2022 Ford Bronco Sport steering problems

Filed Oct 17, 2026 · Electrical, Lights · GA

Water is entering the vehicle and dripping onto the interior floorboards, particularly when the air conditioning is running.This has caused growth of mold and rust inside the vehicle. The vehicle has developed multiple dashboard warning lights, and the turn signals and windshield wipers have stopped functioning. Most concerning, the steering wheel has locked while the vehicle was in motion, leaving me unable to steer even though the engine remained running.This created a serious and immediate safety hazard. The vehicle has since become inoperable and will no longer start. The source of the water intrusion and the underlying causes of the electrical and steering failures have not been confirmed. However, the combination of water entering the vehicle, multiple warning lights, loss of turn signals and windshield wiper operation, loss of steering control while the engine remained running, and the subsequent failure to start raises serious concerns about the vehicle’s safety and possible electrical system damage. I took the vehicle in for an inspection to determine the cause of these problems\. I was informed that diagnostic testing would cost approximately $250 per dashboard warning light, potentially exceeding $1,000 before the underlying problems could be identified. I have not received a confirmed diagnosis of the cause of these failures. The vehicle is available for inspection upon request. Given the loss of steering control while driving, the failure of essential safety-related components, the water intrusion, and the vehicle’s current inability to start, I am requesting a thorough investigation into the cause of these failures and whether they are related to a known vehicle defect. The vehicle should not be operated until the safety issues have been properly diagnosed and corrected.

Filed Sep 22, 2026 · Steering, Suspension · IL

Front and rear axle, 4 wheel drive, and differential issues, causing steering, wheel, and driving issues. There is a nationwide back order on parts needed to repair this common, and known issue, leaving Ford service to return customers to continue driving unsafe vehicles until parts arrive. Despite Ford having knowledge of this safety hazard, there has been no recall.

Filed Sep 3, 2026 · Body, Steering · TX

When turning any direction or hitting speeds of 75 mph +, vehicle makes loud noise and starts shaking. Took it to an independent mechanic and ran a diagnostic, they said the rear differential is going out which isn't normal for vehicles with this mileage and said it was a manufacturer defect. When I took the vehicle to a Ford dealership, the tech laughed and said there's a one month wait for parts and 15 other Broncos in front of me dealing with the same issue.

Filed Jun 23, 2026 · Acceleration, Driver assistance · AZ · crash · 1 injury

We have a video of the incident from our ring camera: [XXX] My daughter pulled our 2022 Bronco Sport out of our driveway onto [XXX] and then made a right turn onto [XXX] After completing the turn, my daughter said the car pulled to the right like the lane assist kicked in and locked and would not allow her to turn the wheel. My daughter does not remember if any warning lights or messages lit up on her dashboard because the whole thing happened within a few seconds. She crashed into our next door neighbors concrete and cinderblock mailbox at low speed and then the Bronco immediately flipped over. The vehicle is at a local tow yard and available for inspection. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jan 5, 2026 · Steering · 80,000 miles · NE · fire

The contact owns a 2022 Ford Bronco Sport. The contact stated that while driving at an undisclosed speed, the contact turned on the heated steering wheel feature, and 30 seconds later, the steering wheel cover began to catch on fire with a blue flame; the contact discovered smoke coming from the steering wheel cover. The contact disengaged the heated steering wheel feature, where the flame self-extinguished. No warning lights were illuminated. The contact discontinued the usage of the heated steering wheel feature in order to avoid a large fire. A fire department report was not filed. A police report was not filed. The vehicle was not taken to a dealer; however, a dealer was contacted and made aware of the failure and informed that the vehicle caught on fire to resolve the failure with the vehicle's insurance. The vehicle was not repaired, but the contact was advised to buy a new steering wheel. The manufacturer was not notified of the failure. The failure mileage was approximately 80,000.

Filed Jun 15, 2025 · Lights, Steering · GA

I am not quite familiar with the name of the lights on the bottom of my vehicle they sometimes come on and sometimes they do not. When I back up it sounds like my tires are rubbing against something and when I pull forward it sounds the same.

