2011 Coachmen Freedom Express problems

Filed Jul 10, 2017 · Tires · MI

Tl* the contact owns a 2012 (na) coachmen freedom express equipped with lionshead trail express tires, size: 225/75r15. While the vehicle was stationary, the contact noticed that the rear passenger tire experienced a blowout. The contact replaced the tire with a spare. After 100 miles, the rear driver side tire experienced a blowout. The vehicle was taken to walmart where the tires were replaced. The dealer and manufacturer were not notified. The dot number, VIN, and vehicle failure mileage were unknown. The tire failure mileage was approximately 41,000.

Filed Jul 10, 2015 · Suspension · 7,000 miles · PA

Tl* the contact owns a 2011 coachmen freedom express. While the vehicle was parked, the contact discovered that the trailer's outriggers were bulging and fractured the frame. The trailer was taken to an independent mechanic who diagnosed that the front and rear axles fractured and needed to be repaired. The trailer was repaired; however, the trailer recently failed a state inspection due to fractures in the middle of the two axles. The trailer was not taken to the dealer or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 7,000.

Filed Aug 17, 2013 · Suspension, Wheels · TX · fire

Returning from vacation in knoxville, iowa we were traveling west on the turner turnpike between tulsa and oklahoma city. The travel trailer had made a sudden move to change lanes, I immediately slowed down and looked in my left mirror to notice a fire, sparks and smoke coming from the left side of the travel trailer. I stopped and extinguished a fire in the left rear wheel bearing and hub. I called a heavy duty wrecker service to assist in moving the truck and trailer from danger of the turnpike. We spent the night in the parking lot of flying j truck stop. The next morning I was able to call a repair shop to have the travel trailer axles and bearings repaired. Currently the trailer is in oklahoma city having the damages assessed. This is the second incident we have had on the same axle within 6 months.

Filed Aug 17, 2013 · Body, Wheels · TX · fire

Traveling east on 146n just on the downhill side of the fred hartman bridge a good samaritan hailed our attention that the right rear wheel was on fire of our travel trailer. We pulled over out of danger to an entrance to a pubic boat ramp. There was a centerpointe energy personal that helped extinguish the fire to the axle. The tire and wheel had removed itself from the spindle and rolled into the ditch. Calling on an emergency road repair service to repair the trailer bearing, it was noticed that there was no bearing race installed in the wheel hub on the inboard side. The emergency road repair technician replaced the bearings races and repacked the bearings to specifications to have us return home for the evening. We then took the travel trailer to a repair shop to have it properly repaired and the other wheel bearings inspected.

Filed Oct 12, 2011 · Suspension · 3,000 miles · NY

Traveling down highway pulling camper. Stopped in rest area and observed that rear axle had bent and right side tire was at approx 20-25degree angle. After that had been repaired. 2 days later the leaf spring on right side in front of front axle snapped. The vehicle was less than 1 year old. The axle manufacturer eventually sent heavier duty axles to warranty them, refused to cover damage caused by their bent and defective axle. When the manufacturer of the camper was contacted, it was referred back to the axle manufacturer and doing nothing for the cracked spring, which was repaired at my expense, even though the vehicle was still covered under the original warranty.