Blend door will not work, common failure in models 02-06, poor design breaks after a year or so...cant defrost windshield when windshield frost due to snow or cold temperatures. Unable to remove foggy windshield on rainy days.
2003 Dodge RAM 2500 visibility complaints
Page 2 of 3: complaints 11 to 40 of 45, newest first, as owners wrote them.
Tl* the contact owns a 2003 dodge ram 2500. The contact stated that the defroster failed and he was unable to clear the windshield when it was cold or when the window would become foggy. The contact stated that the blend door caused the failure. The vehicle was not taken to the dealer for inspection or repairs. The failure mileage was 120,000 and the current mileage was 152,000.
Mix door fails to blow heated air up through defrost vents. Visibility is zero when it is below freezing and there is moisture in the air. It appears there is no recall for this even though it is an extreme safety hazard.
Tl* the contact owns a 2003 dodge ram 2500. The contact stated that when using the defroster, very little air was emitted from the vents and would not defrost the windows. The vehicle was taken to a dealer for diagnosis where they advised him that the defroster door failed and needed to be replaced. The vehicle was not repaired. The manufacturer was contacted and offered no assistance. The failure mileage was approximately 200,000. The current mileage was approximately 225,000. The VIN was unavailable.
The defroster will not activate-found tsb 24-004-03 relates to this issue. Chrysler should have recalled these vehicles for repair due to numerous number of failures and safety issue related to not having de-ice or defrost capability.
When I turn signal to left makes right signal comes on, when you turn right signal on makes left signal comes on. The lamp out light keeps coming on and going off when you turn the left signal on then off again. I checked none of the lamps are out. Has been took to dealer twice and had the wiring harness in the steering column fixed, it quit for a while and then starts the same thing again.the dealer claims using the tilt on the steering wheel is the cause of the problem. I think the problem is in the turn signal arm because it affects the signals and the wipers. I have talked to other dodge owners who are experiencing the same problems. I feel there should be a recall on it because it could turn into a safety issue.
Tl* the contact owns a 2003 dodge ram 2500. While attempting to use the heating system in the vehicle, the contact noticed that the switch which controlled the flow of the air would not function. The vehicle was taken to the dealer where the contact was informed that the blend door needed to be replaced. The vehicle was not repaired. The current mileage was 193,000 and the failure mileage was 120,000. Updated 05/11/12 *bf the consumer stated the dash was cracked. 05/21/12
I drive to work on a highway 5 days a week and started to have lots of vibration and it only occurred at higher speeds and would clunk. Turns out both u-joints for the rear drive-shaft had started to fail and were allowing unwanted movement. After replacing the u-joints the truck was fine for a few weeks then I heard squealing of metal on metal contact and there was a slight wobble. Took it to a shop and they said the hub bearings were shot and were moving so much as to allow the wheel to move. After replacing the bearings the truck was fine for about a month then the wobble was back and the tie-rods for the steering linkage were bad, so replaced the steering linkage with dodges new setup since it was hard to find the original one that came on mine since there is a recall on it. With the new steering linkage I got it aligned and it was good for a week and drove straight and no problems. Then I hit a pothole at 55mph while going to work and I got massive wobble in the steering so much so that the steering wheel was trying to go back and forth and I had to fight to keep it on the road and slow down enough to pull it over. I limped the truck to a shop and there was now lots of play in the steering and I could move the wheel 3+ inches before getting the wheel to move. The shop replaced the steering gearbox since the input shaft would move but the output would hardly move at all. Had it aligned again and it still can not be driven over 35+MPH or it gets massive wobble. Everything checks out with the steering components and tires since everything is almost new to try and solve this recurring problem, and I have spent $4578 in parts and labor to try and solve this never ending problem. The latest problem is that the HVAC does not work. It seems the doors controlling the temp are not working since the AC works sporadically,the defrost heats my feet, and windows stay foggy.
Tl* the contact owns a 2003 dodge ram 2500. The contact stated that the defroster was inoperable. Both the dealer and the manufacturer were notified of the failure, but denied any assistance with repairs to the vehicle. The vehicle was not repaired. The failure mileage was 34,000 and the current mileage was 44,000. The VIN was unavailable.
