Vech lost brake pedal went down to floor and over heated brake fluid causing melt down of sensors and bearings .while on highway.
The worst 2003 Fleetwood Flair problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
- Brakes1
- Lights1
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Brakes1
- Lights1
Recalls 6
Service brakes, air
- What is wrong
- Fleetwood is recalling 509 my 2001-2008 class a motor homes equipped with axles that include bosch zops or zoht pin slide hydraulic disc brakes. When combined with occasional or seasonal vehicle operation may experience calipers sticking in the applied position. This can result in abnormal heat generation at the wheel end causing brake drag. The driver would normally have warning of the brake drag if undetected by the driver.
- Risk
- The driver would normally detect the brake drag but if undetected the temperature increase at the wheel end can eventually lead to soft pedal conditions due to brake fluid boil, and possible extended stopping distance increasing the risk of a crash.
- Remedy
- Dealers will inspect and replace the necessary components free of charge. Workhorse is handling the remedy for this campaign please see 09v‑110. The manufacturer has not yet provided an owner notification schedule. Owners may contact workhorse at 1‑877‑246‑7731. Workhorse will conduct the owner and dealer notification.
Recall number 09V198000 · Recall details
Equipment: recreational vehicle/trailer
- What is wrong
- Fleetwood is recalling 70,101 my 2003-2007 southwind, pace arrow, bounder, flair, storm, fiesta, terra gas class a motor homes; bounder, discovery, providence, excursion, expedition, revolution, american eagle, american heritage, american tradition diesel class a motor homes; jamboree tioga class c motor homes; and prowler, wilderness, terry, mallard, pioneer, pride and triumph conventional and fifth wheel travel trailers equipped with a two-door refrigerators manufactured by the dometic corporation. The refrigerator may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
- Risk
- If this solution is exposed to an ignition source under certain specific circumstances, it can result in a vehicle fire.
- Remedy
- Fleetwood is working with dometic to repair these refrigerators (please see 08e032). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist the owner in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1‑888‑446‑5157 or fleetwood at 1‑800‑322‑8216.
Recall number 08V320000 · Recall details
Equipment: recreational vehicle/trailer
- What is wrong
- Certain motor homes and travel trailers equipped with a two-door refrigerator, manufactured by the dometic corporation, may have a defect in the boiler tube. Pressurized coolant solution could be released into an area where an ignition source (gas flame) is present.
- Risk
- Release of coolant under certain conditions could ignite and result in a fire.
- Remedy
- Fleetwood will be working with dometic in order to repair these refrigerators (please see 06e076). Dometic will repair these refrigerators by installing a secondary burn housing, a thermal fuse, and a melt fuse free of charge. Dometic has retained stericycle inc. To manage this campaign. Stericycle will assist you in locating dealerships or service centers and will provide assistance with scheduling of appointments. Owners may contact dometic/stericycle at 1‑888‑446‑5157 or fleetwood at 1‑800‑322‑8216.
Recall number 07V120000 · Recall details
Electrical system
- What is wrong
- Certain motor homes built on workhorse chassis and equipped with actia corporate instrument clusters fail to comply with the requirements of federal motor vehicle safety standard no. 101 "controls and displays" and no. 105 "hydraulic and electric brake systems." if the brake fail input falls below a voltage of 1.5v, the brake failure lamp and alarm will be activated. Also activation of the ABS telltale when the ABS is not properly functioning does not always occur.
- Risk
- At night the instrument cluster lights may fail and the driver may not be able to see the instrument panel gauges and the brake warning light indicator which could increasing the risk of a crash.
- Remedy
- Workhorse is conducting the owner notification and remedy for this campaign and reprogram the instrument panel cluster free of charge. Owners may contact workhorse at 1‑877‑246‑7731 or fleetwood at 1‑800‑322‑8216.
Recall number 06V115000 · Recall details
Trailer hitches
- What is wrong
- Certain motor homes equipped with draw tite hitch receivers may be missing one or more welds between the hitch receiver box and the bottom support plate.
