The contact owns a 2013 Dodge Grand Caravan. The contact stated that while driving at an undisclosed speed, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle stalled. The contact was unable to pull over to the side of the road. No warning lights were illuminated. The vehicle was left on the side of the road. The contact returned and towed the vehicle to an independent mechanic who diagnosed that the fuel pump relay inside the Totally Integrated Power Module (TIPM-7) had failed. The vehicle was not repaired due to the cost. The vehicle was towed back to the residence and had not been driven since. The contact related the failure to the federal safety agency Campaign Number: 15V115000 (ELECTRICAL SYSTEM); however, the VIN was not included. The manufacturer was notified of the failure and confirmed that the VIN was not included in the recall. The failure mileage was approximately 190,000.
Dodge Grand Caravan fuel pump problems
321 of the 13,443 owner complaints about the Dodge Grand Caravan describe fuel pump failure, most of them for the 2011 model year.
- owner complaints
- 321
- worst model year
- 2011
- typical repair cost reported
- $1,100
- typical mileage
- 94,200
By model year
Often reported together
Stalling 97Won't start 77Battery drain 25Fuel leak 18Check engine light 18Fuel smell 12Loss of power 11Hesitation 10
Trouble codes mentioned
P0520 1P0456 1P0441 1P0175 1P0172 1P0128 1
What owners say
The fuel pump would run all night and going down the road the van would cut off...had it checked the tipm was bad
My van tipm went out..it would cut off going down the road the safety door locks was not working the fuel pump was running all the time with switch off
The vehicle randomly and dangerously stalls while driving at various speeds and locations. The vehicle will not restart until battery is disconnected and then reconnected. It then starts right up and runs fine until the next episode of stalling. This has been addressed by the federal safety agency campaign # 19V813 recall for bad fuel pump relay but my VIN # has not been included in this recall even though the vehicle is in the same year as the other vans covered under the recall. This is a very dangerous condition that keeps happening even after leaving the van with the Chrysler dealer for a week to diagnose and they say they don't have a definitive fix for it but offered to replace the entire TIPM for $1700 without a guarantee that the problem will be permanently fixed! The faulty fuel pump relay is well known and has been addressed with an external fuel pump relay kit covered by this recall. Please help us get our vehicle covered under this recall as we are retirees on a fixed income and have already spent too much money (close to $1000) trying to fix this known problem. Already replaced the ignition module which was another known possible cause but the problem still remains.
this is the fourth time i am filing a complaint. My 2013 dodge grand caravan completely dies and looses all power going over 50 miles per hour. no warning, no codes appear, nothing. looses all power, power steering, brakes, etc. have to get to side of road, wait 20 minutes, then car will start. this has happened now over 25 times. The latest time i was driving on the expressway and the vehicle behind me almost crashed into me. this continues to be a safety issue and it is unclear as to why dodge is doing nothing about this despite multiple complaints by hundreds of drivers. I have spent $3000 so far trying to fix this to no avail, new battery, fuel pump, fuel filter, TPM relay, new keys, new programming, still happens. case manager from 2023 told me to take to dodge dealer, spent additional $800, but they had no root cause. happened again. case manager told me to take to a different dodge dealer for second opinion. No codes, no root cause, but charged $400 diagnostic fee. When is Dodge going to do something about this? How many complaints are needed? does someone have to get injured? just tell me how to fix it, that is what i and thousands of others this happens to need to know before someone gets killed.
Car will crank but not start. Can cannot be started intermittently which could be dangerous considering location of vehicle, adverse weather conditions, etc. There are no warning lamps or messages related to the problem. This is a known problem with other Chrysler models and model years. TIMP fuel pump relay has failed. Bypassing the fuel pump relay will allow car to start. See attached file of Vertical Vissions' bypass solutions to this problem.
Driving down the road and my van cuts off. After leaving about 15 minutes it starts back up. I can go around 500 miles between cut offs. Had to 2 different garages with no solution. Replaced fuel pump, did not help. This is very dangerous especially on major highways.
While driving engine was cutting out, stalling, hard to restart. Found the reason was thr TIPM. Found there was a safety recall R09 / the federal safety agency 15V‑115 fuel pump Relay, however this was for other Fiat Chrysler models and not the Dodge Grand Caravan, please help me understand why? The TIPM within this caravan is the same TIPM installed is other Fiat Chrysler models and clearly the same danger concerns. I don't believe I need to tell the federal safety agency how scary it was to be driving 65 on a freeway when this occurred putting my life and others around me in danger of possibly losing control of a vehicle. Then learn this same TIPM was part of a large recall, but only on some models and not all. Makes absolutely no sense. I would ask that this prior recall be extended to all models with this TIPM installed as I can only imagine how many others have experienced this; God forbid and accidents were caused. Thank you for your time.
