I had just filled my car with (93 octane fuel) after putting the car back on the road ,as it is my summer vehicle. I never fill past first click. I started it and it started idling rough 200-300 rpms and it quit. I started the vehicle and had to give it some gas to get it to go again which it did,chalked it up to coincidence. I pulled out of the gas station and was making a left hand turn across traffic and no sooner did I pull out than did it stall,narrowly missed being hit by a large truck,put in neutral and it restarted. However it did not run very well it was what I call bucking and surging as I drove down the road the car was almost unresponsive as far as throttle control about 15- 30 MPH. As I left the city the car stalled again I rolled to the right side of the roadand popped it into neutral,it restarted and idled normal again. I was now entering the highway to go home and made it home approximately 15 miles away. The car seemed fine again. I have long had a stalling issue with the car every since I purchased in january of 2012. I have take care of this car to the utmoststandard while in my possession. This car is immaculate and is not a clunker. I have also experienced the stalling issue when making tight turns at parking lot speed mostly to the left. The issue lies in the fuel tank itself there is a valve on top that fails and lets raw gasoline into the emissions vapor system. This should not be happening! Chrysler nationwide is going through 43 of these tanks on average a week. This tells me there is a large issue. To add insult to injury the tank is not cheap or simple or easy to install with an average bill of 1200 -1800 dollars depending on how many components are damaged as a result of the raw fuel entering a closed system.there are many chrysler tsbs concerning this condition,I believe they underestimate the severity of this condition.
2006 Dodge Charger fuel system complaints
Page 17 of 18: complaints 461 to 490 of 516, newest first, as owners wrote them.
Tl* the contact owns a 2006 dodge charger. The contact stated that after refueling, the vehicle stalled. The failure recurred numerous times. The vehicle was taken to a dealer each time and the contact was informed that the failure could not be replicated. The manufacturer was made aware of the failure. The vehicle had not been repaired. The failure mileage was 60,000 and the current mileage was 100,000.
Not sure of exact first date or mileage this happened, but around 12/17/12 and 92,000 miles I went to gas station and filled tank, then drove approx 1.5 miles towards home, and then while going about 25 MPH on slight downward slope in my neighborhood vehicle stalled out completely without any warning and oil light came on. I let car sit off for few minutes and then it restarted, then I drove less than 0.5 miles and car stalled again when backing into garage so I did not attempt to restart and pushed car into garage since never experienced this type of problem before on this vehicle, or any vehicle I have ever owned in 20 years. Then same thing happened again in jan 2013 right after fillup, car stalled within 100 yards of pulling out of gas station in traffic, but was able to restart but ran roughly for first few minutes after restart. Then happened again a few more times between jan - march after fillups. Then on 4/17/13 happened few minutes after fillup while on highway ramp and vehicle almost got hit by cars coming behind me with wife in car. That time vehicle would not restart after two attempts, but let sit for few minutes and then applied gas pedal and started, and ran rough again for few minutes afterwards then smoothed out. Very lucky that time my wife and I did not get rear ended by cars speeding up on ramp to get on highway since hardly any shoulder area to pull over. Since that incident I have been filling up tank using slowest pumping selection to try and avoid stallouts after fillups. Chrysler is aware of this problem based upon info I pulled off web, and only permanent recommend fix was to replace gas tank and all lines since they come as one assembly unit, but that sounds like a definite manufacturer's defect to me as opposed to a normal wear and tear issue, and should be made into a recall before someone gets seriously injured.
After refueling my 2006 dodge charger, the car stalled while traveling out of the gas station and the speed was appoximately 20 MPH. This has happened several times and only after the tank has been filled to capacity. From what I have read online this is a fuel overflow sensor on the top of the fuel tank that is causing this.
I had just filled up my car with fuel and upon exiting the gas station my car stalled. I put the transmission into neutral and coasted to the side of the road. I waited several minutes and restarted the car and went on my way without further incident. I had been aware of a potential problem with my vehicle for this type of problem with information I gleaned from internet forums and this helped me to not panic when it eventually happened to me. This event happened in the evening with fairly light traffic and with the traffic light in my favor. Had the roads been busier and the traffic flowing northbound at the time I may have been broadsided by oncoming traffic. This issue has not been acknowledged or addressed by chrysler to date as far as I know.
If I fill up my car with gas, it will stall and hesitate. After driving for a few miles it will stop and not happen again until I fill it up again. If I don't fill it all the way, it wont do it. Please fix it!!!
Immediately after fueling, the vehicle stalled while leaving the gas station and lost all belt driven components as a result - power steering, A/C, etc. The vehicle subsequently stalled several more times while driving, and exhibited labored acceleration in between. This was the first incident and has been repeated every time it was refueled until pump shut off since, regardless of different gas stations and fuels.
I filled my gas tank to full and it hesitates to start and also shut off on me once.