Tl* the contact owns a 2003 dodge ram 2500. While parked the contact noticed minimal air was emitting from the defroster vents. The contact stated there was a hinge that fractured on the blend door not allowing the air to come in contact with the windshield properly. The vehicle was not taken to the dealer for diagnostics and was not repaired. The approximate failure mileage 144,000.
Tl* the contact owns a 2003 dodge ram 2500. The contact stated that fluid was leaking out of his vehicle. The vehicle was taken to a local mechanic who diagnosed that the heater coil was defective and needed to be replaced. The contact mentioned that heater coil was replaced four times. The manufacturer was made aware of the failure and did not offer any assistance. The vehicle was not repaired. The failure mileage was 232,000 and the current mileage was 245,000.
Tl* the contact owns a 2003 dodge ram 2500. The contact stated that the defroster and heater door fractured and the contact was unable to use either component and the winshield would become extremely fogged whenever it would rain. The dealer was contacted who stated there were no recalls for the failure. The manufacturer was not contacted. The failure mileage was 130,000.
When I tried to switch the AC to defrost, it would not worked. Kept hearing a "thunk" from inside the dash. Defrost would not switch over and air continued blowing from vents. Created an extreme visibility impairment.
No heat or defrost on my 2003 dodge ram 2500. All air blows out dash. Problems defrosting windows and keeping clear. Was told by the dealer that it is not covered and would have to pay for it out of my pocket. At least $1000.
Defrosters will not come on when control knob is turned to defrost position. During my recent trip from one state to the next I had to drive through a snow/ ice storm and needed to defrost my windshield, I turned the knob to defrost but nothing came out it just continued to blow through the vents. I have been having this problem now and it is causing dangerous commutes for me.
I was driving down the road and turned on the heater in my truck and the windshield immediately fogged up to the point I could not see. I had to roll down the window to see out and to pull over to the side of the road to avoid a head on collision. Once I was stopped I noticed the problem was no matter what position I set the defrost or heat on, the air only blew out the vents on the dash panel. I went to the dodge dealer and they told me the whole dash had to come out of my truck, drain the cooling system and air conditioning system to replace some broken plastic parts, costing around 1,500.00 to 2,000.00. After researching this problem on line, I have found numerous people, all with the same problem. I feel this is a safety hazard because within 5 seconds my vision was completely obstructed and could have not only resulted in my death but that of someone else. This truck almost killed me once when it jumped into reverse and almost ran over me. Yes they ended up creating a recall for this problem, but that did not pay to repair my truck or my neighbors house that my truck ran into. I think it is unfair for us as consumers to continue to pay for dodge's flawed engineering. They have a tsb on this problem so they are completely aware of it.
Defroster and floor vents do not work. Heat and A/C only blows out of the dash vents. Took to dealer and was told that they get 2 to 3 in a month with the actuator door is broke and dodge has been made aware but no recall. I was told this is not a safety issue. Living in northern michigan in the middle of winter with no defrost is a safety issue. Hard to drive if you can't see. Cost will be between 1200 and 1500 dollars for something that should be recalled.
I can't defrost my windshield on my 2003 dodge truck. Last weekend when it started to rain, my windows fogged up and I had no defrosters to clear them. I almost caused a wreck on I-10 and finally had to pull into a rest stop until the rain stopped and the humidity dropped. The AC works good, just can't get air to the windshield. Dodge knows how to fix the problem, but says it's not a safety issue.
I'm a 3 time dodge owner currently have a 2003 ram 2500 slt hemi, 2004 ram 1500 short bed, 2005 durango hemi. Each one has problems. What I don't understand is how the federal safety agency and dodge don't see the safety danger involved. The 2003 has the most serious safety issues. A dash that is cracking so bad that pieces are now starting to fall out. If an accident were to occur this is a projectile hazard . I have taken pictures of the dash. I hope know one gets injured from projectile fragments of the dash. The more serious issue with the 2003 is the flapper door on the actuator motor that changes the air flow from vent to floor or defrost. Dodge does not see this as a safety issue. I don't see the difference between the defrost to the windshield not working and a windshield wiper recall; they both affect your view. We don't drive the pickup if ice and snow are in the forecast. I could not believe all the complaints about this issue and nothing is being done. Lets wait until one of these 2 issues injuries someone seriously or even sadder yet someone is killed!!!!! There is always a lawyer waiting. I would think any problem that affects your site or view for driving would be most dangerous.