I have a problem with fuel pump circuit .it stays open and drain the battery after I shut the car off ,the problem with the fuel pump rely witch s integritated in the TIPM, to solve the problem I have to replace whole TIPM wich is cost $1070. All Dodge Grand Caravan model 2010 to model 2020 have same problem . Please liste this problem as a recall. Thanks for understanding.
this is the third time i am filing a complaint. My 2013 dodge grand caravan completely dies and looses all power going over 50 miles per hour. no warning, no codes appear, nothing. looses all power, power steering, brakes, etc. have to get to side of road, wait 20 minutes, then car will start. this has happened now over 16 times. The latest time with my grandchild in the car, the vehicle behind me almost crashed into me. this continues to be a safety issue and it is unclear as to why dodge is doing nothing about this despite multiple complaints by hundreds of drivers. I have spent over $3000 so far trying to fix this to no avail, new battery, fuel pump, fuel filter, TPM relay, new keys, new programming, still happens. will never buy another dodge/chrysler again, and have told family and friends the same potential hazard of this brand.
Related recalls
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- Vantage Mobility International, LLC (Vantage) is recalling certain Vantage-modified 2016-2019 Dodge Grand Caravan vehicles. The fuel pump gasket may deteriorate, allowing fuel to leak.
- Risk
- A fuel leak in the presence of an ignition source can increase the risk of a fire.
- Remedy
- Vantage will notify owners, and will provide parts and reimbursement to owners for repair facilities to replace the fuel tank gasket, free of charge. The recall began May 19, 2020. Owners may contact Vantage customer service at 1‑800‑488‑9082.
Recall number 20V278000 · Recall details
Fuel system, gasoline: storage: tank assembly
- What is wrong
- On certain mini vans, the fuel tank control valve weld joint could separate resulting in a possible fuel leak.
- Risk
- Fuel leakage in the presence of an ignition source can result in an underbody fire.
- Remedy
- Dealers will inspect the fuel tank and replace it if necessary. Owner notification began october 28, 2002. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1‑800‑853‑1403.
Recall number 02V274000 · Recall details
Fuel system, gasoline: fuel injection system
- What is wrong
- Vehicle description: mini vans built with 3.3l and 3.8l engines have fuel rails with nitrole rubber o-ring seals that can degrade over time. Fuel leakage from the underhood fuel injection fuel rail could result, increasing the likelihood of a vehicle fire.
- Risk
- Fuel leakage in the presence of an ignition source can result in a fire.
- Remedy
- Dealers will install a seal on the vehicle fuel rails to prevent external leakage of fuel from the fuel rail crossover tube, should the existing o-rings continue to degrade. Owner notification began on january 25, 2002. Due to the large quantity of vehicles involved in this campaign, the owner notification will be phased over the next several months. However, if a vehicle is leaking fuel from the o-rings, the vehicle should be taken into a dealer to have this repaired as soon as possible. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact daimlerchrysler at 1‑800‑853‑1403.
Recall number 00V268000 · Recall details
Fuel system, gasoline: delivery: fuel pump
- What is wrong
- Vehicle description: minivans. Fuel can leak from the fuel tank at the interface of the fuel pump module attachment.
- Risk
- If a fuel leak occurs in the presence of an ignition source, a fire could occur.
- Remedy
- Dealers will replace the fuel pump module attaching nut with a nut that includes tighter design tolerances. The sealing o-ring will also be replaced.
Recall number 99V216000 · Recall details
Fuel system, gasoline: storage: tank assembly: filler pipe and cap
- What is wrong
- A static electric charge can build up on the ungrounded metal section of the fuel filler tube.
- Risk
- This condition could cause a spark to occur when fueling the vehicle and possibly ignite the fuel vapors.
- Remedy
- Dealers will install a ground strap for the fuel filler tube.
Recall number 96V002000 · Recall details
Fuel system, gasoline: delivery: hoses, lines/piping, and fittings
- What is wrong
- The fuel tank rollover valve can allow fuel to pass into the vapor canister resulting in the potential for fuel leakage.
- Risk
- Fuel leakage increases the potential for a vehicle fire.
- Remedy
- Dealers will replace the fuel tank filler tube with a filler tube that has an additional rollover valve. The associated rollover valve vapor hoses will be rerouted.
Recall number 95V236000 · Recall details
Questions about the Dodge Grand Caravan fuel pump
Which Dodge Grand Caravan years have fuel pump failure problems?
The model years with the most reports are 2011 (129 complaints), 2012 (55 complaints) and 2013 (42 complaints).
How much does it cost to fix fuel pump failure on the Dodge Grand Caravan?
Owners who mentioned a price put the repair at about $1,100 (median of 59 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Dodge Grand Caravan?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history