- Risk
- The welds could break, allowing the hitch receiver box and the towed load to separate from the towing vehicle, increasing the risk of a crash.
- Remedy
- Dealers will inspect and replace the hitch receiver. The recall is expected to begin during august 2004. Owners should contact fleetwood at 1‑800‑322‑8216.
Recall number 04V352000 · Recall details
Equipment: recreational vehicle/trailer
- What is wrong
- On certain travel trailers equipped with samsung microwave ovens, these ovens were produced with a defective panel. An electrical short can occur between circuit patterns on the membrane panel, especially overlapped by a "jumper" or jump wire. This may cause the oven to activate without pressing any key pads.
- Risk
- An electrical short can occur causing the oven to activate without pressing any key pads. This could result in excessive heat, smoke, or possibly a fire.
- Remedy
- Samsung will notify customers and repair the panel free of charge. In the meantime, consumers should unplug their microwave, if possible. If the consumer is unable to unplug the microwave, they should leave the door ajar until the panel is replaced. Consumers should never use the microwave oven for storage or leave any towels, paper, cloth or other products in the microwave after use. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact samsung at 800‑932‑3837 or fleetwood at 1‑800‑629‑8454.
Recall number 03V452000 · Recall details
See all 6 recalls for the 2003 Fleetwood Flair
Defect investigations
Inadvertent slide-out extension movement
This investigation was opened based on odi's receipt of a congressional letter on behalf of a constituent.the constituent reported incidents where the slide out room of his motor home would inadvertently move (extend) during highway use.odi was concerned that a fully extended slide out would degrade the vehicle's dynamic handling characteristics and/or possibly impact an object or another vehicle, resulting in a crash.odi contacted fleetwood and discovered that slide out rooms were installed in motor homes, travel trailers and folding trailers. As part of the investigation odi visited a rv show and the fleetwood paxinos plant to examine slide outs in various new make and model vehicles and gain an understanding of how the systems work.during the investigation odi learned that there are two methods used to extend slide out rooms.some manufacturers use hydraulic systems and others, such as fleetwood, use an electric motor. (continued on page 2)
PE06005
What 2003 Fleetwood Flair owners say
Most recent owner complaints, unedited.
I presently own a 2003 flair motor home manufactured by fleetwood corporation on a ford chassis. Model: 33r serial: [xxx] vehicle id #: [xxx] chassis id#: [xxx] purchased : july 13 2003 the headlights are so glazed over that it makes it extremely dangerous to drive vehicle at night, neither the manufacturer of the motor home or the chassis maker will except responsibility for the headlights. It is my opinion that a two year old vehicle with 18000 miles should be able to have good headlights. *nm updated 07/19/2012 *js information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6)
The federal safety agency recall 03 e 044 000/samsung microwave ovens/ circuit short: owner unable to contact anyone from the 800 number (800/932-3837) provide on the recall notice. Unable to get information where recall can be repaired. Seeking help from the federal safety agency concerning this issue.
Compare the 2003 Fleetwood Flair
Other model years
19901991199219931994199519961997199819992000200120022003200420062015201620192020202120222024
Questions about the 2003 Fleetwood Flair
Is the 2003 Fleetwood Flair reliable?
Owners have filed 3 complaints about the 2003 Fleetwood Flair, 1.5 times a typical Flair model year.
What is the most common problem with the 2003 Fleetwood Flair?
Brakes, with 1 complaint. Next is lights (1).
How many recalls does the 2003 Fleetwood Flair have?
6 recalls, covering service brakes, air, equipment and electrical system.
Was there a recall on the 2003 Fleetwood Flair brakes?
Yes, 1 recall: 09V198000. Check your VIN to see if your car still needs the free repair.
VIN decoder
See the problems and recalls for an exact car
Buying a used 2003 Fleetwood Flair?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history