2003 dodge ram pickup has defroster that will not work because air only blows out front vent. Unable to defrost ice while driving.
The defrost door and the blend door in my 2003 dodge ram 2500 is inoperative. It failed during the winter of 2007. The windshield will not clear thus causing an extreme hazard when attempting to drive the vehicle in inclement weather.I took the vehicle to the dealership in may 2008 and they admitted there was a problem and that there was a technical service bulletin but would not cover the repair due to being out of warranty. I agreed to pay for the repair. Upon them repairing it they discovered that all of the inside duct doors had failed and charged me to replace all of them. It has again broken and the dealer will not cover the repairs. I asked how it could fail again and they told me chrysler has not corrected the failed parts and are providing faulty parts for the repairs. I contacted chrysler and they declined any assistance. This is a serious safety hazard as the windshield and all other windows will fog over preventing visibility. I have searched the internet and have found this to be a large scale problem in these trucks. A safety recall should be done.
Tl*the contact owns a 2003 dodge 2500. The contact stated that the wiring harness failed and was repaired under warranty. On a separate occasion, the defroster and windshield wipers failed. While utilizing the driver's side turn signal, the passenger side turn signal would illuminate instead. This failure was also repaired under warranty. In addition, the contact was experiencing very hard vibrations form the front end of the vehicle. He struck a squirrel in the road and nearly lost control of the vehicle due to the vibrations. A local service dealer replaced the steering linkages in the vehicle at the contact's expense. He later received a recall notice for the suspension and excessive vibrations (steering linkages). The federal safety agency campaign id number was unknown. The current and failure mileages were less than 120,000.
It was snowing I had my three children in the truck the window fogged and when I put on the defrost it only came out the vents and did not clear the windshield I could not see as I was going down the highway and had to pull off the road. It was fixed once before in 2007 and did not last 6 months.
The switch on the climate control panel cannot change the air from the floor to the vents or defrost. The door in the air box does not move.
The heater/ defroster does not function properly. It results in no heat by my lower extremities and poor defrosting of windshield. I contacted the dealership and they informed me that I was not the only 2003 dodge ram 2500 to have this issue. I took it to another mechanic and he confirmed that I was not the first with this issue. I count ten including myself. I went to the manufacture and got a copy of a service bulletin detailing this issue, but no formal recall was ever issued. Chrysler refuses to do anything because they do not consider this a safety issue. I personally consider poor visibility from one's windshield due to faulty defroster a safety issue. No one has had a crash to my knowledge, but if a cop can write a citation for a minor chip, could they not do the same for a foggy windshield?
Tl*the contact owns a 2003 dodge ram 2500. While driving 35 MPH in the rain, the windows fogged up. The defogger switch and air conditioner would not switch over to defrost the windows. The contact went to the dealer and they stated that it was a damper door in the air vent, which tells the air whether to flow towards the door or the floor. If the door breaks, there is nowhere for the air to flow. Tsb number 24-004-03 was referenced. The dealer stated that this was an electrical failure, which only covered 12,000 miles; therefore, the contact has to pay for the repairs. The failure mileage was 45,130. Updated 11/12/08. *lj updated 11/14/08.
Tl*the contact owns a 2003 dodge ram 2500. The defroster and heat malfunctioned. The visibility through the windshield was limited. The defroster was on for 45 minutes and the windshield would not defrost. The dealer replaced the door that directs the air. The failure mileage was 70,000 and the current mileage was 72,000. Updated 02/14/08
Tl*the contact owns a 2003 dodge ram 2500. The contact stated that his vehicle would not start and the fans for the air conditioner were not working. After he adjusted the steering column, the air conditioner worked. The vehicle was taken to a local mechanic and they were unable to duplicate the failure. The failure remained and the contact had the vehicle towed to a local dealer. The dealer stated that the wiring circuits were burned, but they could not determine when the fire occurred. They refused to repair the vehicle for free because it exceeded the warranty. A complaint was filed with the manufacturer. The failure mileage was 69,000 and current mileage was 71,000. The consumer stated cuevas informed him the air/heat controls did not work in all positions. Updated 12/13/07
Blower dafters will not operate properly to defrost windshield in freezing temperatures or rain. Making it impossible to see while driving in this kind of weather.
When turning on defroster for my window it would not blow through.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2003 Dodge RAM 2500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history