2006 Dodge Magnum: engine stalls while driving

Filed Jan 30, 2025 · Brakes, Engine · CA

vehicle engine codes were all corrected properly in hopes of fixing the stalling issues. the vehicle was seemingly better for a few days. upon driving the vehicle on the highway at normal highway speed, the vehicle suddenly began flickering and shutting off and on. the vehicle would shut off and on rapidly. each time the vehicle turned back on it would accelerate causing the vehicle to jolt forward and stop rapidly. the car would not allow me to brake safely. the vehicle behind was within inches of a collision but their quick response to slam on their brakes and swerved to the shoulder thankfully missed. this is not an isolated event. speaking to other hemi 5.7 vehicle owners this is a very common issue. I had a baby in a carseat in the backseat who was jolted around slamming the back of his head into his car seat. this is so dangerously unsafe. not dealership can find the problem even after replacing every part possible on these vehicles.

Filed Sep 29, 2021 · Airbags, Engine · CA

The engine in my 2006 dodge Magnum has begun stalling out after fueling precisely as described in the federal safety agency action number PE13016. The first time it happened I was in the middle of a U-turn at a busy intersection. The engine died and I lost power steering and power brakes. I was able to brute-force the steering wheel and narrowly avoided hopping the curb and hitting the light pole on the corner. This light pole might have just as easily been a pedestrian. I called my local Dodge dealer (Ontario Dodge, Ontario California) to explain the problem and arrange to bring the car in. I let them know that I was aware that this issue was addressed under the federal safety agency action number PE13016 and should be covered under the lifetime warranty extension. I was told by the service adviser that I am required to drop off my car and that it would be 7-10 days before they would look at it. I suggested that they put me on a list and I could bring my car in 7-10 days at a time when they were able to look at it. They were unwilling to do this. They're insisting that my car sit in their lot for 7-10 days before they will even look at it. This isn't a scheduling issue. I can go on their website today and schedule my car for any other service tomorrow. No, this is a punitive action. Clearly they don't want to do the repairs and they're hoping I'll just go away by making it unreasonably difficult; not to mention expensive considering that a rental car will now be required. Chrysler and their dealers are not acting in good faith with regards to their agreement with the federal safety agency and PE13016. In my experience and opinion they're doing whatever they can to evade these repairs. I'm a little disappointed that a full recall wasn't ordered. The agreement the federal safety agency made with Chrysler left them with a little too much wiggle room in my opinion.

Filed Mar 11, 2021 · Engine, Fuel system · 128,000 miles · AZ

Tl* the contact owns a 2006 dodge magnum. The contact stated that when the fuel tank was full, the vehicle stalled without warning. The contact stated that at a half tank the failure was not experienced. The contact inspected the vehicle himself and found that the fuel tank was defective. The contact stated that the fuel tank integral multi-functional control valve failed to operate as designed. The vehicle was not repaired. The contact stated that the manufacturer provided tsb 14-002-14 regarding the engine stall following fuel tank fill up. The contact was made aware of the manufacturer's x53 lifetime warranty extension. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 128,000.

Filed Feb 13, 2021 · Fuel system · 76,233 miles · UT

Here we are 15 months later and only 2,330 miles from my last complaint about my 2006 dodge magnum stalling after a fuel fill up or when turning left, it happened yet again today, I know there is a current fuel tank recall for 2005 - 2006 dodge charger, magnum & chrysler 300's with the v8 5.7l & 6.1l, yet nothing for the v6 2.7l & 3.5l, why? They all use the same exact gas tank, which have been proven to be defective, I;m the original owner of this car and it still only have 76,233 miles, so it should be covered but is not, please expand this recall x53 to cover all magnums and chargers and chrysler 300s....we v6 owners should also have a voice in our own safety and recalls when our cars all use the same gas tanks

Filed Nov 22, 2019 · Engine, Fuel system · 73,460 miles · UT

I have owned this 2006 dodge magnum se v6 2.7l from new, bought in april 2006, the problem I'm having is with the car stalling, without any notice, happening today when turning left at a stop light and starting uphill. I was able to restart the car after pulling to the right without power, coming to a stop, putting the car in park, and restarting. I made it back home, but the car has been cranking over and not starting when in my garage, this after filling up with gas. I've had this issue happen before from 2006 onward to today, only a few times a year, and changed out the fuel pump relay each time and thought that was the problem, but the car has never stalled while driving before now, only when sitting at a light or stop sign after filling up the tank. The car only has 73,000 miles now after 13 years, I always baby the car and it still looks new. Thanks for any help with this matter

Filed Aug 30, 2019 · Fuel system · 40,000 miles · FL

Tl* the contact owns a 2006 dodge magnum. When the contact filled up the tank, he noticed that the top of the fuel tank was defective. The fuel tank top (the malfunction control valve) allowed fuel to leak into the purge line, which caused the engine to stall in traffic. Central florida chrysler dodge jeep ram (8675 commodity cir, orlando, fl 32819, (321) 445-8017) stated that the vehicle met the criteria for technical service bulletin: 14-002-14 issued on april 22, 2014; however, the VIN was not included and the contact was denied coverage for the repairs. The manufacturer stated that the coverage was excluded for the vehicle and referred the contact to the federal safety agency. The failure mileage was 40,000. *as *tr *pm consumer stated fuel tank failed 2nd time in june of 2019 at 112,000 miles and had a lifetime part warranty on it. Consumer stated the 1st recall has been honored.

