1999 Dodge Caravan electrical problems

Filed Feb 9, 2015 · Electrical · FL · fire

While driving van speed would not accelerate over 35mph, I pulled over to find wires burning it was the fuel injector harness and the surrounding areas of that location.

Filed Mar 9, 2014 · Electrical, Lights · 10,000 miles · LA

While driving the vehicle, the instrument panel shuts off without warning and for no known reason. Dodge told us that it was a short in the wiring in the dash that caused the computer to shut down. The technicians insisted that the problem would be impossible to find, especially since it could not be replicated on demand. This has continued to happen periodically, most recently in january 2014, when the computer went out, shutting down the instrument panel and the wheels on the passenger side of the vehicle. The driver's side continued forward, which pushed the vehicle into a curb, flattening two tires and damaging those respective rims. Although no one was injured, had there been a vehicle next to the van, as opposed to a high curb, the defect in the vehicles wiring and computer would have caused a collision. There is never any warning prior to the electrical and instrument panel going out. There is no known trigger that causes this problem. It is not triggered by going over a bump, driving at any particular speed, stopping or accelerating. I wanted to report this, because a witness (who happened to be a police officer) to the most recent incident advised us that this is a known and common issue in dodge caravans built in the late 1990s/early 2000s.

Filed Oct 10, 2012 · Electrical, Suspension · 115,000 miles · IL

Tl* the contact owns a 1999 dodge caravan. The contact stated that the entire instrument cluster failed. The vehicle was taken to the dealer where the contact was advised that the wiring harness was rusted and would need replacing. In addition, the front strut tower assembly was also found to be completely rusted. The dealer advised the contact that the vehicle could not be aligned and was unsafe to drive. The vehicle was not repaired. The failure mileage was 115,000 and the current mileage was unknown.

Filed May 9, 2012 · Electrical · 145,000 miles · VA · fire

My parents van. A couple of days before this happened I tried to start it and all it did was click. I tried to start it again and it started right up. I turned it back off and tried to start it again,same thing happened. All it did was click. I then tried to start it again and it started right up. We drove to town with no further issues that day. The next day it started right up. We drove about eighty miles to my sisters house. When we came out to leave in the evening. I started the van and it started right up,but it was making a rattling noise that I could just barely hear over the engine noise. I turned the van off,but something was still running. The starter was still engaged with the engine and running. I turned the key back on and the engine started again. I turned the engine off again and the same thing happened. The starter stayed running. I attempted to drive two hundred yards to my sisters garage to get pliers. I realized I probably did not have enough time to get to her garage before the starter burnt up. I ran in the house leaving the van running. By the time I got back to the van and got the hood open the starter was starting to smoke and make a real bad winning noise. My wife got a fire extinguisher. I pulled the negative battery cable. By the time that I got the cable off the starter was already burnt up and starting to catch fire. Their was so much smoke. I have know doubt that if I had not gotten the battery cable disconnected when I did that the van would have gone up in flames. The other bad thing was that it was sitting next to my sisters house and that would have gone up in flames with it. I am just glad that it did not happen when my seventy five year old parents were driving it,because I believe that the van would have defiantly caught fire and they would not have known what to do fast enough. This year make and model needs to be recalled before someone gets killed. Thanks.

Filed Sep 9, 2010 · Airbags, Electrical · 100,000 miles · CT

Tl* the contact owns a 1999 dodge caravan. The contact stated that the clock spring on the air bags broke on the vehicle in may of 2010 and it was replaced under campaign number 04v480000;air bags. The contact stated that all gauges go out on the dashboard when the failure occurred. The contact feels this is a safety issue because he does not how fast the vehicle is traveling and he does not know how much gas is in the vehicle. The contact stated that the part is supposed to be under a lifetime warranty, but the part had broken on the vehicle twice in three months. The failure mileage was 100000 and the current mileage was 103000.

Filed Apr 15, 2010 · Airbags, Electrical · 100,000 miles · MD · crash

Tl* the contact owns a 1999 dodge caravan se. The contact stated when the vehicle is started, the air bag warning light would illuminate on the instrument panel and remain illuminated. In addition, the vehicle horn was inoperable. The contact received notification of a recall campaign (the federal safety agency campaign id number: 04v480000: air bags) which she believed was directly related to the failure. The recall letter advised a new clock spring would be installed in the steering column. The vehicle had not yet been taken to the dealer for diagnostic testing or repairs. The contact stated the vehicle had previously been involved in a crash but there were no injuries. The approximate failure mileage was 100,000 and the current mileage was 147,750.

Filed Oct 2, 2009 · Electrical · 200,000 miles · IA

Tl*the contact owns a 1999 dodge caravan. While driving approximately 35 MPH on normal road conditions the electrical instrument panel gauges failed to operate. An authorized dealer stated that card in the instrument panel was damaged. The vehicle has not been repaired. The contact had concerns of the safety risk involved. The failure and current mileages were 200,000.

Filed Jun 8, 2009 · Electrical · WI

The ignition key will not turn. Unable to start the car. Not an electrical issue. The key physically does not turn. Happened completely randomly. Other people have suggested tapping the end of the key with a rubber mallet, but I do not trust this fix. I now have a family vehicle that I do not feel comfortable bringing my family anywhere far away in. Transporting my family was the only reason I bought a minivan.

Filed Mar 12, 2009 · Airbags, Electrical · 150,000 miles · SD

Tl*the contact owns a 1999 dodge caravan. While the vehicle was parked and the engine was being warmed up, the passenger side air bag deployed without warning or an impact. Since then, the heater and power windows have stopped functioning. The cause of the failure has not been determined. The current and failure mileages were 150,000. Updated 10/06/09. *lj updated 10/08/09

Filed Aug 26, 2008 · Driver assistance, Electrical · 220,000 miles · CA

Our belts sips off during wet weather"five times we replaced the "s" belt and the tensioners,waterpump,overheating our 2nd yr of owership.now the 3rd yr of transmissions leaking,the ABS light came on while driving at 35mph w/children in car ,starting to brake causing to slow way down in traffic and made a chime sound,the horn went off and it got hot fast causing the car to shut down. Thank god there was room to get over. All the lights were flickering all over the dashboard. The car just leaks everywhere,water,oil,trans. Something needs to be done about these cars. I cant even get mine smog because I have to keep unplugging my battery because now we have a short in the electrical system somewhere. I brought a lemon.....oh yeah! I called the dealer, they cant replace the cruise control unless the ABS light stays on. I hope I don't die cause the airbags wont work because I have a electrical shortage. 2 batteries were replaced,alternator too. The clockspring wont work for my car only the cruise control so said the dealer. I would feel bad selling this car to a family ,cause what if they were killed. I couldn't deal with that. The day that happened was on my daughter 16th birthday. I had to stop everywhere all day to put water in the radiator just to keep it cool enough not to ruin her day. I hate hot days,I fear the rainy days, I cant see at night cause my headlights on the left side burned out and the covers has a glass over them.