1999 Dodge Caravan technical service bulletins
104 technical service bulletins and manufacturer communications cover the 1999 Dodge Caravan.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- KEY, Master If replacing the key/FOBIK on a WJ, KJ, TJ, or PT Cruiser, use the "AC" NIC level part number
- Charging System, Battery Diagnostic Tools and Warranty
- Repair Parts Used For Structural Repairs
- Use of Salvage/Recycled Parts
- Use of Aftermarket Parts
- Service
- Valve Body
- Child Seat Tether Anchor Installation
- Snow/water ingestion into rear brake drum
- Snow/water ingestion into rear brake drum
- Pop/tick sound in steering wheel area
- Cosmetic corrosion or perforation at upper strut tower/s usually between the strut and upper load path...
- Snow/water ingestion into rear brake drum
- Concerns with the air bag warning indicator lamp on intermittently or constantly
- Flash programming failure recovery
- Subject regarding outside rearview mirror glass replacement
- Experiencing a pop/tick sound heard coming from the steering wheel area while the vehicle is in motion
- Subject regarding transmission oil cooler line hose clamp service
- Subject regarding camshaft / bearing service
- Subject regarding outside rearview mirror glass replacement
- Experiencing a squawk / creak / groan sound from front suspension while driving over rough / bumpy roads
- Subject regarding airbag / clock spring service for various models including 2002 model year jeep liberty
- Subject regarding generic scan tool (GST), publication no
- A condition may exist where a low frequency howl / moan noise is heard from the rear brake area during low...
- On some vehicles, while driving through deep or blowing snow / water, the snow / water may enter the rear...
- Subject regarding wire splice repairs
- Subject regarding outside mirror glass replacement
- Information on service publication updates
- Subject regarding child seat tether anchors
- Experiencing a chatter sound coming from the sliding door power lock actuator(s) when the power lock...
- Information regarding updates to the fuel system service procedures
- Subject regarding non-deployed airbag handling procedures
- Subject regarding EGR monitor diagnostic test difficult to complete or not ready at high altitudes (above...
- A condition may exist where there is intermittent operation / static occuring in the front instrument...
- A condition exist where the roof panel surface exhibits waviness or depression(s) near the front of the...
- Information on spare tire winches
- This bulletin contains procecures to remove waviness or depressions from the roof panel surface
- Experiencing a knocking / clunking sound coming from the front sway bar link heard inside and outside the...
- This bulletin provides a revised wire splice procedure and related parts
- A condition where a click / rattle sound may be heard coming from the area of the steering wheel while the...
- Subject regarding misdiagnosed leak detection pump systems with diagnostic trouble codes P1494, P0442...
- Concerns with the pcv valve freezing under extremely cold conditions
- Information regarding snow / water entering the rear brake drums
- Vehicle operator may complain of poor AM radio reception
- Daimlerchrysler corporation is now offerinb airbag on / off switches for selected vehicles
- Information on rear wheel park brake actuator / lever service
- Subject on transaxle seepage mis-diagnosis- case porosity
- Subject on the child seat tether anchors
- Intermittent malfunction indicator light (MIL) illumination with hex code $1B (P0123) throttle position...
- Information regarding the ignition switch housing service
- This bulletin announces the availability and installation of a resuable automatic transmission oil pan gasket
- Information on child seat tether anchors
- Concerns with speed control which does not maintain set speed while climbing a grade
- Experiencing vibration / buzz in the accelerator pedal at 2200 - 2500 RPM and above 3500 RPM
- Vehicles may exhibit an intermittent condition where the a/c system blows warm air after the a/c system...
- Concerns with the right side sliding door trim panel contacting the quarter panel when the door is opened
- This bulletin explains the operation and application of the leak detection pump (LDP) monitor test
- Conditions with inoperative or intermittent remote keyless entry (RKE) transmitter
- Experiencing tick type noise at top of left b-pillar
- Concerns with serpentine belt slipping off idler pulley
- Emissions call for an incorrect vehicle emission control information (VECHI) label which was inadvertently...
- Some vehicles may exhibit a condition where the air conditioner system blows warm air intermittently
- Information on fast feedback fleet - installation of 2000 model year 41TE transaxles
- Service action regarding headlamp aim procedure change
- Subject pertaining to smooth road high-speed vibration or shake condition
- Customer may complain of low speed tire wobble
- Conditions with intermittent loss of speed control
- Service action regarding an incorrect vehicle emissions control information (VECI) and monroney labels...
- Vehicles may experience faults related to the transmission range sensor (TRS)
- Service action regarding vehicles equipped with luggage rack crossbar installation information
- Subject regarding reusable automatic transmission oil pan gasket
- Service and parts information on 1999 running changes to transmission range sensor (TRS) tt
- Concerns with front and / or sliding door power lock motors making a whirling noise
- Subject pertaining to a ticking type noise at top of left b-pillar
- Subject regarding airbag on - off switches
- Subject regarding oil seepage at cam position sensor / misinterpreted head gasket leak
- Windnoise around fron door glass, especially at top of the b pillar
- Vehicle experiencing a ticking noise while at idle from engine
- A new multi-layer steel ( mls ) head gasket has been developed and is being implemented into production...
- Subject regarding i/m ( inspection maintenance ) testing - OBD II "carb" readiness monitor information
- Approval of using of in- transit protective film
- Information on electrical feature changes
- Right side half shaft cv boot is made of a special high temperature resistant material that CAN show heavy...
- A squeaking / chirping noise is heard ( inside or outside the vehicle ) from the strut tower area( s )
- Subject regarding body control module auto headlamp sensor/ signal circuit diagnostic trouble code (DTC)
- Subject on flash programming failure recovery
- A "honk" or squeal noise during parking lot maneuvers
- Condition with a/c compressor lock-up at low mileage
- Exhibiting a moaning and groaning sound accociated with a/c compressor operation
- Subject regarding erroneous body control module diagnostic trouble code
- The front door body mounted weaterstrip falls off mounting flange, usually along the top of the door opening
- Subject regarding a/c suction and / or discharge line requires replacement due to cracking at or near...
- Perceived loss or cahnge of radio station presets
- Information on body control module (BCM) replacement
- Information on installation of radio transmitting equipment
- Information on vehicle aluminum wheels having a unique balance weight retention flange
VIN decoder
See the problems and recalls for an exact car
Buying a used 1999 Dodge Caravan?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history