My car stalls after refueling the tank. It does it at stops and slowing speeds. It has happened in the middle of turns etc. I t has almost caused me to crash. I went to my mechanic who in turn said I needed an entire fuel tank $1700. While debating on the having it fixed of course checking my finances. I went on line and seen numerous articles about this issue. In the articles you guys are mentioned for having done a federal probe into the situation and chrysler extending a warranty on the problem to life time. Well then I went to the dealer and brought it to their attention and nobody knew anything about it. They charged me $65 to diagnose the car and proceeded to give me an estimate of $1900. They then gave me the number to chrysler who in turn knew nothing of the problem and sent me on my way saying there is not a problem and no warranty. I need to know if in fact this is a legitimate claim by the federal safety agency in the articles out there. Some of these articles are as recent as of february 2014. I have almost had two accidents from this issue. It has taken numerous scenarios to trouble shoot this and when reading the articles brought everything to light. Please help. The articles mention 2006 chrysler 300,dodge charger, & dodge magnum with v8 5.7 & 6.1liter engines. This is what I have.
2006 Dodge Charger fuel system complaints
Page 12 of 18: complaints 311 to 340 of 516, newest first, as owners wrote them.
After filling my tank I drove away from the station and my car shut off while driving down the road. It took a few attempts before my vehicle actually started again. I drove down the road towards my house and it stalled on me again. This time I was a little faster to turn on the vehicle but it stuttered all the way home. This happens every time I fill my tank. To be sure of the issue I ran my gas tank to half tank and refilled it. The same stalling outcome was present. I recently took my car in for repair of this issue but after the repair it continued with the stalling. After this happened to me on monday march 18, 2014 while my children were in the vehicle I decided to go back and get it looked at again by the dealer. My car is currently (march 19, 2014) at the dealer for the second time to try and get this issue fixed. I see on your website that the federal safety agency action number : pe13016 has been filed for this identical issue that I am having. I called chrysler to see if they would give me the letter to owner for extended warranty on the gas tank and I was told that I could not get it because my car does not have this issue, yet my car is at the dealer right now getting this same issue fixed. As usual I feel that chrysler is trying to ignore the issue and not give support to those who have purchased their product. My dealer has been helpful but they said they could not cover me under this extended warranty unless it appeared with my VIN # in the chrysler system. This issue is very dangerous especially if you are fueling up near a highway and then getting onto the highway. While chrysler claims that this is low risk to motor vehicle safety it is high risk to human safety. We can replace cars, we can not replace people. All I ask for is reimbursement for a manufacture defect or an extended warranty.
Tl* the contact owns a 2006 dodge charger. The contact stated that the vehicle stalled after refueling. The contact indicated that the failure occurred when the fuel level was above 3/4 and while turning or coming to a stop. The vehicle was taken to the dealer where it was found that a faulty rollover valve/vapor valve was allowing fuel to enter the engine. The manufacturer was notified and no solution was offered. The failure mileage was 80,000.
Each time after filing the gas tank the car stalls and engine dies before able to make a left or right turn or taking off from stop light. It does this repeatedly until driven a few miles. Stalls at the most critical time when merging into traffic. Getting to the point now that this vehicle will be junked before I get killed or someone else. Chrysler does not honor their extended tank warranty under the agreement as per the federal safety agency agreement on feb.14,2014. Therefore as a taxpayer that paid for their bailout ,next time let them fail. No more chrysler products for my family and friends ever.