Filed Jun 8, 2019 · Fuel system · 90,000 miles · FL

Takata recall vehicle stalls anytime . Loose power steering. Unable to steer it. Very dangerous. Dealer says there is a free replacement for fuel tank because of a defective vent. I never got a recall notice, apparently is just 2006 dodge/chrysler issue. And spend thousands on new computer and other service to find out the cause. Found the defective vent issue on line - confirmed with dealer I purchased it at that tank issue is covered. If there had been a recall for this dangerous issue, I would have had it fixed years ago. Vehicle is located in duluth, mn/superior, wi area now

Filed May 20, 2019 · Fuel system · 130,000 miles · ID

My dodge magnum stalls after filling up the fuel tank. It happens shortly after filling up and will continue until the car has been driven about 30 miles. It will stall regardless of what speed I am driving. It will restart after a couple tries.

Filed May 13, 2019 · Fuel system · 46,000 miles · WI

Car stalls unexpectedly immediately after a fuel fill up. Problem clears up within 10 minutes of continuous driving.

Filed Apr 8, 2019 · Fuel system · 109,545 miles · PA

I purchased a 2006 dodge magnum last week on 4/4/2019 odometer reading at 109, 545. 2 days after I purchased the car it needed fuel and I filled the gas tank. I then left the gas station. Within less than a mile the engine stalled as if it were trying to shut off. This happened 4 times within 1 minute and less than a mile from the gas station. Since I was merging onto a highway, I could not just pull over. I continued off the merge and into the highway. Then it stopped. With hesitation I continued down the highway. About 20 miles down the highway later and driving at the speed limit of 70 MPH, I accelerated on the gas pedal to go up a small hill and maintain the speed limit of 70 MPH. The car again tries to stall out and shut off and it continued to do this 3 more times. I had to drive yet another 50 miles to make it home and I was very uneasy the whole time. I did make it home without any additional insidents. The incident was very unsettling. I dread what happens the next time I put gas in it as this seemed to be the trigger of the incident. I went home to research the issue and sure enough this a common complaint among dodge magnum owners. Apparently there had been a recall for an issue with the gas tank. My VIN does not show up or qualify for the recall but is indeed having this shared problem. I feel it is a major safety issue for anyone on the highway. Causing serious injury and or death to myself, my passengers and any other drivers on the road. This issue needs to be resolved and addressed! Especially after finding there are so many other 2006 dodge magnum owners having the same problem! To replace the gas tank by a certified dodge mechanic it will cost about $2,000 in parts and labor. How do I get help with this recall issue even though the VIN on my car is not showing it is eligible or included in the recall??

Filed Oct 27, 2018 · Fuel system · 49,500 miles · VA

On several occasions, I have filled the fuel tank and when attempting to leave, the engine has stalled, sometimes in the parking lot of the gas station, other times attempting to stall but not cutting off, while driving on the road. I have been able to start the car when it has cut off in the parking lot, and if it stalled while driving, I have been able to keep it running by "feathering" the accelerator until it starts to run normally. I have read similar complaints about other owners with similar vehicles to mine, each having the 6.1l hemi engine or the 5.7 hemi. It appears that I may have the same problem, where the fuel shut-off float fails to perform properly. I read that the federal safety agency pe13016 was issued that relates to this problem. I cannot provide a specific date since I no longer fill the tank. (note that I haven't had the problem unless I have filled the tank. Months ago, I was able to fill the tank without experiencing the problem, but that was a while back. (I estimated the latest date in order to complete this form.)

Filed Aug 7, 2018 · Electrical, Engine · 95,000 miles · FL

On 07/06/2018 started engine, within 30 seconds car shut off . As if I turned off the key.restarted car and shifted to reverse to back out of drive, stalled. Started car ,put car in reverse transmission would not ingage 15 to 20 seconds later car went into gear and stalled 4 times before car would move without stalling. Two tenths of a mile car stalled pulling out on main road. Car started would not move waited for transmission to engage as traffic is is starting to line up. Mile later car stalls again everthing off start car and wait for transmission to go into gear. This happens ever day for the pass 2 months dodge dealer said my coils were bad had them changed next day same problem. Car now sits till something is done.dont feel safe driving on road. This happens moving and stationary