2001 Dodge Caravan lights problems

Filed Feb 28, 2025 · Lights · FL

There is no incident, however I would like to report a manufacturer problem. Many manufacturers put vehicles on the market with front headlights that are too bright and not aimed properly. See [XXX] There are regulations for the lumens of headlights and system of reflectors, but I assume manufacturers are not be watched for violations. Where I live, in Sarasota, FL, I am blinded by all the vehicle lights at night because lights appear to be on bright when they aren't. Something is very wrong. I don't think everyone is having aftermarket LED lights installed. I think they are coming from the manufacturers that way. Can you help? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 26, 2023 · Lights · MD

.

Filed Nov 7, 2014 · Lights · 170,000 miles · NC

Tl* the contact owns a 2001 dodge caravan. The contact stated that while driving 70 MPH, the headlights failed and an unknown light illuminated. The vehicle was taken to the dealer. The technician diagnosed the front modular needed to be replaced. The vehicle was repaired but the failure recurred. The manufacturer was made aware of the failure. The failure mileage was 170,000. The VIN was unavailable.

Filed Dec 30, 2010 · Lights · 114,000 miles · WI

Tl*the contact owns a 2001 dodge grand caravan sport. The contact noticed that while driving at any speed in wet weather conditions, the headlights shut off, the warning lights illuminated, and the all of the gauges display zero. The dealer performed a diagnostic test and replaced the body control module. The contact did not inform the manufacturer. The current mileage was 151,000. The failure mileage was approximately 114,000.

Filed Aug 17, 2010 · Electrical, Lights · 90,000 miles · FL

2001 - dodge caravan - left rear tail light fell out, hanging on by wires. Took to private mechanic, said dealer had to fix. Took to dealer, stated could not reinstall, needed whole new unit for dry rotted rubber gasket. Took vehicle to home depot, bought 1 tube of black exterior silicone caulk. Drove vehicle home, and cleaned area around rear tail light. Pushed light back into place and caulked around dry rotted rubber. Taped tail light to body assembly (be careful to use tape which will not damage vehicle). Left vehicle to sit still for 24 hours as caulk dried. Made this simple repair myself for $2.86 when the dealer wanted over $500 to repair. What a rip off when they can't even make a vehicle that lasts, they have to price gouge their customers.

Filed May 4, 2010 · Lights · 125,000 miles · AR

Tl*the contact owns a 2001 dodge caravan. The contact stated that while driving various speeds, the headlights began to flash, the horn would sound and the hazard lights would also flash on and off. The failure also occurred when the vehicle was parked with the engine turned off. The contact had to disconnect the battery to prevent the failure from recurring. The contact spoke with an authorized dealer who stated that they were aware of the failure but there were no recalls. The dealer also stated that the hot body controller and front body modulator had to be repaired at the owners expense. The failure mileage was approximately 125,000. The current mileage was 134,893. Updated 07/22/10 *bf updated 07/27/10

Filed Jan 15, 2010 · Lights · 54,000 miles · IN

Tl*the contact owns a 2001 dodge caravan sport. The contact was driving approximately between 35-40 MPH on normal road conditions with the headlights in activation. Suddenly, the headlights became inoperable without warning. The driver experienced limited visibility and continued in operation with the emergency flasher engaged. The failure occurred intermittent. The manufacturer was notified of the malfunction. The vehicle has not been repaired at this time. The failure mileage was 54,000.

Filed Oct 30, 2009 · Electrical, Lights · 130,000 miles · FL

Headlights and dashboard dies, intermittent. The problem show when I used the turn signal, the dashboard dies entirely and the headlights goes off, it happens every 2 or 3 days, after a few minutes they worked again. It happens to me more than 10 times. I solder the terminals at the electrical box that according to the electrical diagram feed the turn signal, dashboard and headlights in the engine compartment 2 years ago, since then the problem has not occurred any more.

Filed Sep 15, 2009 · Lights · 98 miles · MN

2001 caravan headlight problem. Faulty fcm (bad connections) this is a very serious problem that seems to be getting ignored by everyone especially chrysler. This issue needs to be put on the front burner before someone gets seriously hurt or killed in a crash. Headlights going out in the middle of the nite on the highway going 60 MPH is dangerous. Please look into a recall on these vehicles. The fcm connections are faulty. Multiple people and mechanics have discovered where the problem is and has fixed them by readjusting connecter pins or tabs in the connection and this has corrected the problem. Even canada knows of the problem. Also these people have been getting soaked 1000s of $$$ in repairs (chrysler) leading to the same problem coming back. Please lookup google( 2001 dodge headlight problems) this topic is heavily talked about on the topix.com site easiest way to find this forum is to google this phrase (2001 dodge headlight problem). 186 posts about this problem in since 2006. Hard to find through the site.please try to find a way to address this problem. Thank you for taking the time to read about this issue. Please e-mail me on what can be done in the future. Thank you.

Filed Jul 24, 2009 · Electrical, Lights · 13,400 miles · PA

Since late spring 2008, the headlights on my 2001 dodge caravan have intermittently flickered and gone out, then come back on. This continued off and on until I had the vehicle repaired at a vehicle electrical system expert (enormis, erie pa) in july of 2009. They replaced the fuse box for the vehicle at a cost of approx $430. They indicated that they have had to do this with approx. Six other vehicles recently. This was an extremely dangerous situation, having your headlights go out at night on an interstate highway while traveling 60 MPH, especially while it is raining. I have the original part:there should be a recall of these vehicles and I want to be re-imbursed!!! I am an attorney and know a dangerous defect when I see one!!!!