2003 Dodge RAM 2500 brakes problems

Filed Oct 18, 2017 · Brakes · 135,202 miles · PA

Abs and brake light remain on anytime my truck is running. Took it to a dodge dealer to fix the problem. Quoting from my bill..."replaced wheel speed sensor. Further diagnosis revealed corroded connection at ABS module. Need to replace ABS module connection and module. Customer declined repairs at this time/quote for $1200.00" I had already spent $191.90 for wheel speed sensor above. Dealer says the ABS problem is not showing as recalled for my truck's VIN. I have found a recall (d20 issued in september 2004) for corroded ABS connectors on 2003 dodge rams. Why is my 2003 ram not covered by this recall?

Filed May 12, 2017 · Acceleration, Brakes · 140,000 miles · TX · crash

Sudden loss of braking while approaching intersection; the brake pedal just went to the floor when applying approximately two hundred feet before intersection; applied emergency brake to effectively stop;speed was below 30 MPH when approaching intersection and brake loss occurred; truck has also had four "death wobble" experiences even with pittman arm and associated parts replacement; two experiences of sudden acceleration (possible jammed open throttle) of the turbo, leading to loss of control; sudden accelerations occurred shortly after cruise control usage and traveling less than 30 MPH; while stationary, vehicle has experienced wiring harness short and fire on firewall while connected to trailer. Pictures attached were taken within 12 hours of sudden loss of brakes.

Filed Jan 24, 2017 · Airbags, Brakes · AK

Tl* takata recall. The contact owns a 2003 dodge ram 2500. The contact received notification of the federal safety agency campaign numbers: 15v313000 (air bags) and 15v528000 (service brakes, air bags). The part was not available within a reasonable time frame to schedule the recall repair. The dealer did not give a specific date for when the part would become available. The contact was unable to determine when the vehicle would be repaired. The manufacturer could not provide an estimated date for when the contact's vehicle would receive the recall repair. The contact was not experiencing a failure. Vin tool confirms parts not available. Parts distribution disconnect.

Filed Jan 29, 2016 · Brakes, Steering · 303,549 miles · MO

Tl* the contact owns a 2003 dodge ram 2500. While driving 50 MPH, the power steering fluid leaked out and the steering wheel became difficult to turn and the brake pedal stiffened. The contact replaced the power steering pump seven times. The manufacturer was notified. The approximate failure mileage was 303,549. Updated 04/13/16*lj

Filed Aug 20, 2015 · Brakes · 105,000 miles · CT

All brake lines are rusted through causing a brake failure

Filed Nov 13, 2014 · Brakes, Fuel system · 93,000 miles · MN

The dodge ram 2500 truck has a cummins diesel engine with common rail fuel injection. March 2013 while on a trip pulling a trailer, the number 5 & 6 fuel injector lines were severely rusted / corroded which resulted in a bad fuel leak. I lost close to 30 gallons of diesel fuel in 40 miles driving distance. The under hood and underbody of the truck was coated in fuel. Vehicles behind me had some fuel spray as well. It was smoking bad behind me due to the fuel being on the exhaust system. I had a dodge dealer replace two of the six fuel injector lines. No choice. The dealer also cleaned the underbody. Once I returned home from the trip, I had a different dodge dealer replace the other four injector lines. If this was a gas engine, the truck would've burned to the ground. Now, november 2014, I see the brake lines from the master cylinder to the ABS brake controller are also severely rusted / corroded. They are not leaking yet. It is just a matter of time. I will have them replaced prior to taking any trips, and will have the brake system completely flushed too. Pulling a trailer with the truck and losing the brake system could prove to be fatal. The truck now has 96000 miles, and is always parked inside a garage. These lines should not have corroded so badly, even in minnesota.

Filed Jan 15, 2014 · Brakes, Steering · 77,391 miles · CA

Driving in the mountains on dirt road heard horrible sounds in the front of truck. Noticeably louder and very concerned to driving the truck any more, my two small children and I 9 months pregnant are very lucky. Made to our home 15 miles away. I called mechanic and truck was in the shop next day.

Filed Mar 1, 2013 · Brakes, Steering · 100,000 miles · NJ

Tl* the contact owns a 2003 dodge ram 2500. The contact stated that while driving various speeds and depressing the brakes, the vehicle would jerk to the right. The vehicle was taken to an independent mechanic where they advised the contact that they were unable to duplicate the failure. As a precaution, the brakes were replaced. The manufacturer was not contacted. The failure mileage was approximately 100,000. The current mileage was approximately 104,000. Updated 4/24/13 *cn the consumer stated the vehicle was repaired after replacing bushings, power steering gear box, and idler arms. Updated 06/4/2013 *js.

Filed Aug 12, 2012 · Brakes, Steering · 80,500 miles · CA

On a road trip I was driving on a highway at 65 MPH and I hit a small light decal that delineates the lines on the road and my truck began to shake violently and so severely that I nearly lost control. Braking did not stop the shaking, not accelerating until it slowed to about 35 MPH did stop the shaking. I pulled over immediately because I was terrified that it would happen again. Since I was in the middle of nowhere I decided that I would drive again but at a slower pace. This time I drove at 55 MPH and when it hit a tiny bump again it began to shake horribly again. And once again I was stressed beyond belief that I was barely able to control this truck. This continues to happen at high speeds and if there is any ruffness on the road. Please recall these trucks and fix them. I paid alot of money for a truck that I thought would be good quality and now I am stuck with a piece of junk that I cannot drive faster than 35 MPH for fear that I will kill myself or someone else. And I refuse to sell this lemon to some other poor soul.

Filed Feb 22, 2012 · Brakes, Steering · 250 miles · CA

The vehicle without warning shakes violently and the only way to stop it is to slow down. I hit the brakes a couple of times and that only made it worse and controlling the vehicle in a safe manner was impossible. The only way to stop the shaking is to take foot off of accelerator pedal and ride it out, this creates another major problem. The vehicles behind you do not know what is happening and someone almost rear ended me because my brake lights did not go on. He passed me and honked his horn at me and gave me the "finger" self explanatory. This is a major problem and dodge will not admit it to anyone.