2001 Dodge Dakota suspension problems

Filed Dec 29, 2021 · Suspension · 300,000 miles · CA

The contact owns a 2001 Dodge Dakota. The contact stated while driving approximately 70 MPH, there was a wobble coming from the front passenger’s side tire. The contact was able to pull over and had the vehicle towed to a local mechanic to be diagnosed. The contact was informed that the ball joints needed to be replaced however, the vehicle was not repaired. There was no warning light illuminated. The manufacturer was not informed of the failure. The failure mileage was approximately 300,000.

Filed Jun 5, 2014 · Suspension · 73,647 miles · CA

Tl* the contact owns a 2001 dodge dakota. The contact stated that he was informed that the upper ball joint was worn. The independent mechanic informed the contact that the upper ball joints need to be replaced to repair the vehicle. The vehicle had not been repaired. The manufacturer was notified of the failure. The approximate failure mileage was 73,647.

Filed Sep 30, 2011 · Suspension · 50,000 miles · VA

I started noticing a "lurch or lateral shift" of the front end during tight left and right turns at low speed (35 MPH or less). Driving at highway speeds on straight roads did not indicate any problems. Recently, during a brake system inspection, significant "slop / free movement" at the upper ball joint & wheel knuckle assembly connection was noted (> 0.5"). I researched the problem and discovered the federal safety agency issued recall for "upper ball joint failures on 2000-2003 dodge dakotas" as well as the dodge issued tsb for the same defect. I took my 2001 dakota in to a dodge dealer for the recall repair. The dodge dealer and chrysler both conveniently took the position that my VIN was not part of this recall, therefore they were not responsible for making the repair. My vehicle has the same failure mode described in the federal safety agency recall and the dodge issued tsb. The federal safety agency should force dodge to expand the scope of VIN's covered by the recall to include all 2000-2003 dakotas that experience premature ball joint failures. A safety related suspension component should not fail at 50,000 miles. To arbitrarily exclude some vehicle VIN's from the recall even though they have the same defects is dishonest and not in the best interest of the traveling public. I urge the federal safety agency to force dodge/chrysler to repair this defect on all 2000-2003 dakotas.

Filed Aug 10, 2011 · Steering, Suspension · 169,000 miles · IL

Tl* the contact owns a 2001 dodge dakota. The contact stated that while reversing out of a parking lot, he heard a loud noise and was unable to move the vehicle. Upon inspecting the vehicle, the contact noticed that the front passenger side tie rod broke. The vehicle was towed home, where the tie rod and lower ball joints were replaced. The vehicle was not taken to an authorized dealer and the manufacturer was not made aware of the failure. The failure mileage was 169,000 and the current mileage was 170,000.

Filed May 12, 2011 · Suspension · 142,000 miles · KY

Tl* the contact owns a 2001 dodge dakota. The contact stated that the passenger side upper ball joints arm separated from the wheel. The vehicle was taken to a mechanic shop where the contact was awaiting repairs. The dealer was contacted who offered no assistance. The manufacturer was not made aware of the failure and the VIN was unavailable. The failure mileage was 140,000.

Filed May 14, 2010 · Suspension · 90,000 miles · MD

Tl* the contact owns a 2001 dodge dakota. The contact stated that he previously had repairs performed on the vehicle under the federal safety agency campaign id number 04v596000 (suspension, front control arm, upper ball joint). He was experiencing an abnormally loud squeaking and clanking sound while he was driving various speeds. The contact stated that the identical failure recurred after the recall repairs were made. The failure mileage was 90,000 and the current mileage was 94,000.

Filed Mar 14, 2008 · Suspension · 65,689 miles · CA

Tl*the contact owns a 2001 dodge dakota. While driving 2 MPH, the contact heard a banging noise coming from the passenger side front tire. He stated that the steering was difficult to turn. Upon inspecting the vehicle, he noticed that the passenger side front lower ball joints were disengaged. The mechanic stated that the cause of the failure was due to the lower ball joints not being lubed. In addition, the lower ball joints were rubbing against the upper ball joints. The mechanic replaced the front lower and upper ball joints. There had been no further occurrences. The failure mileage was 65,689 and current mileage was 66,471.

Filed Dec 15, 2007 · Brakes, Suspension · 64,000 miles · VA

I have a 2001 dakota quad cab 4x4 purchased new and the inside of the front rotors wear out extremely fast. They become damaged on the inside of the rotor appearing extremely rusted and as if maybe they overheated on the inside. 64,000 and this has happened 2 times. Dealers deny this is common , my brother has a 2002 (purchased new) and has had the same problem. Ball joints failed on both trucks , steering rack and rear differential leaks on both .

Filed Nov 22, 2007 · Suspension · 87,500 miles · WV

Ball joint problem on 4x2 dodge dakota. Popping grating sound and lack of control in the upper ball joint assemblies. These use the same upper ball joint assy. As the 4x4 units that have been recalled. These cause the same problems and dangerous safety issues.

Filed Mar 10, 2007 · Engine, Suspension · 55,000 miles · KY

I bought a 2001 dodge dakota 4wd a month ago. I have had to replace the lower ball joints, catalytic converter, timing chain, water pump and now the transfer case has gone bad. The truck only has 55000 miles on it. I have only made one payment on the truck and have paid the repair shop over $1500 in repair costs. They only time that I have got to drive the truck is to the repair shop except when I bought it. This is ridiculous, a truck with low miles like this should not have this many problems. The dealer said that they would look at it this time put they couldn't make any promises. We paid for everything else to get fixed and I refuse to pay for anything else. I paid $10,000 for a truck that I can't even drive, I'm actually scared to drive it because who knows what will happen next. Apparently dodges are pieces of crap to put it politely.