Filed Jan 29, 2025 · Electrical, Lights · CA

First the battery was drained and needed replaced. Then message on center navigation screen displays “System Off to Save Battery. Please turn ignition off or start engine” when entering the car before trying to start it. Then I was notified of a recall that needed to be done. The recall was for “the body control module bcm and powertrain control module pcm calibrations may be unable to detect a sudden change in the 12-VOLT battery state of charge during a drive cycle.” The safety risk of this recall was as follows: “If the bcm and pcm calibrations are unable to detect a sudden battery degradation during a drive, the vehicle may be unable to restart after an auto stopstart event or may experience a stall while coming to a stop at low speed. The vehicle may also lose 12-VOLT accessories, including hazard lights. A loss of motive power can increase the risk of a crash.” The Ford Service Center did a software update to resolve this recall. Then the car started displaying a message on the dashboard front screen “Charging System Service Soon” and the battery light would be on. I also got a notification from my Ford app saying “Charge System Fault” “Indicates that there is a 12V charging system fault”.The car was taken to the Ford Service Center immediately and they said it just needed reprogrammed. The issue seemed to be solved on the short 5 minute drive home. The next day the car displayed the same “System Off to Save Battery” message on the middle navigation screen and “ Charging System Service Soon” message on the front dashboard screen. While driving the entire front dashboard electrical system turned off right after flashing multiple messages “front camera & pre collision assist not available”, no headlights and power steering went out, This happens randomly but happens every single time the car is driven. It is no longer safe to drive at night with no lights and no way to see any displays. Ford has been contacted with no response and service center will not see it.

Filed Nov 28, 2024 · Airbags, Steering · FL · crash · 2 injuries

I see steering recall on the internet but not under vin number for 2022 Ford Bronco Sport.

Filed Oct 30, 2024 · Brakes, Steering · FL

This is the 3rd time this vehicle has been in for service in less than three months. The initial two visits were for a differential issue that was not completely resolved. Also, the brakes seem to have unusual wear for the mileage of the vehicle. The current visit is happening as of today and the issues are being diagnosed and appear to be potentially possibly an electrical issue. There is also a very loud squealing sound when I back up and have been told by both the dealership and Ford that it is known but there is not yet a fix. I am on the phone with Ford letting them know I do not feel safe in the vehicle and they advised to file a report here.

Filed May 16, 2024 · Electrical, Lights · PA

On Monday [XXX], I was driving my vehicle home when I received the following error messages while driving: -pre collision assist not available -service advancetrac -check park aid -service vehicle soon -front camera fault service required -front camera fault service required -shift sys fault service required I was able to make it home and got my car towed to Washington Ford (Washington,PA) the next day. Ok Wednesday [XXX], I received the following message from Washington ford “ Your vehicle is done and ready to pick up. The concern was related to a reprogram of the power steering control module. --Andrea Baumgardner Washington Ford” I picked up the vehicle on Wednesday. On Thursday night, I was driving home after 12am when I received all the same above error messages that I noted as well as losing power steering and control of all my lights (headlights, turn signals, hazard lights). I had the car towed again the next day back to Washington Ford. Since then they have not been able to duplicate the problem and that there’s nothing more they can do. I was told “my vehicle is ready to pick up” but couldn’t guarantee it was safe to drive In April of 2024, Ford recalled 456,000 Ford broncos for “ because the vehicles may fail to detect a low battery charge, which could lead to a loss of engine and electrical power while driving.” Which is the exact issue I had with my vehicle two times in 3 days, however my vehicles VIN wasn’t included in that recalled. On May 13th, 2024 expanded the recall and my vehicle was included this time. I was told there was no remedy for the recall at this time and they were expecting a new update on May 29th, 2024 but in the meantime they are not offering me a rental car and told me my only option is to get a rental car myself if I feel that the car is unsafe to drive. I can not afford a rental car. So my only option ford leaves me is to drive a vehicle that they can not guarantee is safe to drive since they aren’t able to duplicate INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INF