After refueling the vehicle the vehicle stalled making a left hand turn across traffic. The resulting issue didn't result in an accident but it was close. After that time, the vehicle will stall after filling the passenger fuel chamber over 60 liters.
Tl* the contact owns a 2006 dodge charger. The contact stated that after refueling, the vehicle stalled. The vehicle was taken to the dealer who stated that the fuel system was allowing too much fuel into the engine which caused it to fail. The vehicle had not been repaired. The failure mileage was 26,000 and the current mileage was 26,500. *tr updated 7/15/13 *cn the consumer stated there was a malfunction of a valve on top of the fuel tank, that was part of the emission system.. Raw fuel entered the fuel canister, which made the engine rich and stalled.
After filling up the gas tank the car stalled out while driving. Its been happening for a long time now. This only accrues after filling up only.
Vehicle engine stalled while driving in on going traffic many times most times after refueling having a hard time to get it started again.
On july 4th 2009, after refueling my 2006 dodge charger r/t (5.7l hemi with approximately 38,000 miles), it stalled while driving at approximately 45mph. It ran/idled rough when restarted. Since the first incident, it repeats the stalling issue randomly after refueling and has continued until current day (5/14/2013). It has stalled several times in the middle of intersections, causing dangerous situations that put my life, as well as other drivers in danger, but usually stalls when stopping at stop/yield signs. After refueling, it is unsafe for me to try and merge onto the freeway unless I circle town on low speed city roads until the car stalls or I feel it will not be an issue at the time - this is a gross waste of fuel that should not be necessary but under current circumstances, it is. Through my own investigation thru on-line sources and members within my local car club, I have found the issue to likely be a faulty roll-over valve within the fuel tank, which is non-serviceable and requires replacing the entire fuel tank (about $750~900 for parts and 3~6 hours of labor).
Tl* the contact owns a 2006 dodge charger. The contact stated that while driving 50 MPH, the vehicle stalled. The contact had to restart the vehicle to resolve the failure momentarily. The vehicle was taken to the dealer, who stated there was a charcoal canister in the fuel system that needed to be replaced. The manufacturer was not made aware of the failure. The failure mileage was 56,000. The current mileage was 58,005. Updated 7/10/13
After filling the gas tank the engine stalls and is difficult to restart. It will do this until the tank is not completely full.
2006 dodge charger rt (5.7 hemi) stalls suddenly when driving on highway. I placed car quickly in neutral and tried restarting twice before car started again. It is very scary now to drive on the highway. This issue continues to happen frequently. I noticed that it usually happens especially after filling up gas.
Tl* the contact owns a 2006 dodge charger. The contact stated that after fueling the fuel tank more than half full, the vehicle stalled. The failure recurred numerous times. The vehicle was taken to a dealer for diagnosis but no cause for the failure was found. The vehicle had not been repaired. The failure and current mileage was 70,000. Updated 6/4/13
I was driving the car at 60mph on the expressway when the engine quit with no warning causing the car to lose all power in heavy traffic. My car was nearly hit several times by other cars as I tried to change lanes in order to reach the emergency lane on the right side of the expressway. I restarted the car with no problems. The car engine has quit for no reason several other times with no warning in the last year while driving at different speeds. The manufacturer needs issue a recall, or be liable for any lawsuits resulting from accidents caused by defective fuel systems in these vehicles.
After filling tank with fuel, car stalls and dies several times due to flooding. Web search reveals this is a very common problem and only solution to fully resolve is to replace fuel tank with associated equipment. If this problem is as pervasive as it seems, then an investigation should be initiated and a recall begun. A car dying repeatedly in traffic is a very bad thing.
Tl* the contact owns a 2006 dodge charger. The contact stated that while driving 25 MPH, the power steering assist failed followed by the vehicle stalling. The failure recurred numerous times. The vehicle was taken to a dealer for diagnosis and the contact was informed that the fuel tank would need to be replaced. The manufacturer was notified and they offered to cover seventy-five percent of the repair cost. The vehicle was not repaired. The failure mileage was 75,000 and the current mileage was 102,000.
Tl* the contact owns a 2006 dodge charger. The contact stated that after refueling, the vehicle stalled while driving at unknown speeds. The contact took the vehicle to the dealer where it was found that the fuel tank and sensor needed to be replaced. The vehicle was repaired. The failure mileage was 35,000 and the current mileage was 46,237. *tr updated 05/28/13*lj updated 06/11/2013
For the past 3 months, 5 to 10 minutes after filling up with fuel, car stalls and dies. Spoke to the dealer mechanic and he said he had to replace the total gas tank in an 06 charger a few days ago for the same reason. He went on to say that this is the only way to fix the problem. Cost starts at 1700.00 up to 2500.00. Why is there no recall on this... Chrysler dodge will be paying much more when accidents and injuries start happening due to this issue. I was in the center lane of the freeway and everything locked up. It was peak traffic hours. I threw it in nutral to restart and go, I made it to the slow lane and put my hazard lights on until I could exit off the freeway. Car died 2 more times until I was off the freeway. I wil not drive on the freeway with this car until its fixed.
