H.v.a.c. Controls start to go out, then go out completely. The part that fails is the blend doors. This causes a loss of temperature control, directional, and or power control. When the h.v.a.c. Is not working correctly, the windshield and side windows can fog up obstructing the driver's view. The whole problem is due to a plastic part working against a metal part, that causes failure of the plastic tabs.
2006 Dodge RAM 2500 visibility complaints
Page 3 of 3: complaints 41 to 62 of 62, newest first, as owners wrote them.
Right side windshieled wiper motor arm stopped working at 73,000 miles.
2006 dodge ram 2500 heater will not switch to the defrost or the floor. Air only comes out the dash. Truck only has 40800 miles on it but dodge refuses to fix it unless I pay for it. I consider it a safety issue. After reviewing this problem on-line I see that this is a problem for the dodge line. They are not proud of their product. It has cost them a customer.
Failure of windshield wiper linkage caused loss of vision during heavy rain storm. This is obvious not an isolated incident. The dealers are selling the replacements as fast as they get them in. My dodge truck is only 4 years old and the linkage failed where the linkage arm is connect to the windshield wiper arm mount. The problem stems from a ball and socket design that requires an nylon bushing to hold the two parts together. The nylon bushing is failing prematurely (only 4 years.) since the replacement is the exact duplicate, we can expect it to also wear out (another 4 years) and create and instant driving hazard. This needs to be redesigned by dodge and replaced on all vehicles immediately before a serious accident happens. To keep replacing it with the same flawed design is absurd.
Cold weather causes ice to form on the inside and outside of the windshield and the heater control would not go to defrost. Had to stop in heavy traffic to scrape the inside and outside of windshield to remove ice. The air flow,blend door plastic actuator that is connected to the electric motor broke. The dealer told me it is very common and charged me 578.93 to fix the problem. I had no choice but to have them fix it because it was to dangerous to drive in the winter.
Tl* the contact owns a 2006 dodge ram 2500 mega cab. The contact stated that while driving at various speeds, the windshield wipers would only function on an intermittent basis when using during inclement weather. The vehicle was not inspected by a dealer nor was it repaired. The failure mileage was approximately 30,000.
Unbearable noise and vibration comes from dash area when A/C or heater fan switch is turned on to the high position. Took truck to the dealership and they diagnosed it as the "blend door" being broken. Truck just went out of warranty so dealer wants approx $700 to fix the problem. With the blend door not working properly, this will cause the windows to fog excessively in the winter as the blower can not be turned on high to clear them. Additionally, summertime driving here in the south gets extremely hot and the A/C system will not cool properly on the low setting. Researched the problem on the internet and found this to be a common problem in that year model truck as the blend door is not engineered properly. The problem was cured in the 2007 model.
Tl*the contact owns a 2006 dodge ram 2500. While driving approximately 70 MPH, the contact turned the air conditioner on and heard a loud vibrating noise from the instrument panel. The failure occurred whenever he turned the air conditioner on and was more pronounced when the blower was on the high setting. The vehicle was taken to an authorized dealer where the contact was informed that the blend door was broken. The vehicle had not been repaired. The failure mileage was approximately 35,000 and the current mileage was approximately 39,000.
A went in the defroster system that activates the fresh air or in cab circulation system failed at the pivot point. The door then fell over the fan at the bottom of the system which doesn't allow any air to flow out of any vent. I live near minneapolis , mn and this happened in august so there were no issues but if this had happened during the winter the defrost function would not have worked which is something that drivers in minnesota rely on every day in the winter to be able to see out the windshield.
Tl*the contact owns a 2006 dodge ram 2500. The contact was driving approximately 45 MPH when he engaged the left turn signal and the right turn signal illuminated instead. The failure would occur sporadically. In addition, the windshield wipers would fail intermittently. The vehicle was not taken for inspection or repairs. The failure and current mileage was 110,000.
1)the AC / heater motor starting making a loud vibrating sound and very little air was coming from the vents. 2). The recirculation door which is located above the fan (in the duct) broke and fell on top of the blower fan. This door controls weather outside air is used or the air is recirculated throughout the vehicle. As a result the AC/heater and most importantly the defroster would not work. An internet search of this problem reveals many different dodge years and models having the same problem. The part can be replaced by the dealership for a cost of approximately $700. The dash must be removed to replace the part. Most people (along with me) are removing the fan motor and simple removing the recirculation door altogether which is a cheap semi-fix. One blog website can be seen at http://autoforum.classifieds1000.com/dodge-1500_pickup/a_c_fan_noise_excessive_a_c_air_flow_reduced?pg=5. 3). The part has not been replaced, the dealer will not do anything outside of warranty. The defroster now works after removing the door, but the AC system is not working as designed. As a result of not being able to recirculate the air, my compressor clutch (which you have to replace the whole compressor) went out due to over working of the system. This is a major safety concern if the door breaks and falls on the motor. The fan can rub on the door which can get hot and catch the truck on fire and/or the defroster will not work and the windows can fog up causing an accident.
Turn signals do not blink properly, often times both come on at once. Windshield wipers suddenly go off during the middle of driving, which is not experienced very often due to it not raining very often, but it happens enough to scare me.
