Tl*the contact owns 1996 ford bronco. The contact stated that when the cruise control switch was engaged, the vehicle begin to accelerate beyond its set speed. The contact was driving 55 MPH. The contact did not call the manufacturer. The dealer informed the contact that the cruise control switch needed to be replaced. The contact replaced the cruise control with a used cruise control switch and that has remedied the failure. The contact stated that the faulty cruise control could have caused a crash. The failure mileage was 203,000.
1996 Ford Bronco: adaptive cruise control problems
13 of the 81 complaints about the 1996 Ford Bronco describe adaptive cruise control problems.
- owner complaints
- 13
- of this car's complaints
- 16%
- typical mileage
- 105,000
- recalls
- 0
Is there a fix? No recall or service bulletin covers this area of the car yet.
Adaptive cruise control problems by model year
What owners say
Tl*the contact owns a 1996 ford bronco. The vehicle caught fire after being parked for 20 minutes. The vehicle had previously been driven for 30 minutes and the cruise control was not activated. The fire department extinguished the fire. The vehicle was destroyed and towed. The fire department stated that the cause of the fire was electrical. The manufacturer stated that the VIN was not included in the federal safety agency campaign id number 07v336000 (vehicle speed control). The current and failure mileages were 120,000. Updated 11/26/07
The ford bronco was sitting in front of my car. Overnight the car caught fire and burned the front console of the car and below the dashboard. The hottest point of the fire was underneath the hood where the metal turned white and destroyed the paint. A claim filed with ford was filed after the recall for the cruise control switch was issued a few weeks after the fire. Ford denied the claim because they could not locate the switch, which, accordingly to the local ford dealership, was not in the engine block.
The consumer received a recall notice to have 1996 ford bronco cruise control disconnected. *ts ford recall #05s28. An additional three-month delay was issued before the repair could take place. The consumer felt that this was irresponsible of ford.
1. General use of the vehicle 2. Cruise control stopped working. Brake fluid dark/leaking out. Brake pressure switch caught on fire and burned. 3. I will have to get a new switch.
Dt: the contact owned a 1996 ford bronco. The vehicle caught on fire in early june 2005. The fire occurred in the wire cluster that connected into the front of the master cylinder. The fire was first noticed coming from the engine compartment. The vehicle was not operating unusualky before the fire started. Contact only had the vehicle for a couple of months and the cruise control did not work. Heard about the cruise control recall but did not pay attention to it. This was an electrical fire. The vehicle was repaired by bypassing the cruise control and wiring it. Insurance company paid for the repairs.
Fire in engine compartment caused by cruise control brake switch. My first indication of a problem was that my cruise control did not work. I went to my garage and found that a fuse had blown. When I replaced the fuse, the switch assembly, located directly above the brake fluid tank, immediately ignighted, which destroyed the switch and melted part of the brake fluid. We put out the fire with an extinguisher, bought and installed a replacement switch, and it now seems to be working ok. I had figured it was an isolated incident, until I learned it has happened to hundreds of other people and that a "partial" recall has been conducted by ford, but the recall did not include my vehicle. Now I'm afraid I may have another fire. I became aware of this by watching a cnn news story on the problem.
While cleaning my 96 bronco I noticed smoke coming out of the left side of the hood. After opening it, I saw the cruise control box to be smoking heavily. I poured water on it and cooled down the superheated device. Except for the cruise control not working, I did not encounter any other problems. Lately I've been reading about investigations into potential systematic defects of the cruise control of ford trucks and extensive recalls due to that problem. The symptoms described are matching what happened to my car - I seem to just have been lucky to be present. I reported the incident to my car dealer and to ford but both denied a claim because there was no recall on my kind of vehicle. There have been recalls on ford f150 trucks but I could not find any regarding the bronco model which is surprising since both cars are essentially the same except for the flat bed.
Cruise control and brake lights quit working. Replaced fuse and it blew and still no brake lights or cruise. The problem is the brake pressure switch that controls the cruise goes bad and causes fuse to blow and cruise does not work and brake lights will not work. After finding the problem I replaced the switch with a new one from moses ford. Within two weeks fuse blown again and switch was bad again. When switch goes bad it allows brake fluid through switch and onto the wiring leaching up harness and to a larger harness and the fluid caused a short which melted harness. I fortunately saw it had melted and have left harness unplugged since. Now because of the two defective switches it ruined cruise servo and harness. I was totally unaware of brake lights being out until my wife followed me home one night I thought it was just cruise problem. Failure is not corrected as the design of the switch is poor and each one results in same problem and now melted harness needs replaced, which entails replacing the entire underhood wiring harness at a cost of $400 plus labor. There is a recall pending on f150 from 1995-1999 but bronco is not listed when in fact the bronco uses the same harness and switch as the f150. Saw the article online herehttp://abcnews.go.com/business/wirestory?id=608161
While parked for twenty hours cruise control switch ignitied by itself. As a result, vehicle caught on fire. The owner was able to save the vehicle.
In regaurd to investigation ea 05-005 headed up by bruce york; I have a 1996 ford bronco that the speed control deactivation switch also shorted out. It did not result in a fire but the cruise control doesn't work. The wires are burnt right next to the switch and the switch is full of fluid. I currently drive it as is with the wires pulled away but every thing is still in the truck if any investigators want to see it. I see no mention of the bronco in the investigation but the same thing happened to me. I was fortunate. No fire
At approximately 2am on september 8, 2004, I received a call from my neighbor informing me that my 1996 ford bronco was on fire. When I ran outside, there were flames "shooting" several feet into the air. The source of the fire was the front of the vehicle, in the engine compartment. The front tires had blown from the heat and the fire had melted the dash and was into the passenger compartment. The fire dept was called and were able to extinguish the blaze within a few minutes of their arrival. However, the vehicle was a total loss (I have digital pictures). The fire seems to have started on the drivers side in the engine compartment since that was the area where the fire was the hottest. (the lead wheel weights actually melted) since then I have heard quite a few stories of similar occurrences with with ford broncos, explorers, and f150 pick ups of model years ranging from 1996 through 2002. One of the common elements in a significant number of these events, according to a recent article in the local newspaper, is that the cruise control on the vehicles that burnt had failed. That was true with my vehicle. The cruise control had not worked for the last 6 months or so. My vehicle had been parked for approximately 18 hours prior to this event.
Related recalls
No recalls on record for this model year.
Questions about the 1996 Ford Bronco adaptive cruise
Is adaptive cruise control problems a common problem on the 1996 Ford Bronco?
13 of 81 owner complaints about the 1996 Ford Bronco (16%) mention adaptive cruise control problems. The model year with the most reports is 1996.
Is there a recall or service bulletin for this on the 1996 Ford Bronco?
There is no recall or service bulletin for this area of the car on record.
Other symptoms on the 1996 Ford Bronco
VIN decoder
See the problems and recalls for an exact car
Buying a used 1996 Ford Bronco?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history