1996 Dodge Caravan suspension problems

Filed Jul 4, 2011 · Suspension · MN

Strut tower corrosion 10090457 right / left strut tower rusted out on 96 dodge caravan. Took van into repair shop to find out steering issue they found a completely rusted out strut housing said its a known issue with vehicle and safety bulletin was issued since its a known problem. Suspension/body - strut tower corrosion number: 23-044-02 group: body date: oct. 14, 2002 subject: ns strut tower corrosion .

Filed Sep 29, 2008 · Suspension · 90,000 miles · IL

Tl*the contact owns a 1996 dodge caravan. The contact stated that the shocks underneath the driver's side of the vehicle were going straight through the metal, which holds the wheel in place. The failure causes the vehicle to hesitate at times. While driving over small bumps in the road at 15 MPH, the vehicle suddenly veered to the opposite side of the road. The contact has taken the vehicle to the dealer a few times, but they stated that there was only a kit used to seal the shocks in place; however, it is a temporary remedy and the failure would most likely recur. There is currently not a permanent repair for this defect. The failure mileage was 90,000 and current mileage was 115,000.

Filed Aug 23, 2007 · Suspension · 50,000 miles · WI · 10 injuries

Front strut mounts on every 96 thru 00 caravan, voyager, chrysler minivans that I've looked at,have serious rust problems, especially the left side, resulting in the strut itself breaking through and hitting the bottom of the hood, and resulting of loss of control of the vehicle when this happens. The repair cost to have this repaired is very costly,$300-1000 to make the vehicle safe to drive. I would like to see the federal safety agency look into this problem on all 96 thru 00 mini-vans before somebody has a failure while driving with their family, and have a fatal accident. Please cure this problem before and not after people are killed due to this structural front strut tower failure.

Filed Jun 29, 2006 · Suspension · 134,000 miles · MI

I own an 1996 dodge grand caravan. The strut towers, especially the driver side, are rusting horribly and will need repair to avoid a catastrophic failure. If the rust gives way, the struts will go up through the tower which best case causes huge damage to the vehicle and worst case could result in a fatal traffic accident. Reading around the internet, this is a common problem from 1996 through 2000 vans and repair kits are back ordered at dealerships around the nation. Daimler/chrysler is fully aware of this problem and a recall should be issued as this is a huge safety issue for their customers.

Filed Jun 6, 2005 · Suspension · 96,000 miles · NY

Strut tower rusting out almost caused crash. I read that this is common on 96-00 caravan why is this not covered.

Filed Jan 5, 2005 · Suspension · 80,525 miles · MI

Vehicle was taken to dealer for an oil change when it was noticed that the cross member on the vehicle was so rusty that it was starting to break off.*ak

Filed Dec 7, 2004 · Suspension · 100,000 miles · OH

The shock struts on the passenger's side rusted. Consumer took the vehicle to a body shop, and then contacted the dealer. However, the problem recurred.

Filed Jul 19, 2004 · Suspension · WI

Consumer states that the vehicle's front struts are rusted. Dealer notified.*ak the dealer stated that the vehicle should be condemned because of the severity of the rust. The rust was not easily detected because it was under paint.

Filed Jun 17, 2004 · Suspension · 117,000 miles · MI

Shock towers which lead to the springs of the vehicle rusted.

Filed Feb 19, 2004 · Suspension · 70,000 miles · SD

While driving, the consumer heard a loud noise coming from the front of the vehicle. Consumer took the vehicle to the gas station and the mechanic informed the consumer that the lower ball joints were worn out. *ak the front axle broke while driving, the sway bar bushings were replaced as well as the rear shocks.