysler Pacifica. The contact stated while driving 25 MPH, the vehicle lost motive power. The contact was able to veer to the side of the road. The check engine warning light was illuminated. The contact was able to restart the vehicle and continued driving. The contact stated that the failure recurred on two occasions. The contact stated that on the third occasion, a message to park and to restart the vehicle was displayed; however, the vehicle failed to restart at first attempt. The contact was able to restart the vehicle after several attempts. The vehicle was taken to an independent mechanic, where it was diagnosed that the failure was related to the fuel pump. The vehicle was not repaired. An unknown dealer was notified of the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 53,000.

Filed Feb 9, 2023 · Electrical, Engine · NC

The end of 2021, Began not starting requiring many pushed of the start stop button; stalling when in motion on roads; gas pedal tight not depressing, engine light on and off, side auto doors often wouldn’t work automatically (battery new); was lurching and chugging randomly , over time very frequently. Nov 22’ had start stop battery replaced & fuel pump sensor. still lurched etc..worsened..late 2022 began frequently stalling , not starting, pedal would be stiff, lurched daily, stalled frequently during motion & upon first acceleration..start, try to go..stall out..finally jan 5, 2023, wouldn’t even turn over-just clicked-shop diagnosis said few codes referred to electrical panel issues.. replaced spark plugs, starter, got home, next morning, same thing ~no turnover. problem not solved. another shop, where it sits today-found cracked engine block($12,000 estimate to “attempt” replacing engine). deemed total loss as value of van is less. This has to be a defect gone undetected for some time, having built up damage over these last couple years.Many of issues are identical to recall (2019-2022) listed problems. Regardless of any recall being labeled as inactive, this vehicle is clearly a result of manufacturing issues. A 2018 doesn’t just have these problems when it’s cared for.We have four children & currently have no mode of transportation~two shops since January 6, ‘23, prior year of worsening symptoms. A safe, reliable vehicle is vital for our family’s functioning. It’s now at Lee’s Auto-seen in picture. Excel Auto was first repair attempt Jan.6. We will not be reimbursed by insurance for “mechanical failure.” Our loan is $18,000 outstanding. We pay $459.65 each month, and are responsible for remaining balance. Why should this happen to us. We certainly can’t purchase a second vehicle in conjunction with this loan. Your quick action and assistance is appreciated and direly needed.

Filed Apr 21, 2021 · Engine, Fuel system · 13,500 miles · KS

This vehicle is a handicap conversion van modified by revability / vmi in the modification - revability has replaced the factory fuel tank with one of their own design and construction. In doing so - they use the chrysler factory components such as the fuel pump, fuel gauge sender unit, emissions connections, etc. However - the fuel gauge has never worked properly since I purchased the van and it gives misleading information about the fuel level. It registers only 3/4 full on the dash when in fact the tank is full. If you try to add any more fuel (as I found out when I first purchased the van) - it affects the emissions controls severely and makes the van un-drivable; in fact the engine will stall unexpectedly in traffic which is a severe hazard. Further - the low tank level is unpredictable so you are never sure when to refill, if the fuel gets too low then the engine can also stop in traffic. The company is well aware of this problem but cannot fix it. I have had it to the original selling dealership (jay hatfield mobility in lee's summit missouri) several times as revability said the repairs were covered under their manufactures warranty. The dealership has been unable to fix the problem and has since not renewed their contract with revability. So the problem still exists and the powertrain 'check engine' light comes on periodically - which jay hatfield mobility said they had nothing to do with and would not do any further repairs. My wife is handicapped and in daily rehab treatment - so I need this van every day and need it fixed properly - however the van conversion manufacturer has no instructions or information that they can supply for a correct repair. I believe that revability / vmi should be responsible for fixing this problem properly or replacing this van as it is / can be a safety hazard to operate without a properly functioning fuel gauge.