I found two incomplete recalls. I called the dealer 9/28/2020 at [xxx] and spoke to [xxx]. She put the VIN in her system, saw the two recalls and said the parts would be ordered. No response. I call [xxx] 10/5/2020 at the same number and she said about the same thing. Then I called 10/8/2020 and another service advisor printed out the issue with my phone number [xxx] and said [xxx] would call me after lunch. No response. I tried calling the ford customer service 800 392-3673 and after pressing '#' for two commercials, the recorder hung up. The vehicle has been running fine, but these are two recalls that are concerns. (00s56 & 99s02). Thank you very much. [xxx]augusta, ga information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6).
1997 Ford Aerostar electrical problems
13 complaints (21% of all complaints for this car).
- owner complaints
- 13
- of this car's complaints
- 21%
- crashes
- 0
- recalls
- 1
Which part fails
- Ignition: switch7
- Wiring: interior/under dash2
- Wiring: fuses and circuit breakers2
- Wiring: front underhood1
- Starter assembly: relay1
- Ignition: module1
- Ignition1
- 12v/24v/48v battery1
At what mileage
Complaints by mileage at the time of the problem.
Ford Aerostar electrical problems in other years
Related recalls
Electrical system: ignition: switch
- What is wrong
- Vehicle description: mini vans. These vehicles were produced with a higher than specified electrical load through the accessory power feed circuit. The potential for contact between the b2 (battery), a2 (accessory), and p1 (proof) circuits can occur, creating a short circuit, allowing current to flow through the ground wire.
- Risk
- This can cause over heating and the potential for a vehicle fire.
- Remedy
- Dealers will install a jumper harness with a relay which will re-route and activate all a2 accessories through the relay.
Recall number 99V029000 · Recall details
What 1997 Ford Aerostar owners say
Most recent owner complaints, unedited.
Need to know were to start to get all the problems on my van taken care of all the recalls, of power train the electrical and whatever else was reported to me on my report of the recalls on this 1997 areostar van thank you maryjean.
My 1997 ford aero star van produced a puff of smoke from the steering column near the ignition switch. I took it to my mechanic whom checked the recall notices and found one resulting in an electrical overload short circuit and overheating in the steering column electrical components. When the key was turned off it subsides. Since this occurrence the instrument panel has not worked and blew all fuses, the fuel pump does not turn on with the key after multiple attempts it engages some times. The ford dealer did the recall work but did not fix or examine the steering column or the components that burned or over heated as a result of the overload. [xxx] updated 07/19/2012 *js information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6)
Consumer is able to turn igintion and start vehicle without key in it, causing a saftey hazard.
Intermittent discharge of battery, contact dealer cant find proplem, ford have 3 service bulletins out on problem,happens on vehicles build before certain time.
The electrical system involving the horn continually fails. The horn regulary goes off while the vehicle is not running. I have replaced both horns, the low and high frequency. I have replaced the horn relay. With each replacement, the horn burns out because it is operated for extended periods because it is set off by something in the system. This usually occurs at night.
Key is stuck in the ignition switch.consumer contacted dealer.
Vehicle denied recall work due to lack of parts (99v‑029) ignition switch. Mjs
Consumer has contacted the dealer 4 times regarding recall 99v029000, ignition switch short. Dealer informed consumer that parts were not available.
Consumer is not satisfied with recall repair policy, when repair was made. (99s02)
Questions about the 1997 Ford Aerostar electrical
Does the 1997 Ford Aerostar have electrical problems?
Owners have filed 13 complaints about the electrical of the 1997 Ford Aerostar, 21% of all its complaints, more than any other problem.
At what mileage do 1997 Ford Aerostar electrical problems start?
Not enough complaints include the mileage to tell.
Was there a recall on the 1997 Ford Aerostar electrical?
Yes, 1 recall: 99V029000. Check your VIN to see if your car still needs the free repair.
What year does the Ford Aerostar have the most electrical problems?
The Ford Aerostar model years with the most electrical complaints are 1993 (99 complaints), 1994 (69 complaints) and 1991 (67 complaints).
Other 1997 Ford Aerostar problems
Acceleration 9Transmission 9Brakes 7Wheels 7Airbags 4Fuel system 4Suspension 4Engine 3Locks 3Seat belts 2Steering 2Tires 2Body 1Lights 1Visibility 1
VIN decoder
See the problems and recalls for an exact car
Buying a used 1997 Ford Aerostar?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history