1994 Ford Aerostar recalls
There are 3 safety recalls on record for the 1994 Ford Aerostar, covering 860,298 vehicles in total across all the models in each campaign. Newest first.
All recalls
Electrical system: wiring: front underhood
- What is wrong
- Vehicle description: mini vans. Heat generation in the wiring harness to the fuel pump/sender assembly can cause an electrical short. The vehicle could experience a loss of power and become immobilized and the fuel gauge may be erratic.
- Risk
- Heat damage, including melting or charring of the fuel pump and sender assembly wire harness and associated wiring harnesses can also result. The short circuit could also have the potential for a vehicle fire.
- Remedy
- Dealers will install a fused jumper harness in the fuel pump ground circuit that will be installed at the fuel pump inertia shut-off switch.
Recall number 99V028000 · Recall details
Electrical system: ignition: switch
- What is wrong
- Vehicle description: mini vans. These vehicles were produced with a higher than specified electrical load through the accessory power feed circuit. The potential for contact between the b2 (battery), a2 (accessory), and p1 (proof) circuits can occur, creating a short circuit, allowing current to flow through the ground wire.
- Risk
- This can cause over heating and the potential for a vehicle fire.
- Remedy
- Dealers will install a jumper harness with a relay which will re-route and activate all a2 accessories through the relay.
Recall number 99V029000 · Recall details
Power train: transfer case (4-wheel drive)
- What is wrong
- Vehicle description: all wheel drive passenger minivans. These vehicles can develop powertrain bending resonance or transfer case output shaft bushing displacement. The powertrain bending resonance or the output shaft bushing displacement can result in structural failure of the transmission and/or transfer case. Fluid explusion, driveshaft separation or loss of vehicle drive can result.
- Risk
- This condition can cause a loss of vehicle control, and, if the expelled fluid contacts the exhaust system, a vehicle fire could occur.
- Remedy
- Dealers will install a new transfer case rear output shaft bushing and an aluminum driveshaft will be installed.
Recall number 97V204000 · Recall details
Questions about the 1994 Ford Aerostar recalls
How do I check if my 1994 Ford Aerostar has an open recall?
Enter your VIN in the VIN decoder on this page to see the recalls for your exact model and year, then confirm with any dealer of the brand or the manufacturer, who can tell you whether the repair was already done on your car.
Do I have to pay for a recall repair?
No. Safety recall repairs are free at any authorized dealer of the brand, even if the car is out of warranty or you are not the first owner.
How many recalls does the 1994 Ford Aerostar have?
3, covering electrical system and power train.
VIN decoder
See the problems and recalls for an exact car
Buying a used 1994 Ford Aerostar?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history