2002 Dodge Ram Quad Cab transmission problems

Filed Jun 2, 2019 · Transmission · 180,000 miles · OK

Bought truck in 2009. Drive a couple times a week. Transmission has went out 5 times now including this morning. Was told by a coworker that theres ab issue with the dodgers not circulating fluid when idling in gear.??? Either way this will be the 5th time in 10 years taking it to get rebuilt!!!! Which has been 2,500.00 to 4,000.00 each time!!! Really bout to give up on dodge

Filed May 27, 2018 · Transmission · 203,695 miles · VA

Rear end locked up going down highway at approximately 45 MPH, sent me sliding into the slow lane and then off of the highway into a driveway coming to a halting stop with my tailgate was still partially in a heavily traveled highway. The driveshaft also dropped down and eventually came completely off and I had to call a roll back to come get truck. I have had this 2002 truck for the past 11 years and I have never been notified by dodage that this could be a major issue. All in all it has been a good truck. This incident really scared me, as I work out of this truck with my business and now I have to suffer a loss for not being able to work until I spend a good some of money to fix this issue so I am able to use it again.

Filed Aug 23, 2010 · Engine, Transmission · 85,000 miles · SC

2002 dodge ram 1500 quad cab has a surging problem at highway speed. The check engine light will come on and it is read as transmission fluid pressure sensor. This was replaced with a factory sensor and within 2 weeks it did it again. After 200 miles the light went out and the surging stopped only to start and stop repeatedly up to this date, 8/23/2010. How can a sensor repair itself? Impossible! Mileage at first check engine light was less than 100,000. Also dash is cracked to a completely unacceptable level for the age of the vehicle and mileage on dash at 138,000 with care taken to keep it clean and conditioned. Cracks began at 85,000 miles. Wipers when operating on high will lower speed and will continue to change from high to low intermittently unless they are turned off and turned back on several times. Do not consider this safe in any way. Intermittent wiper use with delay feature seems to be completely okay. Air conditioner will only blow cold air on driver's side and blows warm air on passenger side. After 45 minutes of A/C use, roaring sound issues from the vents and a gradual decrease in all air begins until only wisps of air escapes from driver side vents.

Filed Mar 5, 2007 · Transmission · 87,000 miles · NC

Tl*- the contact stated that while driving at about 60 MPH in the 2002 dodge ram 1500 quad cab the transmission locked. The truck disengaged from overdrive, and the overdrive light turned on. He pushed the button to engage the overdrive. He drove about one mile and the transmission light turned on. He had to drive another 1/2 mile to get to safe place. Once there he put the truck in neutral, set the emergency brake ,and he checked the transmission fluid. He stated that when he checked the transmission fluid it seemed that there was too much on the dip stick. He turned off the vehicle and let the vehicle sit for about five minutes, checked again., and the fluid was normal on the dip stick. When he restarted the vehicle all lights on dash seemed to be normal. He drove another 100 miles and the vehicle was fine. He stated that the next morning he drove to work and back home, and the next day the transmission slipped. The next day the over drive off light turned on and the vehicle lost power. Mhad to put the vehicle in first gear and drove to the dealership. The contact stated that this vehicle had 87,000 miles, and was informed him that something came loose in the transmission ,and that was what caused the transmission to seize. The contact called the manufacturer, and was told that maybe someone will get back with him at later date. The current mileage was 87879.

Filed Aug 8, 2006 · Brakes, Electrical · 88,000 miles · NH

At 65 MPH using cruise control, daytime, dry pavement, good weather, brake warning light and ABS warning light illuminated with warning chime. At next exit, operator took vehicle to repair shop. Technician found right front wheel bearing assembly worn, allowing tire/wheel assembly to be moved 1-2'' from vertical. Vehicle had been checked during state inspection less than 400 miles previously and passed. A total failure in traffic at speed might have resulted in a loss of handling/braking that might have caused or worsened an accident. Failed part is available. Vehicle has also suffered numerous premature failures including: failure of driver heated seat, failure of electric fuel pump, nearly causing accident due to engine stoppage and loss of power steering, failure of instrument cluster, failure of front suspension components, and damage to spare tire due to mis-routed tail pipe. Some of these are manufacturer design defects, others are troubleshooting or repair errors at dealer. Two events (fuel pump, wheel bearing) might have caused accident with injury/death possible outcome.

Filed Mar 27, 2006 · Transmission, Visibility · TX

While driving down the road at about 60 miles per hour or so I lost my overdrive and 3 rd gear of my transmission. Dodge dealer reports the valve body went out on my truck it had only been out of warranty by about 3000 miles. Dodge would not work wit me even thou they admitted to having some come it. So I had to have the valve body replaced. While sitting in the service area waiting for my truck to be fixed a customer came in to get a heater core for his 2002. Guess what less then a month after spending 1300.00 to get my transmission fixed the heater core went out on mine . Is this common or am I just the lucky one? As the heater core failed it did dump anti freeze in the cab of the truck and on the carpet. I have yet to have the heater core replaced.

Filed Aug 2, 2005 · Transmission · 68,300 miles · NC

I took my truck to have an oil change and 60,000 mile service at the dealer. I was told that the rear end needed to be overhauled because the brackets to my rear differential were broken, and if I did not have it repaired, the brackets would fall down into the spider gears and while I was driving, it would cause the truck to lock up. I took it to get another opinion and was told the same thing. I was also told that if they repaired it back to the way it was manufactured, I would continue to have the same problem. I went online to http://www.minerich.com/dodge_ram.htm and read numerous reports of people with the same problem and had to have it repaired more than once. The shop I took it to did not restore it to the way it was manufactured, but instead fixed the problem so that it would not happen again. This truck is only used to be driven back and forth to work.

Filed Sep 21, 2004 · Electrical, Steering · OH

Electrical - cannot charge a cell phone in any of the receptacles. Works in other vehicles. Transmission - changes gears very rough, somtimes on acceleration, all the time when decelerating. Steering - at times the steering does not want to work. Will not turn, very hard as if no rack and pinion. Truck slides out at times during turns, steering gets pulled.

Filed May 9, 2004 · Transmission · 27,008 miles · MS

Transmission goes into high gear too soon, causing too much downshifting when I need to speed up. It goes into o/d at 45 MPH. Very sluggish when I need to speed up unless I give it lots of throttle and then it drops out of overdirve and skips 4th gear and goes into 3rd. In town when you get up to 30 MPH the transmission pops like it is trying to downshifting straight to 1st.I have had it to the dealer 3 times with no results.*ak I feel they are trying to wear me out so I will quit coming back

Filed Mar 30, 2004 · Brakes, Electrical · 15,000 miles · CA

Excessive stoplamp failures, replaced lamps due to melting of base repeatedly,4th time in 8 mos. No service kit or upgrades available, check chevy, same tail light board set-up, same problems, perhaps they have a bulletin on problem?*ak severe shaking under braking, started at 15k miles, servicer refuses to cover under warranty (12k warranty), have found numerous issues with these rotors. Severe shaking on sweeping right hand freeway turns, presently scheduled for service at antioch/delta dodge. Engine intermittently stalling, unable to duplicate problem when in for service, not noted on service tickets. Independent front end leakage, presently scheduled for service at antioch/delta dodge. This my 3rd dodge truck since 1996, 1st one was great, 2nd had repeated rearend issues, 3rd seems to be having excessive issues across the spectrum of components, I would like help in resolving these issues, as presently I still view dodge as the leader in customer satisfaction.