When refueling fuel shoots out of gas tank. Mechanism doesn't shut off when full. I consider this very dangerous. It originally occurred about 2 months after the mfgr warranty expired and no recall was made with this year model. Very frustrating as well. Occurs while sitting still next to gas pump, engine off.
2006 Dodge Durango fuel system complaints
Page 3 of 20: complaints 41 to 70 of 552, newest first, as owners wrote them.
The gasoline spews out at you before the gas tank is full. So if you are unaware, not paying attention, or just completely forget you end up in a bath of gasoline. So now possibly your shoes clothes and hands have gas on them. Hopefully you don't plan on lighting a cigarette afterward. (I don't smoke) but I do care not to wear gasoline or have to breathe the fumes in my really nice mopar. Super problematic for the owners afflicted with this problem I hope chrysler does the right thing and recalls the affected vehicles.
Tl* the contact owns a 2006 dodge durango. When attempting to refuel the vehicle, fuel spewed out. The failure recurred each time the contact attempted to refuel the vehicle. The vehicle was not diagnosed nor repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 95,000.
Gasoline overflows from filler neck when filling fuel tank. A considerable amount of gasoline overflows after gasoline pump shuts off.
Bought a used. 2006 dodge durango. First time wife filled tank fuel erupted from fill spout covering her head to foot in gas. Next week I tried filling tank. Again fuel spewed from the filler neck. The pump shuts off automatically then boom. 1/2 to 1 gallons of gasoline is on the ground, side of vehicle and myself. We can only put partial tanks of gas in at a time. As with all refueling trips the vehicle was parked, engine off, sitting beside the pump. The 2005 durangos were recalled. Why not this year also. Dealer claims warranty work was completed and will only look at vehicle if they charge a fee. This is a vehicle " checked out " by dealer before sale. Apparently they don't care about our safety or the hazard to the environment when close to a gallon in fuel gets dumped on the ground every time it's filled.
Upon filling the vehicle with fuel it will spit back a considerable amount of fuel after pumping has stopped full. Its amazing that a recall was issued for the 2005 durango for this problem and not the 2006. A quick google search shows the scale of the continued fueling problem on durangos. This problem has been occurring over the past 2 years at multiple gas stations.
Gasoline overflows from filler neck when filling fuel tank. A considerable amount of gasoline overflows after gasoline pump shuts off.
When refueling the vehicle and filling the tank to full or near full, when the fuel nozzle shuts off automatically, fuel will spray out of the filler neck all over the side of the vehicle and all over the ground and the driver. Approximately 1/3 to 1/2 gallon of fuel will be expelled from the tank. This started after I had about 75000 miles on the vehicle. It will happen every time I fill the car up. As a result I can only fill the tank about 3/4 full. The fuel has destroyed the paint on the side of the car. I have had to drive 20 miles home soaked in gasoline after this has happened. I'm glad no one flipped a cigarette in my direction!
Tl* the contact owns a 2006 dodge durango. The contact stated that when attempting to refuel the vehicle, the fuel was spewing out. The contact mentioned that he had to listen to when he thought the tank was going to be full to stop fueling. The failure recurred numerous times. The vehicle was taken to a dealer however the contact could not recall the diagnosis. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 67,000.
Each time I fill up my gas tank when the pump kicks off gas spills out of the tank onto the ground. The car was parked and off
Each time I fill up my gas tank when the pump kicks off gas spills out of the tank onto the ground. Dodge says they are aware of the problem but because my vehicle is listed as "restricted" in their data base they cant tell me exactly what restricted means only that it may have been classified as a total loss at some point. I purchased the vehicle used but had no issues registering it or insuring it in nj. Dodge says there is a lifetime warranty on this problem but because it is not a recall they refuse to make the repair for me because of my vehicles "restricted" status so I guess if I am refueling and gas spills out and catches the place on fire dodge wont care I would like to file a complaint this should be a recall and not just a warranty issue there is a significant chance of someone getting severely burned or killed if this spill happens near an ignition source. Please advise me of my next course of action.
Tl* the contact owns a 2006 dodge durango. While refueling the vehicle, fuel ejected out of the tank. The failure recurred on numerous occasions. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 69,000.
As I braked to park the durango, the engine abruptly stalled. Not sure why it stalled, but I know there was a problem with the 2004-2005 durangos where the engine would stall during sharp turns while braking.
When I fill the gas tank, the pump does not automatically shut off and gasoline spews all over the place. I just purchased this car less than a week ago and have had it happen every time I fill it up.
When I took my vehicle in for a recall I was informed that the right manifold studs were broken and the repair was going to cost $765.00. I took the vehicle into my regular mechanic to determine if I was being informed correctly. He advised that the chrysler dealer ship did not remove the heat shield to verify that this was actually the issue. The mechanic mentioned he could determine this by looking at the fasteners of the heat shield. The mechanic said that this happens a lot to chrysler products. He said that is why they did not need to remove the heat shield. When the studs are broken it allow the exhaust system to leak. My question is if this is a regular problem with chrysler why is there not a recall. I called chrysler to see what they would do about paying for a repair for a constant issue. They said there has not been many problems of this nature. Can this be investigated by having chrysler mail out s survey to actually determine if this is a material defect in their studs?
