1995 Dodge Neon fuel system problems

Filed Sep 30, 2011 · Fuel system · 142,000 miles · MN

I have owned several first generation (1995-1999) dodge and plymouth neons. Without exception, all of them have/had corrosion on the fuel filler pipe that was so bad that gasoline spilled on the ground when they were filled. I believe this is a safety hazard and is not, in my experience, normal.

Filed Apr 27, 2009 · Fuel system · 50,000 miles · CA

Gas tank leak (very slow and gradual). Noticed only while parked, left drops on garage floor. Car also had bad head gaskets, parking brake, and automatic transmission.

Filed Jun 18, 2008 · Body, Brakes · NJ

Peeling paint on my 1995 dodge neon. I am on my third transmission, replaced air conditioner because of smoke under hood, brakes, rotors, fuel leaking, valve cover gasket, head gasket, no oil in engine had it towed. I also in the time I own my neon I have had all kinds of problems. After replacing all this I only had one recall sent to me on the steering coupler. I had that fixed at the dealer. But, I haven't had any other recalls sent to me. 2 transmissions and alot of money spent on a lemon.

Filed Feb 12, 2007 · Fuel system · 150,000 miles · WI

Replaced rusted out fuel tank that leaked fuel after filling it more then half-full. Repaired rusted out fuel inlet tube ( leaked when filling fuel tank) fuel tanks was recycled and still using inlet tube.

Filed Aug 1, 2003 · Fuel system · NY

While pumping fuel consumer noticed that fuel was leaking from undrneath the vehicle. Dealer stated gas tank filler pipe was corroded.

Filed Jul 24, 2003 · Engine, Fuel system · HI

While traveling on the highway, the check engine light appeared on the dashboard, and the vehicle leaked gasoline underneath the vehicle. *ak *ts

Filed Jul 17, 2003 · Electrical, Engine · 74,000 miles · HI

Fuel pump (20a) fuse randomly blows. 30a fuses used and also randomly blow causing vehicle to stall. No indication of problem with fuel pump itself. O2 sensor and egr valve has been replaced. Mechanics have been unable to isolate the cause but have found different variations of circuit/wiring diagrams for this '95 neon sport model vehicle. Mechanics have also received varying advice from dodge dealerships on the cause and remedy. Result is safety hazard to vehicle driver and occupants if the system fails in traffic.

Filed Oct 29, 2002 · Fuel system · OH

Consumer stated that while driving at any speed and without warning the fuel filler neck is rusting. Dealer notified ts

Filed Oct 9, 2001 · Fuel system · MN

I discovered that the fuel tank filler pipe had corroded and separated from the fuel filler door assembly (pipe from fuel filler door to fuel tank). Fuel tank filler pipe was found loose and dangling within the right rear fender behind the right rear wheel. Fortunately, no apparent loss of gasoline was detected at the point of discovery. Contact the local chrysler/dodge service rep indicated that they had no knowledge of this type of safety defect and no recall on record. I am proceed with the repair of this safety defect at my own expense.

Filed Oct 9, 2001 · Acceleration, Engine · OK

Bleeder valve cap cracked, causing fuel to leak from the car. Occured 3 different times. Oil leak occurred from the head gasket. Erratic and difficulty when accelerating.