Multiple times in the last month when I have refueled, the vehicle is difficult to start and then runs extremely rough and usually dies on the road once or twice. The engine seems to rumble and shakes the vehicle and then after a short period of driving it seems to go away. The engine light blinks on and off while this situation is happening. My mechanic has looked the problem over twice and cannot seem to determine what needs to be done to correct the problem. He has been in contact with dodge/chrysler and they indicate no other reported problems. The mechanic is still checking but seems to remember changing a fuel tank on a charger in the past that was having an engine problem and it corrected the problem. He is rechecking his files to find that repair job. Last night my vehicle died twice in my driveway (with less than half a tank of gas) and I consider it unsafe to drive at this point. Anyone want to buy a used 2006 charger (hemi)??? It will be sitting in my driveway. [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
11/16/13 I had just filled up my gas tank on i95 at ladysmith, va and was coming down the ramp northbound when the engine sputtered and stalled just as I merged onto the highway. I pulled over after getting blasted by truckers horns for making them slam on brakes. After a couple attempts it restarted and I took off again, only to have it stall again. It did this three more times before it finally started and did not stall. Since it didn't happen again, I figured I just got some bad gas. Then it happened the next time I filled up. And the next. And the next. I checked on-line and found several others who had experienced this and they said it was the gas being filled to the brim that caused it. I tried filling up less than a full tank and this did seem to work. Only problem is I now want to sell or trade in the car and I don't feel right passing this problem along to someone else. I saw the article about the federal safety agency forcing chrysler to extend the warranty on 2006 hemi chargers and took it to the dealer only to be told they know nothing about this and would fix the problem for $1100. Why hasn't chrysler set up a program for these replacements? Is there a list of the vehicles that are covered by the new extended warranty? Can I please see if my car is on it and if not why not?
Tl* the contact owns a 2006 dodge charger. The contact stated that while waiting at a traffic signal immediately after refueling, the vehicle stalled without warning. The vehicle was taken to the dealer where the technician diagnosed that the fuel tank needed to be replaced. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was 14,000 and the current mileage was 21,000.
Vehicle stalls out intermittently after refueling. This happens when vehicle is stopped or slowing for a stop. Had vehicle examined and no trouble codes are in the computer.
Immediately after fueling vehicle to regular capacity and automatic shutoff - no "topping off". Left the filling station and the car stalled several times, each time in a precarious position such as decelerating to make a turn or coming to a stop at a light. Car dies losing power steering and breaks. Thought this might be bad gas but it has since repeated every time the car is refueled. This is becoming a serious safely concern as the condition is common during the first 50 or so miles of driving after a fill up. Upon speaking with the dealer they blamed the issue on the end user overfilling the tank. As the only user of the vehicle it is never overfilled nor ?topped off?.
Immediately after fueling vehicle to regular capacity and automatic shutoff - no "topping off". Left the filling station and the car stalled several times, each time in a precarious position such as decelerating to make a turn or coming to a stop at a light. Car dies losing power steering and breaks. Thought this might be bad gas but it has since repeated every time the car is refueled. This is becoming a serious safely concern as the condition is common during the first 50 or so miles of driving after a fill up. Upon speaking with the dealer they blamed the issue on the end user overfilling the tank. As the only user of the vehicle it is never overfilled nor topped off.
After fueling up my 2006 dodge charger rt the car will repeatedly stall. This is obviously a very dangerous situation. This happens every time I fill the car with gas.
Tl* the contact owns a 2006 dodge charger xt. The contact stated that the engine would stall sporadically after the vehicle was refueled. The contact inquired about a technical service bulletin (tsb) under the federal safety agency action number: pe13016 (fuel system, gasoline) however, the extended warranty only covered the vehicle for up to 100,000 miles and the contact had exceeded the mileage. The vehicle was not repaired or diagnosed. The manufacturer was made aware of the failure. The approximate failure mileage was 108,000.
While waiting at stop lights, car idles fine. The moment the light turns green and I release the brake to step on the gas pedal the car stalls. This has happened up to 4 times in one day. Happened only once today 3/6/2014.
Tl* the contact owns a 2006 dodge charger. The contact stated that while driving 2 MPH, the vehicle stalled without warning. The vehicle was taken to the dealer where the technician diagnosed that the dual fuel tank assembly was defective and needed to be replaced. The manufacturer was made aware of the failure. The vehicle was not repaired. The failure mileage was 66,200 and the current mileage was 66,258.
After filling up the gas tank, within minutes I was turning left in an intersection when the engine stopped and the steering became very difficult and an accident was barely avoided. This was extremely dangerous because of oncoming traffic. In fact I was almost struck by two vehicles, one coming at me and the other behind me. I restarted the car, drove through the intersection for about 5-10 seconds and the car stopped again, same steering difficulties. Started the car a third time and it moved forward with no more stops. This has happened at least 20 more time in the past 3 years. Additionally, within the past 6 months, it has been very difficult to put fuel into the tank. It would take about 20 minutes because the nozzle would shut off. I could only put in very small amounts each squeeze of the handle. I find this not only annoying but also question the design of the whole fuel receiving and storage system of this vehicle. I have asked my local dodge dealership about the problems and was advised that a new gas tank would have to be installed for approximately $1,200! A new gas tank? That would confirm in my mind that these problems are caused absolutely by a design flaw and should be recalled and repaired asap before there are fatalities linked to this flaw.
