Tl* the contact owns a 2005 fleetwood excursion. While driving various speeds, a foggy substance appeared in between the double panel window glass. The rv was not taken to the dealer. The rv was not diagnosed or repaired. The manufacturer was not contacted. The VIN was invalid. The failure mileage was 45,000.
The worst 2005 Fleetwood Excursion problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Visibility6
- Body2
- Engine2
- Electrical1
- Lights1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Visibility6
- Body2
- Engine2
- Electrical1
- Lights1
Recalls 2
Equipment: recreational vehicle/trailer
- What is wrong
- Fleetwood is recalling 70,101 my 2003-2007 southwind, pace arrow, bounder, flair, storm, fiesta, terra gas class a motor homes; bounder, discovery, providence, excursion, expedition, revolution, american eagle, american heritage, american tradition diesel class a motor homes; jamboree tioga class c motor homes; and prowler, wilderness, terry, mallard, pioneer, pride and triumph conventional and fifth wheel travel trailers equipped with a two-door refrigerators manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
- Risk
- If this solution is exposed to an ignition source under certain specific circumstances, it can result in a vehicle fire.
- Remedy
- Fleetwood is working with dometic to repair these refrigerators (please see 08e032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1‑888‑446‑5157 or fleetwood at 1‑800‑322‑8216.
Recall number 08V320000 · Recall details
Equipment: other: labels
- What is wrong
- Certain diesel class a motor homes fail to comply with the requirements of part 567, "certification." the manufacturers' tow hitch receiver information label was printed with the incorrect weight carrying capacity value and the incorrect tongue weight value.
- Risk
- The weight label on the hitch receiver provides the maximum trailer weight rating and the maximum tongue weight rating. It is important that these ratings not be exceeded. Failure to comply could result in damage to the motor home frame, body, or hitch receiver and could cause unstable driving and handling characteristrics which may result in a vehicle crash.
- Remedy
- Fleetwood will mail owners the correct tow hitch receiver weight information label. If owners do not feel comfortable installing the label, dealers will install the label for them. The recall began august 4, 2005. Owners may contact fleetwood at 800‑509‑3418.
Recall number 05V333000 · Recall details
See all 2 recalls for the 2005 Fleetwood Excursion
Defect investigations
Inadvertent slide-out extension movement
This investigation was opened based on odi's receipt of a congressional letter on behalf of a constituent.the constituent reported incidents where the slide out room of his motor home would inadvertently move (extend) during highway use.odi was concerned that a fully extended slide out would degrade the vehicle's dynamic handling characteristics and/or possibly impact an object or another vehicle, resulting in a crash.odi contacted fleetwood and discovered that slide out rooms were installed in motor homes, travel trailers and folding trailers. As part of the investigation odi visited a rv show and the fleetwood paxinos plant to examine slide outs in various new make and model vehicles and gain an understanding of how the systems work.during the investigation odi learned that there are two methods used to extend slide out rooms.some manufacturers use hydraulic systems and others, such as fleetwood, use an electric motor. (continued on page 2)
PE06005
Technical service bulletins for the 2005 Fleetwood Excursion 1
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
What 2005 Fleetwood Excursion owners say
Most recent owner complaints, unedited.
Most of the rv windows have fogged over and can't be cleaned as the fog/haze is inside the windows. The winshield is the only glass that is clear the driver side window is extremely fogged and interfers with viewing the outside rearview mirror. This condition can cause a very bad accident as you can't clearly see moving traffic on the drivers side. With the size of this vehicle, a serious accident could happen. Your attention is distracted as you try to see if you have moving traffic on the drivers side and while tryingmto see that side you end up taking your attention away from the winshield. This is a bad situation while driving on both highways, streets and avenues. This condition seems to be the norm for this year vehicle as I have meet other rv owners with the same window conditions.
Tl* the contact owns a 2005 fleetwood excursion. The contact stated that in between the double panel window glass, a foggy substance appeared. There were nine other windows that exhibited the substance. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 50,000.
Rv gas/electric refrigerator began leaking coolant gas (ammonia) into coach making occupants very ill and light headed. Gas seemed to almost ignite before area was opened to the access panel of cooling unit and vented. Coolant gas was open to lp gas heating element flame for possible uncontrolled ignition leading to possible fire to coach. Area extremely hot which suspects a small fire occurred. Refrigerator cooling unit had to be completely replaced.
I have a 2005 fleetwood excursion 39b and several windows, including the driver side, are fogging up. In fact, the driver side is so bad that I can barely see the left side mirror. This makes it extremely difficult and hazardous trying to pass or change to the left lane.
Tl*the contact owns a 2005 fleetwood excursion recreational vehicle. The defrost did not operate normally since the sealant on the windows failed to seal them properly. The failure caused his visibility to be impaired. No repairs were made. The manufacturer is longer in business. The failure and current mileages were 30000.
My 2005 fleetwood excursion has dual insulated glass that has fogged up. I have replaced one of the windows because it was dangerous to drive. It was the window that I look through to see my rear view mirror. The manufacturer won't replace it because it is no longer under warranty.
Improper installation of slide out seals on fleetwood excursion motor home. Warranty has since expired, but manufacturer refuses to pay for repair. Stated that it was my fault for not inspecting mounting screws, even though they cannot be seen from a normal viewpoint. Also claims it was neglect of care, yet I treat and lube slideout seals 3-4 times yearly. Improper installation has resulted in leaks/water damage to interior. Would like manufacturer to pay for seals and labor for replacing seals, I will pay for water damage repair.
The slider on a four slider motorhome will not come in many times. I drive alone, and my safety is at risk if I can't pull in the sliders and leave. Three to four people have to lift and push and jerk in the slider. I can not use this rv because of fear and the slider does not fully close. Four or 5 times to dealer, their statement, they have no clue. Also in aaa motorhome magazine this is a major problem, fleetwood is hiding from the public. I was stuck in mexico and montana away from all mechanical help, except those who we could gather up. Their offer to me fleetwood )) was to buy a new rv for $ 220000. The service writer,I overheard, this problem is un-solvable and told me it was not safe for me, he obviously didn't want me to tell anyone this.
Motor home had multiple safety related issues throughout 2005. -fire in awning motor inside motorhome -warped slide which could not be retracted and protruded from vehicle -constant frozen water components -leaks in ceiling which cause the roof integrity to be compromised causing an unsafe situation with multiple water incursions -no climate control for 5 months -constant electrical issues including rear light failure caused by wires melting on exhaust system -interior cabinets/shelves breaking loose while vehicle was in motion.
Compare the 2005 Fleetwood Excursion
Other model years
Questions about the 2005 Fleetwood Excursion
Is the 2005 Fleetwood Excursion reliable?
Owners have filed 10 complaints about the 2005 Fleetwood Excursion, 5.0 times a typical Excursion model year.
What is the most common problem with the 2005 Fleetwood Excursion?
Windows, wipers and visibility, with 6 complaints, typically around 38,000 miles. Next is body (2).
How many recalls does the 2005 Fleetwood Excursion have?
2 recalls, covering equipment.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Fleetwood Excursion?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history