2025 Ford Bronco engine problems

Filed Sep 18, 2026 · Body, Electrical · 500 miles · GA

The contact's wife owns a 2025 Ford Bronco. Upon taking delivery of the vehicle, the door stops on both rear doors began detaching and the plastic fender components fell off while the vehicle was parked. Additionally, the rear passenger’s side window intermittently failed to roll up. The contact then received notifications of the federal safety agency Campaign Numbers: 26V468000 (Engine, Electrical System) and 26V403000 (Structure). The vehicle was taken to the dealer for a wiring harness recall repair; however, the dealer stated that the fix was ineffective and too complex to perform. The manufacturer was notified of the issue and confirmed that parts were available; however, the vehicle was unrepaired. The failure mileage was approximately 500.

Filed Aug 24, 2026 · Electrical, Engine · FL

The contact owns a 2025 Ford Bronco. The contact received notification of the federal safety agency Campaign Number: 26V468000 (Engine, Electrical System); however, the part to do the recall repair was not available. The dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure.

Filed Jun 3, 2026 · Driver assistance, Engine · AZ

Car would shut off shortly after using remote start on key fob then display a warning on digital instrument cluster for two days now. It would also show my speed going back and forth from 0 to 1mph while parked.

Filed May 20, 2026 · Engine · MD

On [XXX] at [XXX] PM I was driving westbound on [XXX] at [XXX] while traveling through the intersection, my vehicle started shaking, lost acceleration, and nearly caused me to have a collision. My vehicles check engine light began flashing, and I was able to safely exit the highway. On May 20, 2026, Crouse Ford diagnosed a “cylinder #6”, however attributed the event as “an anomaly”, and no corrective action was taken despite the seriousness of the safety concerns. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Mar 17, 2026 · Engine · 13,500 miles · IL · fire

The contact owned a 2025 Ford Bronco. The contact stated while driving 30 MPH, another driver pulled closer to the vehicle and honked to get the contact's attention. The contact stated that upon rolling down the window, the contact noticed flames coming from the front driver's side wheel well. There was no warning light illuminated. The contact was able to pull over to the side and exited the vehicle. The contact stated that the vehicle completely burned from the front end to the front seats. The contact stated that the fire originated from the driver's side of the engine compartment. The front driver's side of the vehicle sustained more fire damage than the passenger's side of the vehicle. The fire was extinguished by the fire department. A fire department report and a police report were filed. There was no reported injury. The vehicle was towed to a tow yard. The vehicle was a total loss. The dealer and the manufacturer were not contacted. The failure mileage was approximately 13,500.

Filed Feb 19, 2026 · Brakes, Engine · FL · crash

on Jan 15, 2025. A cold start for the Bronco, putting in reverse, the vehicle lurched back and to the hard right, uncommanded acceleration at a high rate of speed, steering locked up, brakes locked up, tires spinning, engine revving causing the bronco to smash into the exterior of my home garage area. Then, shifting to drive, the vehicle again lurched, uncommanded acceleration hard to the left now, steering locked up, brakes locked up, tires spinning engine revving traveling 20-30 feet crashing into the electrical box coming to rest on top of it. Numerous faults showing multiple systems malfunctioning causing this incident.

Filed Jan 15, 2026 · Acceleration, Electrical · FL

While slowly backing into our home garage, the vehicle accelerated brakes were not working and smashed into the side of the house, put the car in drive to move it. It accelerated forward over correcting and drove into our power box and came to a halt. No brakes were working and the wheels/steering locked up.

Filed Jan 8, 2026 · Electrical, Engine · AK

While driving, after a missed downshift that causes engine bogging, the vehicle experiences a loss of engine power. The engine remains running but will not produce usable torque and will not rev above approximately 800 RPM, despite clutch disengagement and selecting the correct gear. Holding the clutch fully depressed does not immediately restore power; instead, after approximately 4 seconds, the engine stalls or cycles/resets, after which normal operation resumes. The condition persists until the vehicle nearly stops, the engine stalls, or the ignition is cycled. This has occurred in traffic and adverse weather conditions and is repeatable.”

Filed Sep 8, 2025 · Acceleration, Engine · AZ

I was driving the vehicle on high mountain pass roads in Colorado. Anytime I would approach approximately 11,400 feet of elevation. The vehicle would instantly lose all power with no warning lights of any kind. All gauges were in the normal operating range. Vehicle would barely move 2 mph. Created a very unsafe condition on narrow steep dirt roads in the mountains. As soon as I turned around and descended approximately 100 feet in elevation the power came back instantly and vehicle operated normally. This happened on three occasions. The roads we were on were narrow, off-road vehicle mountain roads, and it created an extremely dangerous situation. I contacted Ford and they have not heard of this issue and there are no recalls associated with it. I spoke to a Ford bronco ambassador, who was also on the trail system with a lot of other off-road vehicles, including Broncos and they had never heard of this happening . This vehicle is Six months old. Ford says there are no codes set on my computer and since they cannot duplicate this where I live in Phoenix because there are no roads high enough I don’t know where to turn.

Filed Aug 8, 2025 · Engine, Transmission · VA

2025 Bronco Sport Safety Recalls* Replace instrument panel cluster Recall incomplete Block heater element replacement Recall incomplete Cylinder head replacement Recall incomplete Cylinder head inspectionreplacement Recall incomplete DO NOT DRIVE! RECOMMENDED TO REPORT NATIONAL ALERT FOR OWNERS OF THIS VEHICLE TYPE. INVESTOR REPORTING FOR BROADCAST RECALL ALERT!