So my car began to stall after filling it up with gas. Most of the time it stalled while stopped. A few times while in motion. Since the car dies I have lost power steering.
3/1/14....my husbands 2006 dodge charger/hemi, a few months after he purchased vehicle, would stall suddenly after filling the fuel tank with gas. He brought it to the dealer, while still under warranty, but they always told him there was nothing seriously wrong, perhaps a little dirt got into the fuel injection and it should clear up on its own. This kept happening but the dealer still would not admit there was anything wrong. Then within the last few months it would sudden stall even without fueling and/or while he was driving, a definite safety issue. He brought it to another dealer, as the one where he purchased the auto closed, and they diagnosed it to be a defected fuel tank. By now, of course, the vehicle was out of warranty, so we had to pay for the service out of pocket. This was done on 1/14/14 and it was expensive. We definitely feel that this is the responsibility of the manufacturer since it should have been repaired while in warranty and expecting some type of reimbursement. Researching this I found many complaints regarding this same issue and I think they will agree with me. Thank you.
Tl* the contact owns a 2006 dodge charger. The contact stated that after refueling, the vehicle would begin to hesitate before stalling. The contact was able to restart the vehicle but the failure was recurring. The vehicle was taken to the dealer, who was unable to duplicate the failure. No repairs were performed. The contact also stated that when the engine was first started, the odor of gasoline was present inside the vehicle. The manufacturer was notified of the failure. The failure mileage was 96,000.
While driving with cruise control on the car just stalled out for about 3-5 seconds and kicked back on. This has now become more frequent and also stalls while stopped now. I have spent over 1300$ trouble shooting and going back and forth to the mechanic. Only to start searching and came across this investigation. I just want the car to run correctly.
Car will stall while decelerating on freeway after filling up the car. Even though this is an issue that is known with chrysler and they have extended the tank warranty to lifetime under nvs-213krh; pe13-106 they are still not communicating to the dealers that this issue exists and what the proper fix is. I also can not get them to confirm or deny that my VIN is part of the group of cars that this problem pertains to, however I had the same exact symptoms as all other drives with the car stopping after refueling the system. The dealership tries to blame the customer for 'over-fueling' but I find it ridiculous that you can not fill your engine to full ( 7/8 or above) without this issue happening. When you bring it to the dealership they show raw fuel in the cannister and want to trouble shoot it as a customer error. So far this issue has cost me $2500 (tank, labor, rental, 2 canisters now) to fix on my own and chrysler and the dealership are of no help.
After fueling the vehicle it stalls and shuts off. This has happen several times and I have had the evap replaced but the problem till remains. This is a very serious safety issue and someone will get seriously injured and even killed if this does not get fixed. Everyone that owns a charger like this, life hangs in the balance if they continue to drive it.. Please help get dodge to do a recall. Lives over profits please!!!!!!!
I own a 2006 5.7 hemi dodge charger. During my trip into work my engine shut off automatically in park, so I went through 4 cycles of restarting my engine. Finally I got the car started and proceeded down my street onto the main road. As I gave my car gas the engine shutdown and I went through the cycle again. I called one of the local dodge dealerships where I purchased my vehicles and they had no complaints on the problem. As I drove to the dealership I got on the interstate at the speed of 70mph the engine was hesitating again, but did not fully shutdown. I am sure dodge has heard this complaint from multiple owners and I feel dodge should correct the issue. This is very dangerous especially if you are traveling on a busy road.
Tl* the contact owns a 2006 dodge charger. The contact stated that while driving approximately 5 MPH, the vehicle stalled without warning. The contact was able to restart the vehicle, which was taken to an independent mechanic. The mechanic replaced the spark plugs, cleaned the throttle body, replaced the plugs for the power control module, and changed the fuel pump relay. The failure recurred after the repairs were performed. The manufacturer was made aware of the failure. The approximate failure mileage was 97,000.