Outsider air door/flap in the A/C system on my 2006 dodge ram pickup is broken which prevents air flow to the cabin. I removed the broken door flap, but now am unable to shut off outside air flow. This is dangerous to my family's health since I am unable to prevent outside exhaust fumes from entering the inside of the truck. Apparently this is common on all dodge ram trucks in this make/model. Replacing the flap requires removing the entire dash and is very costly to have done by the dealer. Likewise, people have had it replaced multiple times and it continues to break. The design is very poor - made of plastic and the hinge can easily break. It needs to be redesigned and recalled by the dealer.
My wiper motor quit during a heavy rainstorm. I had cars honking behind me, I pulled over to the right lane and with my head out an open window, I used the lane lines to guide me. My mechanic told me that there were service bulletins for water intrusion into the windshield wiper motor assembly. Took it to the dealer, where he said there were no recalls on my 06 2500 ram pu truck. He said it would cost $234. Now they say it will cost $1200 as it involves the trucks computer system. Why is the recall (09v084000) only for 2008 and 2009 when the same part is in 2002-2009?
Tl*the contact owns a 2006 dodge ram 2500. The contacted stated that the heat, air conditioner and defrost system failed to operate. The windows became foggy causing limited visibility. The dealer stated that the hinge was broken. The technician was unable to repair the vehicle. The current mileage was 66,000. The failure mileage was 55,000.
I was traveling through the january west coast winter storms. I am not sure if the failure happened during this time but it became very apparent there was something wrong within the cab air distribution system. There was cold damp air that was entering from behind the glove box and could not be turned off. It became increasingly harder to keep the windows from becoming fogged creating poor driver visibility and hazardous driving conditions. After reaching our destination and talking with others that have like vehicles they referred me to a common problem with the distribution doors. A few internet searches and a trip to a local garage and sure enough at lease one of my doors had broken off. At this time the issue has not been resolved. I have contacted dodge and they indicated they were not aware of any problems. I requested written documentation for my records of my complaint that I felt this was unsafe and the level one contact told me was not authorized but would have a level two person contact me. The level two did contact me and told me to submit the request online and as of this date I have not got a response. I called on 2/8/2010 to see when I could expect the letter and they are now offering to have someone contact me to see what can be worked out. Still no answer as to when the response will come.
Tl* the contact owns a 2006 dodge ram 2500. While driving approximately 35 MPH the turn signals would not operate. He had to turn the turn signal switch off an then back on to operate the signals. Also the windshield wipers do not operate at the intended speed. The authorized dealer was notified of the malfunctions. The failure mileage was 40,400. The current mileage was 40,551.
2006 dodge 2500 truck. Has had intermittent problem with turn signals and wipers. Turn on signal and other signal comes on. Wipers go off with switch on. This has been issue since bought vehicle in 06. Does not do it all the time.
The multifunction switch (turn signal) is malfunctioning. I have heard many people state this same thing. The turn signals will activate opposite (trip the left and the right activates) and vice versa. The high beams will not turn off. And most recently I was in a rain storm and my windshield wipers which are activated by the same switch did not work. I had to stop on the side of the road and wait for the rain to stop before I could continue since I could not get them to activate. The multifunction switch appears to be a faulty part of my truck 2006 dodge ram 2500.
Tl*the contact owns a 2006 dodge ram 2500 megacab 4x4. The contact stated that the window began to crack in 13 degree weather. While rolling up the window, he noticed an inch long crack in the window. The dealer was unable to determine the cause of the failure. The contact ordered a new window for the vehicle. He feels that the vehicle is unsafe to drive because it could shatter while driving. The current and failure mileages were 57,000.
I purchased a $34,000.00 dodge 2500 diesel pickup around august of 06, 16 months later the heater defroster, and all heater controls as well as air conditioner controls stopped working. Chrysler knows of this problem, because they have sent out flyers to all their mechanics and have available a kit that is supposed to fix the problem. Without a defroster it's pretty nerve racking to drive this vehicle. But if chrysler can get out of the recall and charge the consumer $861.00 to fix their problem they are way ahead of the game. I have talked to many, many people with the same problem so its not an isolated situation. Chrysler will not even talk to you about the problem.
Intermittent climate control (HVAC) operation, poor air conditioning performance not cooling interior. After four attempts to fix a part has been on order from daimler chrysler since 07/14/06. The part has never arrived at the servicing dealership or do they know when it will arrive. The climate control system is non-operation and has no air movement from any vent on any setting. Two weeks I ago I had to drive the truck to work without the defroster working. I had to pull over several times to wipe the windshield with a towel so I could see to drive. A written complaint letter was sent to d.chrysler on 05/23/06 stating the problems I have had, no resolution so far. I have now gone over 30 days without a functioning climate control system. No help from d.chrysler or the three dealers that have worked on the truck. Vehicle: 2006 dodge ram/mega cab, VIN#[xxx]. *nm updated 07/12/2012 *js information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6)
VIN decoder
See the problems and recalls for an exact car
Buying a used 2006 Dodge RAM 2500?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history