1997 Ford Aeromax technical service bulletins
77 technical service bulletins and manufacturer communications cover the 1997 Ford Aeromax.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Subject regarding vehicle lean correction procedure developed for diagnosing and correcting vehicle lean
- Information on 5R55E - 4R55E - 4R44E pump alignment tools
- Subject regarding vehicle lean correction procedure
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance...
- Ford motor company has released a private labeled material to be used for iron particle / acid rain...
- Procedures on repairing broken radiator coolant supply tank vent hose nipples
- Concerns with the front end accessory drive belt ( fead )-fead belt may wear and/or come off
- Some vehicles equipped with frame-mounted vertical muffler supports may exhibit a crack along the pipe bend
- Concerns regarding the instrument panel plate cracks at parking brake valve
- Ford motor company has released a new electrical grease ( F8AZ - 19G208-AA ) to reduce the possibility of...
- Some vehicles experience heater supply tubes that may crack and/ or leak coolant
- A new service parts released
- The lower radittor hose is being pulled off at the engine water pump on some vehicles
- A noise heard during driveline torque.
- Intermittent electrical issues, such as dash lights flashing when the turn signal is activated may occur...
- The power distribution box cover is now available
- Delco-remy has made available a revised generator for service
- Hinges and hinge springs are now available for service for the optional ready line access door, butterfly...
- Hard to move the hood up and down
- Front engine cover cracks
- Some vehicles with the caterpillar 3306 engine may exhibit the lower radiator hose being disconnected from...
- Information on tire company telephone numbers for customer assistance
- Information on availability of revised coolant level sensor
- Some models with cat C10/C12 engines may exhibit cracks in the engine front cover, near the fan hub pulley...
- The oil level indicator may be difficult to install and/or when installed may contact the crakshaft on...
- Condition with tires being lower than expected tire life
- Diagnostic informatin and wiring schematics for both the horton and kysor engine cooling fan clutches
- Service tips for surface defect removal without repainting
- Engineering is investigating conditions on the hood spring contacting the hood causing damage to the hood...
- Under certain conditions, road splash and spray may build up on the cab side windows
- Some vehicles fan clutch may cycle on when electrical accessories, such as turn signals, headlamps, etc
- The front end accessory drive (FEAD) belt may wear and/or come off on some vehicles equipped with a...
- Some electronically controlled diesel engines CAN be modified to increase engine output by altering the...
- Vehicles may exhibit rear engine support bracket attatching bolts loosening
- Vehicles equipped with cummins M-11 and N-14 select plus engines may exhibit the air operated cooling fan...
- Vehicles equipped with the fd 1460 engine may exhibit rear engine support bracket attaching bolts lossening
- The center support bar to the optional bug/dirt screen may crack at either end
- The vertical exhaust heat shield may exhibit cracking around its mounting bolt hole
- Sun visor- optional roof-mounted sun visor vibrates at highway speeds
- Wiring- wire harness ground- intermittent or open
- Hard starting- possible plugged catalytic converter/muffler (ccm)- vehicles built after 11/29/93 equipped...
- Engine- diesel- FD1060 and FD1460- white smoke from exhaust- service tip
- Front end accessory drive belt (fead)- fead belt may wear and/or come off- vehicles equipped with FD1460...
- A/c compressor drive belt or alternator drive belt rolling off drive pulleys
- Fead belt may or roll off - vehicles equipped with fd 1460 engine
- Vehicles equipped with hendrickson has suspension - may be difficult to maintain correct vehicle ride height
- Cooling system- engine cooling fan cracks at center hub
- Vehicles equipped with power steering and a bug/dirt screen - the screen may contact the power steering...
- Concern with lower roof air deflector support brackets
- Vehicles equipped with detroit diesel engines may experience a concern with engine warning lamps coming on...
- Fd 1060 engines - dipstick rubbing against crankshaft
- Inoperative horn or horn operates even though not pushed
- Air conditioning compressor belt may come off drive pully
- The dipstick rubbing against the engine crankshaft
- Vehicles equipped with the hendrickson air suspension, it may be difficult to maintain the correct vehicle...
- Tachometer inoperative
- Engine derate (reduction in engine-power) possibly intermittent- intermitten speedometer or speed control...
- The fuel shutoff solenoid on the P-7100 pump
- Diagnose the fuel shutoff solenoid on the P-7100 pump
- If one of the following symptoms is reproted on a vehicle equipped with an electronic engine please...
- Doors - battery access doors may come loose - new part availability - vehicles built through 9-96
- Dash mounted air valve assemblies, base part #4484, may leak air
- Vehicles equipped with the cummins electronic engine the tachometer may be inoperative or erratic
- Revised fan assemblies for premium diesel engines are now available
- Vehicles equipped with the cummins electronic engine the tachometer may be inopeative or erratic
- Noise- air leak from behind instrument- panel- vehicles built through 10/21/96
- Wiring - electrical diode identification and service replacements
- Hood grille opening panel - crack at top left and right corners - vehicles built from 11/1/95 through 4/1/96
- Replacement leveling valve extention rod for hendrickson air-ride suspension
- Tachometer inoperative
- Step plate - fuel tank step plate vibrates - vehicles built through 10/1/96 equipped with 70 and/or 120...
- Information when troubleshooting the speedometer & tachometer
- Battery access panel may become loose
- Coolant temp gauge may read on the high or hot side of normal, caused by location of coolant temp sensor
- Information on troubleshooting the speedometer & tachometer
- Procedure for air suspension light on
VIN decoder
See the problems and recalls for an exact car
Buying a used 1997 Ford Aeromax?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history