Car was running fine, stopped at a gas station and filled the tank. After leaving the station and pulling into traffic the car engine died. Almost was rear ended due to the car stopping instead of accelerating. Pulled over to the right side of the lane and tried to restart. Second attempt the car started and I pulled out into the lane and drove about a block and the car engine shut off again in an intersection. Another close call with other vehicles. I restarted the engine and pulled into a parking lot and drove around to see if the engine would quit again, it did, 2 more times. Finally it stayed running for awhile so I drove it home approx 10 miles with no problems. Thought I had gotten bad gas or water in the fuel. Drove it for a week no problems. The next time I refueled at a different gas station and it happened all over again, same symptoms. The problem is associated with filling the fuel tank. Seems to match the federal safety agency action number pe13016.
When out of town I filled up my dodge charger and headed to a hotel. On the road my car began to stall, but not completely lose power. When I slowed to make a turn it completely died. At the time I thought I had gotten bad gas, and had my car towed and repaired. However, it continued to do the same thing only after filling my tank. I took my car to firestone for a diagnostic and the mechanic told me that I would need a new fuel tank. He told me that many people with my car have been having the same issues. I googled the issues I was having and sure enough he was correct. I eventually got the gas tank replaced at firestone and there hasn't been any issues since.
After filling the gas tank, the car stalled. Numerous attempts to get the car started failed. Car would try to start, but would not catch. After sitting overnight, car would start. Numerous times after filling, the car would chug and lose power or kill all together.
I own a 2006 dodge charger r/t with the 5.7 liter hemi engine. I purchased it new in june of 2006 with 5 miles on the odometer. After 6 years of filling up my car by letting the gas pump stop automatically with no issues; the car began to stall right after filling-up when topping off the tank, starting around may of 2012. I called autonation dodge in roseville, california and the service technician was familiar with my issue. He asked if I had filled up the tank by topping it off. I told him, affirmative. He advised me to not top off the tank at all during fill-ups or to buy a new fuel tank at the cost of $2000-3000 with installation. For the past couple of years, I've been lucky to not top off the fuel tank, but it has occurred at least 4 times when I made the mistake of topping off the gas. The last time this occurred was yesterday. After buying gas and having the pump stop automatically, I drove into a major intersection and stopped at the red light. The car turned off, and it took about 3 tries of re-starting the ignition in park before the car luckily powered on again. When my light turned green, the car would jump and lose power while shifting into second and third gears. I was very fortunate to not have any cars behind me, because this issue of the car stalling could cause an accident. This stalling hazard happened again yesterday on my way home and also this morning. I feel chrysler/fiat should replace all effected 2006 dodge charger r/ts with this issue by replacing the tank or whatever repair it would take to fix this safety hazard. I feel that most owners of this vehicle won't be aware of this issue until it happens to them personally. It should be mandatory for chrysler/fiat to issue a recall with all expenses covered by the manufacturer.
After filling gas tank, engine hesitates and/or stalls. I only fill up until the fuel pump automatically shuts off, I do not add any more fuel than that. This has happened almost every time I have filled up with fuel. Most of the stalling/hesitation occurs when coasting or decelerating (coming to a stop). This has created multiple very dangerous situations due to the engine not running and I have a loss of the power assist to the steering. Occasionally the engine has a difficult time restarting after the engine stalls. This will occur approximately 4-8 times after a fill-up of fuel.
After filling car with gas the engine stalls multiple times for the first few miles.this has happened to me a few hundred times over the years,I have almost been t boned and rear ended multiple times due to this defect. I try not to fill the tank but it happens even if gas is close to the fill mark.
I refueled the gas tank with high octane gas, and while driving the short distance home, the engine stalled three times. This made braking difficult and scary, as I was in traffic. Each time it started back up, but left me very afraid of wrecking from possibly not being able to stop the car. The same problem occurred after refueling on 9/13/13 and 11/16/13 and 1/31/14. I reported the first incident that occurred on 4/28/13 on a separate complaint form (xref odi #10562746. As of this date (2/3/14) the mileage is 27,670. The low mileage is because I alternated between three vehicles.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Dodge Charger?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history