2016 Dodge Charger fuel system problems

Filed May 16, 2026 · Fuel system · SC

I am starting to smell fuel inside of my car everytime I fill up my vehicle.

Filed Sep 30, 2025 · Electrical, Engine · 97,000 miles · CO

The contact owns a 2016 Dodge Charger. The contact purchased the vehicle, and the vehicle was taken for the Emissions Test; however, the vehicle failed the Emissions Test. The contact notified the dealer and was informed that some unknown sensors had been replaced, and to allow for a week for the vehicle to adjust. The vehicle was taken to the dealer, and the vehicle failed to start. The vehicle was not diagnosed. The contact stopped by the dealer to pick up the vehicle. The vehicle was restarted, and the contact drove the vehicle to the residence. The contact stated that in the evening, the vehicle failed to restart. After several attempts, the vehicle restarted. The contact stated that on a separate occasion, while driving 40 MPH, there was white smoke coming from the rear of the vehicle. The contact stated that there was a plastic burning odor and an abnormal fuel odor entering the vehicle through the A/C vents. There was no warning light illuminated. The vehicle was taken to the dealer. The contact requested that the vehicle have a full inspection, and the dealer refused. The contact was informed that the spark plugs and fuel pump needed to be replaced. The vehicle remained at the dealer unrepaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 97,000.

Filed May 2, 2025 · Fuel system · VA

Smelled fuel leaking inside car towards rear seat. Electrical connector to fuel pump had fuel surrounding it (located under back seat, on left side of car). Upon disconnecting connector, I notice two right most pins of connector (on pump) had a burn mark which cause a hole and allowed fuel to leak out.

Filed Dec 4, 2024 · Electrical, Fuel system · TX

The car has had over 5 batteries in the last year and 3 in the last 2 months. Something is constantly draining the battery in my car and making them go very bad. Also the car will be dead if I park it too long because of the electrical issue and it’s been a huge problem for me.

Filed Aug 15, 2024 · Fuel system · AZ

My 2016 Charger has the same problem described in Emissions Recall UB4, Revision 5. When filling tank with gas, there is a very strong odor of gas. After about three days of driving, it dissipates. Revision 5 by added 2015 and 2016 Dodge Chargers, but I have been told that my vehicle is not included in that recall. It most certainly is a safety issue. Again, it has the exact problem as described in that recall. The gas smell is so strong, I cannot park it in the garage. I'm not sure if the federal safety agency issued the Revision 5, or Fiat Chrysler issued it.

Filed Nov 5, 2023 · Fuel system · FL

Fuel pump is inoperable due to cheap make(plastic). Leaks out at the top due to the lid and gas comes out thru there right underneath of where my children sit.

Filed Sep 2, 2023 · Engine, Fuel system · SC

Headlights go out when replacing. Fuel smell in cab. Engine ticking Front wheels knocking on bumps Inspection done by police Could cause major wreck all of the above

Filed May 10, 2023 · Body, Fuel system · MN

Car has strong smell of gas inside. Seeing by the other reports here that there is a regular problem with the fuel pump causing this issue. Is a safety hazard for obvious reasons. Drive shaft failed last year at less than 60,000 miles, but luckily had it replaced under dealership warranty. Others have not been so lucky, as I can see in these reports. Like tons of other reports here, door panels are also warping and disconnecting from the inside of the car. A completely cheap and poor design, and am shocked to see that nearly EVERY problem I've experienced with this car is COMMONLY experienced by other owners of this car. No idea how there haven't been more recalls, it's criminal that owners of this vehicle are left to foot the bill (THOUSANDS of $$$) for all of its defects.

Filed Oct 4, 2022 · Fuel system · NC

Strong smell of raw gas when fuel tank is 1/2 full(+). The smell is inside and outside the vehicle (mostly on driver's side near back door & wheel well) whether vehicle is running or not. The smell is just as strong outside as inside. When fuel level falls below 1/2 tank, the gas smell reduces. Removed rear seat, drivers side fuel tank cover have a crack in it. A puddle of gas was sitting on top of the fuel pump & a brown burn mark near the electrical plug. Google search: many complaints of fuel pump leakage. The fuel pump still works, it pumps/primes when the key is switched to the ACC position & the car cranks when pushed to turn on. The issue is fuel is leaking from the pump upward when tank is at or above 1/2 full. Tried to order new pump from local dealership (Northpoint Chrysler Dodge) who said it calls for a different part#, is out of stock with no expected date of availability, & is not available anywhere within their network. September 8th, went online to a site that provides OEM parts (World Parts Direct). They said the part was not available until September 23rd. Since they provided an availability date, I ordered the part & waited. The delivery arrived on the 29th. What arrived have a totally different part# with an electrical connector that must replace the factory connector. In order to install, the factory harness must be cut, spliced, soldered, & heat shrink a rubber sleeve to protect the soldered wires. I questioned the different part#, was told that is what their supplier sent, it is OEM, & should work. The new connector came with a diagram showing to switch the 2nd & 3rd pin from the factory connector into the new connector. The factory (+) & (-) pins are side-by-side, the new connector separates them. Fuel pump wiring is faulty, dangerous. Raw gas encountering electrical connectors is unsafe, can be explosive or deadly. Not inspected/repaired by dealer or mfg, no CEL, avail for inspection if needed. Let's not wait for someone to die for recall.

Filed Sep 23, 2022 · Fuel system · GA

Gas smells in the back seat of my car....where the pumps are underneath the seat. Gets older when fas tank is full