2003 Dodge Grand Caravan engine problems

Filed Mar 26, 2019 · Engine · 238,000 miles · WV

Tl* the contact owns a 2003 dodge grand caravan. While accelerating from a stop, the vehicle stalled without warning. The contact was able to coast the vehicle to the side of the road and powered off the engine. The vehicle failed to restart and was towed to the contact's residence. The vehicle was not taken to a dealer or an independent mechanic for diagnostic testing or repairs. The manufacturer was not contacted. The approximate failure mileage was 238,000.

Filed Aug 21, 2015 · Body, Engine · 120,000 miles · SC · crash

I was driving down the road slees limit was 45 I was doing 50 md a deer came out in front of me and I hit it head on thw whole front ends of my car is at my windshield. It was a very hard impact that brought me to a complete stop m y air bags dis not deploy as they should have with a impact like that

Filed Mar 14, 2015 · Acceleration, Engine · 175,000 miles · MO

Upon refueling the vehicle, vehicle stalls for a few seconds upon first acceleration. This has happened several times (about 1 out of every 4 refuels). Several times, the vehicle has stalled while pulling into traffic. Upon doing research, we have learned of many complaints already voiced about a faulty valve. For reference: http://www.autoblog.com/2014/09/10/dodge-grand-caravan-chrysler-town-and-country-stalling-the federal safety agency/ http://en.allexperts.com/q/chrysler-repair-807/f/stalling-refueling.htm http://ricksfreeautorepairadvice.com/engine-stalls-after-filling-tank-chrysler-minivan/.

Filed Sep 11, 2014 · Engine · 149,000 miles · PA

This problem has been happening for around 2 years now and it occurs when the van is near empty and I fill it with gas. When I start to drive away and pull onto the street, the engine chugs and jerks and acts like it will completely stop. There is no power to accelerate, and it is a terrifying and dangerous situation which will likely result in accident. If I let off the gas and go slow, it eventually stops chugging and jerking. This does not happen every time, but when it does, it is a frightening and extremely dangerous situation. Unless a solution is found, I expect that it will result in an accident.

Filed May 22, 2014 · Engine · 7,000 miles · CA

Tl* the contact owns a 2003 dodge caravan. The contact stated that while driving at low speeds, the vehicle stalled without warning. The contact stated that the computer module was replaced however, the failure was not rectified. The manufacturer was made aware of the failure. The failure mileage was 7,000 and the current mileage was 116,000.

Filed Mar 12, 2014 · Engine · 63,000 miles · NY

Tl* the contact owns a 2003 dodge grand caravan. The contact stated that the engine stalled without warning while driving 70 MPH. The contact was able to coast onto the emergency lane where the vehicle was towed to a local mechanic for further inspection. The failure was experienced several times. The vehicle was not repaired. The manufacturer was made aware of the failure. The VIN was not available. The failure mileage was 63,000. The current mileage was 98,000.

Filed Sep 11, 2012 · Acceleration, Electrical · 165,000 miles · VA

I have had so many major problems with my 2003 dodge grand caravan! I bought it used in 2008 w/ 68k miles. At that time the transmission had already been replaced. I had to replace the entire power steering system ($2000), auto window regulator, AC blower, tires, alternator belt, water pump, etc.the engine light has been on for some time now and mechanic says misfiring spark plugs. When serviced for problem(@ 170k miles) discovered original factory sp still in. Horrible corrosion/build up, had 2 fuel system flushes. Light on again. Newest & most dangerous problems,on multiple occasions now, van has completely turned off while driving, idling, and parked. It happens randomly and unexpectedly. More frequently while at lower speeds or parked but once while I was actually driving. When it cuts off the oil light remains illuminated. The car turns right back on. 5 times while driving 25-50mph has gone into cruise control by itself, and I loose control until it decides to give it back! Today, for the first time, after parking and turning car off myself, it would not restart. Ignition not responding, no noise, nothing. Tried to jump it and nothing, notices that lights and other electrical components not effected. Fortunately an observer also happened to be a mechanic, he took out the starter fuse and stuck some wires in the socket and had me turn the key, it started!!! He said that it seems there is an ignition communication problem, a.k.a. Computer problem. I have 4 kids that are always with me and this is our only vehicle. If the vehicle is dependent on the computer to function, then I have zero room for communication problems. I have reviewed all of the complaints for this make/model/year, there are multiple complaints that are similar if not identical to mine. I wonder how many complaints have to be filed before action is taken? Does someone have to die first?

Filed Dec 30, 2011 · Engine, Transmission · 48,280 miles · NY

Tubes carrying coolant to the rear heater rusted through, causing coolant to leak out of the system. Repair was not covered by extended warranty. Have spoken with other caravan owners that have had the same failure. Some were covered under warranty. Have read on numerous forums 1) about this same failure on multiple model years (1999 - 2005) 2) how the bracket material is different than the tube, thereby causing galvanic corrosion 3) how chrysler has since changed the material of the tubes to reduce the possibility of galvanic corrosion. The repair (tube replacement) is relatively expensive, but potentially more so if there is complete drainage of coolant, causing engine/transmission failure.

Filed Nov 2, 2011 · Engine · 98,000 miles · WI

Tl* the contact owns a 2003 dodge grand caravan. The contact stated that the vehicle stalled while driving 25 MPH. The vehicle would not restart until the contact added a small amount of fuel. The vehicle successfully restarted and was driven home where the failure recurred. The vehicle was then towed to an authorized dealer and the contact was informed that the engine speed circuit failed. The vehicle was not repaired. The manufacturer was made aware of the failure and offered no assistance. The failure mileage was 98,000.

Filed Mar 27, 2009 · Engine, Fuel system · 60,000 miles · TN · fire

Wife went to start car in morning. Loud explosion followed by smoke from engine compartment. She left vehicle. She smelled burnt plastic smell. I checked later and saw exploded intake manifold and hose on top of engine. Obvious explosion in engine intake area with enough force to blow manifold into pieces. Car is at dealer. They are waiting for new intake manifold to repair vehicle. Unconcerned about potential harm to driver/passengers of vehicle. This has potential for fire in engine compartment and vehicle and could be very dangerous situation.