Tl* the contact owns a 2006 dodge charger. The contact stated that after refueling, the vehicle stalled. The vehicle was taken to the dealer where it was found that the fuel tank needed to be replaced. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 79,000.
It happen after I put gas in the car. I was driving and the car just die, I put it in park and started right away but it was driving like if it needed oxygen to breath. The next stop it die again I put it in park again and started right away and I continue to go home. It is very scary I drive the freeway a lot thank god it did not happen while I was on the freeway I would it cause a big accident. Now every time I put gas the car does the same thing I need to find an answer to the problem.
Immediately after fueling the vehicle, it stalled after start up while driving in traffic. The vehicle was not topped off, but had a full tank of fuel. This happened on two occasions to date, both occasions the vehicle died at least twice, once the vehicle died while in park and the other incidents were while the car was in gear and moving at a low speed through traffic.
This problem is related to the purge solenoid. The evaporative emissions system stores fuel vapors from the tank and then burns them in the engine, to keep the vapors from going into the atmosphere. When you fill the tank with fuel the air and vapor that the fuel displaces has to go into the evap system. There is a valve on top of the tank that allows the vapor out, but is supposed to shut off when liquid fuel hits it as the tank fills. What happens is this valve fails and it allows you to push liquid fuel into the evap system when you push too much fuel into the tank. This liquid fuel goes into the vapor canister and lines. When you start the engine a couple minutes later the purge solenoid will come on to do it's job and burn these vapors, but with this failed valve it sucks up liquid fuel instead, so the engine runs rough and can die at idle. The vehicle stalls for the next 5 miles or so whenever you take your foot off the gas, I.e. Taking a turn or sitting at a traffic light. The vehicle bucks violently as well. When the engine stalls it cuts all power to the vehicle causing you to lose power steering and the ABS. Because the vehicle is vapor locked it will not restart immediately. My fear is that I am going to pull into traffic and be involved in an accident when my vehicle stalls and will not restart or I'll be injured when it happens taking a curve or turn. Chrysler customer service center says they have no service bulletins on this issue and no one else has complained about. A quick internet search (dodge charger stall after filling with gas) shows it is a wide spread issue not only with the charger but the magnum and chrysler 300 as well. Only way to fix issue is to replace the entire gas tank which is a $900 part with 2-3 hours labor.
The car would lose all power within a 10th of mile after filling up with gasoline. The car gives no warning signals, but stalls out. This happen also when the fuel tank was a fourth of tank of gas. The car would restart, within minutes after placing it in park. ( remind you I am sitting in middle of highway with no tail lights, or flashers) this is a major concern of mine. I was lucky that I did not get rear ended when the car stalled during "rush hour" traffic. The next day, I took the car to the dealership to have the problem checked and fixed. I was informed the fuel tank canister had a valve that was operating incorrectly causing the problem. The fuel tank and canister needed to be replaced. The total cost to me was $1548.00. The cost was high, but the chance of getting into a wreck and causing injuries was worth the price to fix to me. I feel since has been a problem with other 2006 chargers an investigation of the part needs to happen before someone does get killed.
Tl* the contact owns a 2006 dodge charger. The contact stated that when the fuel tank was filled to capacity, the vehicle stalled then the oil pressure light illuminated. The vehicle was taken to the dealer who replaced the fuel tank and the fuel operational canister. However, the failure was not corrected. The vehicle continued to stall. The manufacturer was made aware of the failure. The approximate failure mileage was 70,000 and the current mileage was 109,000. The VIN was not available.
Tl* the contact owns a 2006 dodge charger. The contact stated that approximately 10 minutes after refueling the vehicle, the vehicle stalled without warning. The contact mentioned that the vehicle would restart immediately after the failure. The vehicle was taken to the dealer. The technician diagnosed that the fuel tank needed to be replaced. The manufacturer was made aware of the failure but did not offer any assistance since the vehicle was no longer under warranty. The vehicle was not repaired. The failure mileage was 62,000 and the current mileage was 63,000. ...updated 03-20-13 *bf updated 04/02/2013
The engine stalls after I fill the fuel tank to its full capacity. This stalling usually occurs within a block or so after leaving the gas station. I then have to sit on the side of the road, or in the middle of the road and wait a few minutes before the engine will re-start. Lately, I have not filled the gas tank to its full capacity. I feel this is a real safety issue. I understand that this is a problem with the rollover valve on the top of the fuel tank and the only way to correct this issue is to have the fuel tank replaced.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Dodge Charger?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history