1997 Dodge Grand Caravan transmission problems

Filed Nov 26, 2019 · Engine, Fuel system · 104,233 miles · CA

Car suddenly lost power while driving on the freeway at 60mph; engine remained on. I pulled over, turned off the car, and it started back up again and drove fine for about 2 miles. 'service engine soon' light came on. When it lost power again, I slowed and then tried to reaccelerate, and it drove fine for about 5 miles, enough to get me off the freeway and to a safe location. I checked the oil and transmission levels, which were ok, and there was nothing leaking under the car. Went to an appointment, and came back to the car, which started up and drove ok for about a half mile, then it shut down completely at a traffic light. This time it wouldn't start back up again, so I pushed it onto a side street, where it started up fine and drove to the nearest gas/repair station. Now, the van won't start again. Van was proceeding straight in all situations.

Filed Jan 28, 2013 · Transmission · 126,321 miles · PA

Was driving the van about approx 35 MPH in a snow storm when it started to slide, I accelerated to keep from spinning out and the transmission let go..took it to the transmission shop that put it in and they said the spider gears were "welded" to the shaft and it caused the shaft to break..this is the second tranny we put in this van for the same thing. Manufacture defect..they should pay for the new tranny.. It cost me over $1950 to put this tranny in and it is a rebuild from advanced auto..they said its a manufacture rebuild..also, the switch for the headlights is very loose and you have to play with it and get it in a certain position to get the lights to stay on. You have to turn them all the way to the right then pull it out a little then it will stay on..

Filed Aug 31, 2010 · Transmission · 104,000 miles · PA

Tl* the contact owns a 1997 dodge grand caravan. The contact was changing the tire when he noticed that the rear axle was fractured and exhibited signs of rust. The vehicle was not repaired. The contact stated that the replacement parts were unattainable. The contact had not spoken with the manufacturer at the time of the complaint. The current mileage was approximately 107,000. The failure mileage was approximately 104,000.

Filed Aug 7, 2008 · Body, Electrical · 149,766 miles · NY

Tl*the contact owns a 1997 dodge grand caravan. Whenever the contact shifts, the vehicle makes an unfamiliar noise. When the vehicle is parked, it operates normally. The transmission stalls and will start back up, but it is unreliable. The vehicle would rev and have to be restarted in order for the revving to stop. If there is a power fluctuation, the rear wipers will turn on and off at random. The high beams on the headlights do not work, but the failure was repaired. The parking light on the front driver's side failed. He replaced the bulb, but it still does not work. The contact stated that he is constantly replacing the low beam lights. The serpentine belt slips off; however, it has been repaired. The check engine light flashes on and off and there is a burning electrical smell coming from the vehicle. The front strut assembly is rusting and rotting. The rocker panel on the driver's side is rusted completely. The current mileage was 186,000 and failure mileage was 149,766. Updated 09/10/08 *bf updated 09/11/08.

Filed Mar 11, 2008 · Transmission · 135,000 miles · OH

Twice in the last 6 years the transmission has had to be completely rebuilt in our 1997 dodge grand caravan due to failure. The first time, in 2002, occurred as the transmission permanently slipped out of gear. The second time, march 2008, the transmission would down-shift into first gear - at any speed and at any time. More often than not the transmission would shift out of gear before down-shifting causing the engine to race high. The van is not used for anything but passenger travel nor is it used for towing.

Filed Jan 22, 2008 · Transmission · GA

Tl*the contact owns a 1997 dodge grand caravan. After the contact parked and exited the vehicle, it began to roll forward. She managed to get inside the vehicle and depress the brake pedal before a crash occurred. The vehicle has not been taken to the dealer. The current and failure mileages were unknown.

Filed Oct 18, 2006 · Transmission · KY

Took off from stop light transmission failed had been slipping for a while before. Also shifted hard into gear. Already had the cooling system replace due to overheating problems at the cost of $1,000.00 no they say the transmission will cost about $2,000.00 to replace.

Filed Jul 21, 2006 · Engine, Steering · 135,995 miles · TX

Dt*: the contact stated that while driving at 30 MPH, the vehicle rpms dropped to zero, the vehicle jerked, and the engine stalled completely. The contact coasted the vehicle to the side of the road, and was able to restart the vehicle after 10 minutes. The vehicle has not been taken in for inspection. The consumer stated several attempts have been made to fix the vehicle. The oil pan was leaking oil. The valve cover gaskets were replaced. The transmission was heavily damaged and had to be replaced. The power steering pump was replaced. The front end of the vehicle pulled to the left. Updated 08/15/06.

Filed Mar 19, 2006 · Engine, Transmission · 24,006 miles · MD

I purchased the 1997 grand caravan in january 1998 at the marlow heights dealership in marlow heights, maryland. The first time I started experiencing issue with the vehicle was 5/1999 at 24,006 miles vehicle had little power when accelerating, transmission not engaging, transmission had to be reconditioned. In 12/1999, there was transmission fluid leaking inside of the vehicle on the driver's side causing a very strong nasty odor. Carpet had to be replaced. This caused a hazardous condition to my family especially my kids having to breath in this fluid. 3 /2000 same fluid leaked again in auto because of defective heating coil. Then again in 8/2001 the leak happened again. This time I contacted daimler chrysler in north carolina and complained daimler chrysler agreed to repair the vehicle under what they called one consumer repair per customer per vehicle. In 11/2001, the check engine light came on 3 times. At this point, the vehicle was also due for emissions testing and did not pass the test because of a cylinder misfire code. Once I was able to obtain the funds for repair, in 5/2004 @ 118,668 miles, I decided to take the vehicle back to the dealership for the repairs. I was told that I needed to have the spark plugs replaced and that would solve the issue. So I paid $114.24 to replace the 6 .spark plugs, problem not solved I ended up paying $3,758.82 in 7/2005 to replace cylinder heads, timing belt, and water pump . This was the second time I had the timing belt replaced. Recently, in 3/2006, oil light came on. Had to replace both vc gaskets, cam plugs, both ft cam seals and rear cam seals and timing belt once again for third time. This cost to me was $2,677.50. Now the oil light is back on again.

Filed Jul 14, 2005 · Brakes, Locks · 152,000 miles · MI

The 1997 dodge grand caravan front and rear brake pads and rotors wear out nearly every month. The vehicle begins to sway while driving 55mph on freeway or when changing lanes. The emergency brake light is on due to a leakage in the brakes. The egr valve keeps going out and the service engine light is on.