1994 Ford B Series technical service bulletins
44 technical service bulletins and manufacturer communications cover the 1994 Ford B Series.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Engine or fuel system concerns when using fuel with greater than 5% biodiesel concentration. tt
- Subject regarding vehicle lean correction procedure developed for diagnosing and correcting vehicle lean
- Subject on a wire harness terminal repair kit available for repairing electrical wiring harnesses
- Subject regarding vehicle lean correction procedure
- Information on identifying non-approved / alternate refrigerants which could cause safety, and performance...
- Vehicles equipped with FD1060 or FD1460 midrange diesel engines may experience a vibration or buzz through...
- Ford motor company has released a new electrical grease ( F8AZ - 19G208-AA ) to reduce the possibility of...
- Information on tire company telephone numbers for customer assistance
- The coolant temperature gauge reading may be inaccurate
- The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable
- New throttle cable to reduce vibration atthe accelerator pedal
- Fuel injection pump- bosch- service information for FD1060/1460 diesel engines
- Hard starting- possible plugged catalytic converter/muffler (ccm)- vehicles built after 11/29/93 equipped...
- Engine- diesel- FD1060 and FD1460- white smoke from exhaust- service tip
- Fead belt- high wear and/or comes off of the drive pulley- vehicles built from 4/1/92 through 6/1/96 with...
- Fd 1060 engines - new design starter motor to alleviate hard start/no start concerns in cold ambients
- No start- starter will not turn engine over- vehicles with FD1060 engine
- The fuel shutoff solenoid on the P-7100 pump
- Diagnose the fuel shutoff solenoid on the P-7100 pump
- Suspension - noise from front spring rear hanger - revised rear spring hanger insulator pad - vehicles...
- Heater- lack of heat in passenger compartment- vehicles equipped with FD1060 engine- cooling system-...
- Engine- FD1060 or FD1460- high vibration at low engine RPM- vibration- high- at low engine RPM- vehicles...
- Fead belt - high wear and/or comes off the drive pulley - vehicles built from 4/1/92 through 9/1/96 with...
- Wiring - electrical diode identification and service replacements
- Many manual transmissions that are replaced/repaired under warranty and returned to the wprc show signs of...
- New fuel hose to replace the hose used in the low pressure fuel return system - the current hose may show...
- Starter - starter does not engage and/or starter may cycle (engage-disengage-engage) while cranking -...
- Subject regarding the stoplamp diode location and replacement procedure on vehicles built since 12/90 with...
- On f/b series w/ fd 1060 engine there may be a concern regarding insuffi- cient in-cab heat
- Hard starting or a no start concern may occur on some vehicles
- The engine coolant temp gauge may read on the cold side of the normal range, or may stay below normal even...
- The use of petroleum-based grease as a lubricant in servicing disc brakes is no longer acceptable because...
- Stall or no start - fuel shutdown solenoid - wiring chafing on fuel injector lines-vehicles built before...
- Unknown
- New service kit for retaining the diesel engine plastic air cleaner
- New catalytic converters for diesel engines FD1060 and FD1460
- Battery covers for outboard frame-mounted batteries rattle or crack
- The transmission countershaft bearing end clearance may not be within specification on some vehicles
- Stationary engine cover cracks
- Steering - revised camber specification
- Starter stays engaged after key is released
- Multi-piece driveshaft misalignment with center bearing
- A driveline vibration/moan may occur when the automatic transmission shifts into converter lockup mode...
VIN decoder
See the problems and recalls for an exact car
Buying a used 1994 Ford B Series?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history