Dodge Magnum power steering loss problems

Filed Jan 29, 2026 · Fuel system · CA

My 2007 Dodge Magnum RT (5.7L Hemi) suffers from a dangerous engine stall immediately after refueling. The vehicle is equipped with the 19-Gallon Fuel Tank. When refueling, if the tank is filled to capacity, the engine stumbles and shuts off completely upon leaving the gas station. This stall occurs without warning in traffic, causing an immediate loss of power steering and power braking assistance, which creates a severe risk of a collision. This is the identical failure addressed in the federal safety agency Investigation PE13-016 and Chrysler Warranty Extension X53. The internal Multifunction Control Valve (MFCV) is defective; the float has swollen and remains stuck in the "open" position. This allows liquid fuel—not just vapor—to flood the EVAP system and the engine intake. I have already replaced the charcoal canister and purge valve, but the stalling persists, proving the defect is internal to the fuel tank assembly. Despite the 2007 models using the same defective tank design as the 2005-2006 models, Chrysler has excluded my year from the lifetime warranty extension. I am reporting this because it is a safety hazard.

Filed Jan 9, 2022 · Engine, Fuel system · OK

When vehicle has been filled up with gas it will intermittently die until it has around 50 miles on it. Usually sputters and dies without warning leaving you with no steering or brakes. Will restart but die until some fuel is ran out. I have scheduled to have the gas tank replaced but the fee is around $150

Filed Sep 29, 2021 · Airbags, Engine · CA

The engine in my 2006 dodge Magnum has begun stalling out after fueling precisely as described in the federal safety agency action number PE13016. The first time it happened I was in the middle of a U-turn at a busy intersection. The engine died and I lost power steering and power brakes. I was able to brute-force the steering wheel and narrowly avoided hopping the curb and hitting the light pole on the corner. This light pole might have just as easily been a pedestrian. I called my local Dodge dealer (Ontario Dodge, Ontario California) to explain the problem and arrange to bring the car in. I let them know that I was aware that this issue was addressed under the federal safety agency action number PE13016 and should be covered under the lifetime warranty extension. I was told by the service adviser that I am required to drop off my car and that it would be 7-10 days before they would look at it. I suggested that they put me on a list and I could bring my car in 7-10 days at a time when they were able to look at it. They were unwilling to do this. They're insisting that my car sit in their lot for 7-10 days before they will even look at it. This isn't a scheduling issue. I can go on their website today and schedule my car for any other service tomorrow. No, this is a punitive action. Clearly they don't want to do the repairs and they're hoping I'll just go away by making it unreasonably difficult; not to mention expensive considering that a rental car will now be required. Chrysler and their dealers are not acting in good faith with regards to their agreement with the federal safety agency and PE13016. In my experience and opinion they're doing whatever they can to evade these repairs. I'm a little disappointed that a full recall wasn't ordered. The agreement the federal safety agency made with Chrysler left them with a little too much wiggle room in my opinion.

Filed May 4, 2018 · Fuel system · 117,000 miles · NY

After filling up gas tank car will stall out. Big safety concern, car stalled while making a turn on city street, lose power steering very dangerous. Happens every time I fill up gas tank.

Filed Dec 2, 2017 · Engine · MD

Hello, in the last 6 months, every time I put gas in, whether I fill it up or not, weather I top it off or not, the engine will run erratically, often stalling multiple times for no reason. It has stalled on the highway, at highway speed, at any other speeds, and going through turns, needless to say, with no engine I have no power steering. I have the strength to keep the car under control, but a less experienced or less strong driver may loose control, possibly with serious consequences. After the car sits for a few hours, it will usually run ok. Thank you for your attention in this matter.

Filed Mar 31, 2015 · Fuel system, Steering · 48,566 miles · CA

After filling up the car with gas it stalls and you lose steering and brake control, very dangerous and my wife is now scared to drive the car. Stalling went away after an hour trying to get home. Next morning seemed to run fine. Next fill up did the same thing. This problem is going to cause deaths for sure if it has not already. Contacting the dealer asap to see if they have others with same issue.

Filed Jan 13, 2015 · Fuel system, Steering · 86,425 miles · NJ

Had filled up gas tank, upon pulling out experienced engine hesitation and lack of power. A few minutes later while passing though a major intersection with 3 children in car, vehicle stalled, causing loss of power steering and of course any means of propulsion. The vehicle started again but stalled three more times before returning home. This is an extremely hazardous situation which can endanger lives in a high speed and high traffic situation.

Filed Apr 2, 2014 · Steering · 60,100 miles · PA

I had a starter failure on my car, and was replacing starter myself, since I do most of my repairs, & to remove starter, the steering shaft has to removed for clearance. After taking the steering shaft from the steering box and examining it, I found rusted out section on the collapsing joint of the shaaft. It is completely rusted out half the diameter of the shaft. I went auto salvage yard & put another shaft on car. I live in pa, padot uses liquid deicing spray on highways & it has penetrated this part. If it had gone much longer, it would have broken completely off, with loss of steering and possibly crash. This only has 60,000+ miles. I didn't go to dealer for replacemet, but saved the defective part. I think there should be recall to check other vehicles for this before someone get in trouble.

Filed Feb 10, 2014 · Engine, Fuel system · 56,000 miles · CA

After filling my car and driving on the 710 freeway, while getting on the freeway the car just stalled. The steering got hard to turn as the vehicle was stalled. I managed to cruise to the side of the road and got the vehicle to start again. While driving it did it 2 more times until my gas started to go down. This happens almost every time I fill up the vehicle.

Filed Nov 6, 2012 · Fuel system, Transmission · 80,000 miles · WA

I had just filled the tank of my 2006 dodge magnum and drove about 20 miles into town. After making a quick stop at a local store I once again got into the car and began driving approx. 30 MPH. As I began to make a left hand turn all power was lost to the car; steering became nearly impossible, gas pedal did not work and I basically was dead in the road. I turned the key to off, placed the car in park and then restarted the engine. It started right up, began to drive and at the next light needed to take another left; with cars coming at me from the other direction I went to take the left when once again the entire car lost power..no steering, no gas power, check oil light came on. I was lucky that the oncoming cars did not hit me and that I had allowed enough space incase the same thing occurred or there would have been a collision for sure. This has happened a few other times without any reason but we are always able to start it back up and then it may or may not happen again. Been told it is the "roll over valve" failing $2 grand to fix!!!!!