This durango had spewed gas during fill up ever since purchased 11/2006, so I just tried to be careful when filling. April 2012, I had some rust fixed around the rear wheel area on the gas tank side. Did not really think too much about it at the time. 1/29/14 I had an inlet check valve replaced at the dealership due to notification from chrysler and they said this could be a safety issue. Thought then that this defect is probably what caused my rust issue but I had had that fixed so did not think anything about it....until it started to rust again in the same area. This is a without a doubt caused by the faulty inlet check valve. I believe chrysler intentionally did not notify their clients until the 100,000 mile rust warranty was up. They will not stand behind the resulting damage from the faulty inlet check valve.
Tl* the contact owns a 2006 dodge durango. While operating the vehicle, the power train erroneously switched to the 4 wheel drive low position and the traction control and 4 wheel drive sensor lights illuminated. While stuck in the 4 wheel drive position, the vehicle became very difficult to steer and failed to accelerate normally. When refueling the vehicle, fuel would spew out of the filler neck. The cause of the failures was not diagnosed. The manufacturer was not notified of the failure. The failure mileage was 135,000.
When I fill up my gas tank, the gas does not stop flowing when the tank is full. The indicator does not work, therefore gas spills out onto the ground every time I fill up the tank.
I went to fuel up my car, when it reached full, fuel started spitting out of the tank. It has done this on numerous occasions.
From the time my vehicle was new I had issues with the gas nozzle clicking off but the gas coming back out of the tank. In the beginning it was a very little bit and I could stand there and monitor it and pump in slowly and it wouldn?t do it. It has steadily progressed to where every time I try and fill my tank the gas pump would click off but the gas gushes out onto me and the car and the pavement ? Anywhere from 2 to 5 cups of gas. The tank isn't even full when it does this. I have had it do it when I have only pumped 1 gallon into the tank and continue to click off every couple of cents. It takes at least 10 minutes to put gas in my tank and then it isn't full. It does this no matter what gas station I go to. I have had the tps replaced 3 times, the fuel pump twice......I can't help but feel that all of these problems are inter-related. My minor concern is that this will cause a medical emergency for me as I have acute asthma/breathing issues. This has caused asthma attacks that I have been able to control but my fear is one day I will not be able to control it. My major concern is the gushing out of fuel will eventually result in a fire at the gas station. I really cannot believe there has not been a recall issued as this was a problem with the 2005 durango's that a recall was issued (the federal safety agency campaign id #09v003000, the federal safety agency action #rq08005) - no one is working to protect the public after their obvious failure to correct the problem.
Tl* the contact owns a 2006 dodge durango. The contact stated that the fuel tank was defective and fuel spilled onto the ground when the fuel tank was filled to capacity. The failure was experienced several times. The vehicle was not taken to the dealer for diagnostic testing. The manufacturer was not made aware of the failure. The vehicle was not repaired. The failure mileage was 1,000.
I am constantly having to watch as I fill my tank on this car, because their is no way of knowing when the gas will spill out onto my car. The constant overflow has effected the paint near the gas tank as well as run under the body of this car. This is an issue which no one wants to address but I hope soon it will be resolved. It is a hazard to the owner and those who are near us when we attempt to fill our car.
This vehicle had a fuel overflow problem. Chrysler has a lifetime warranty on fixing this. The problem is that the gas that was continuously overflowing on fill-up has caused the vehicle to rust under the gas tank. Chrysler is saying this is not covered. Also on the lift gate under the silver piece above the handle there is rust forming from dripping on each side of this silver piece. I believe this is a manufacture defect, but chrysler is saying none of this is covered.
Everytime I fill up or come close to filling up the gas will come shooting out of the tank. It gets all over me, the vehicle and the ground. It can shoot as far as 4 or 5 feet away from the vehicle. I have stopped putting more than 1/2 a tank at a time in it but it is a huge inconvenience to have to stop for gas so much.
When gas tank gets full,gas spills out of the tank all ovdr car and person standing there. You have to fill tank very slowly. Car is rusting below gas cap from all the gas that has spilled there.
Every time I get gas the pump clicks off as full, then a bunch of gas comes gushing out and gets all over the car/ground/me. It has been happening for several years and it is not only a fire hazard, but also an environmental hazard.
This is definitely a public safety hazard. I bought my used dodge durango last october 2014. Every time I fill my gas tank up,the gas pump shuts off from a full tank of gas on my vehicle, then the gas comes gushing back out of the fuel neck of the durango's gas tank. There has been recalls on previous years but none on 2006. There are multiple people filing complaints but no recalls? This causes damage to the automobile paint, clothes, people and the environment. However, most concerning is the safety hazard of a potential fire or explosion from the overflowed gas and fumes happening around multiple cars, people and gas pumps at gas stations when 2006 dodge durango owners fill up their vehicles. This is not a problem caused by any owner. This is a mechanical defect in the dodge durango filler tube valve in the gas tanks. Please help to get this problem corrected by the dodge company.
I bought my dodge durango used in 2010 and everytime I fill my gas tank up and the gas pump shuts off from a full tank, the gas comes gushing out of the fuel neck. There has been recalls on previous years but none on 2006. Doesn't make any sense. There are multiple people filing complaints but no recalls? This causes damage to paint, clothes, people standing in the way without the knowledge it happens. Does it take an actual injury or fire before something is done? Its ridiculous and something needs to be done!!! I don't have the money to fix it and it is clearly a defect from the factory. Hopefully something is done so dodge owners can continue to love the cars they bought.
I purchased this 2006 durango used in 2012.from day 1, it has spewed fuel out when filling up. I have been soaked on a few occasions, and have had fuel sprayed in my eyes. I have seen prior years being recalled for the same reason, but not this model year. Please do something about this.
Every time I fill up, once the gas pump clicks off, gas spews from the fuel fill area.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Dodge Durango?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history